High Performance Liquid Chromatography of Mouse Monoclonal Antibodies on Spherical Hydroxyapatite Beads

Abstract

High performance liquid chromatography (HPLC) on newly developed spherical beads of hydroxyapatite was applied for the simple purification of monoclonal antibodies (mAbs) secreted into mouse ascitic fluid. Sixteen mAbs including all four subclasses of IgG and IgM were separated successfully from serum albumin a major contaminant in the crude mAb preparation by a 30 min-linear gradient of phosphate ion concentration from 0.01M-0.3M at pH 7.2. Not only IgG mAbs but also IgM mAbs were quantitatively eluted from the column. Each antibody had a different retention time (apparent capacity factor of 2.24–4.14) in the chromatography and no relation was found between the retention time and the type of immunoglobulin (class or subclass). A monomeric form of IgM was also resolved successfully from IgM (pentamer) after its reduction with dithiothreitol; the monomer form of IgM was eluted from the column by a lower concentration of phosphate ion than was the pentamer. These results indicate that HPLC on the hydroxylapatite beads will be useful for the purification and characterization of mouse mAbs.     

An Enzyme-Linked Immunosorbent Assay (Elisa) for Measurement of Human Igg Subclass Levels in Serum

Abstract

We established an enzyme-linked immunosorbent assay (ELISA) to quantify human IgG subclasses in serum. IgG subclasses captured with subclass-specific mouse MoAbs could be detected with enzyme-labeled goat anti-human IgG. We screened the MoAbs which were suitable for the method from the commercially available MoAbs raised against human IgG subclasses. The specificity of the present ELISA for each subclass was clarified by the experiments as follows: (a) identification of individual IgG subclasses purified from total IgG by protein A column chromatography and (b) identification of a certain specific subclass which increased relatively in monoclonal (M)-proteinemia-patient sera compared with normal. We could detect each subclass with the sensitivity of 4.0 ng/ml for IgG₁, 13 ng/ml for IgG₂, 0.5 ng/ml for IgG₃ and 0.4 ng/ml for IgG₄ using pooled normal serum calibrated against a reference serum 67/86 from the World Health Organization (WHO) as a standard.     

Isolation and preparative purification of microcystin variants

Preparative reversed-phase liquid chromatography was successfully used to purify two microcystins (microcystin LR and microcystin LA) from a cyanobacterial process waste. The separation protocol involved extraction of lyophilized cells by methanol, isolation and concentration by solid-phase extraction, and purification by reversed-phase HPLC. Milligram-level loading of microcystins was obtained on a solid-phase extraction cartridge packed with 0.5 g of C18 stationary phase. The separations were first carried out on an analytical column and then scaled-up to a preparative column. The microcystins were quantified by HPLC and enzyme-linked immunosorbent assay. A method to remove microcystins rapidly and economically from the cyanobacterial process waste is also described.     

Synergistic Use of Countercurrent Chromatography and High Performance Liquid Chromatography for the Purification of Synthetic Peptides

Abstract

Examples are given demonstrating how countercurrent chromatography (CCC) and high performance liquid chromatography (HPLC) can be used together to purify synthetic peptides. In one example, CCC provided a preliminary purification of Met-Arg-Asp-Val-Val-Leu-Phe-Glu-Lys by enabling separation of ultraviolet absorbing, ninhydrin-negative material from the desired peptide. Final purification was achieved with HPLC without risk of harming the HPLC column. In a second example Tyr-Ala-Ala-Nle-Ala-Ala was completely purified by CCC with the CCC separation rapidly and conveniently monitored by HPLC. CCC appears to be a very useful technique for the peptide chemist.     

在线单柱二维液相色谱法快速纯化牛胰腺中细胞色素C

用二维（弱阳,疏水）色谱柱首次完成了在线单柱二维液相色谱法快速纯化牛胰腺中的细胞色素C.在将牛胰腺粗提液进样到该二维色谱柱后,在弱阳离子交换模式下,以梯度洗脱方式进行一维色谱分离,并将分离得到的细胞色素C样品液收集到色谱仪的附加样品储液管内.然后将储液管中样品液全部排出,并二次进样到同一根二维色谱柱中,与此同时也完成了对该样品液的缓冲溶液交换,按疏水色谱（HIC）分离模式进行分离.最终对细胞色素C完成了第二维的HIC纯化.上述全部操作均为在线,在一具有正压的封闭体系中进行并可在52分钟内完成.细胞色素C的最终产品纯度高达94.7%（RSD=1.91%）,质量回收率为80.5%（RSD=2.20%）.预计此在线单柱二维液相色谱法也可能用于牛胰腺中其他功能蛋白的快速纯化,并可能将其放大到制备和生产规模.     

UV-based solvent system screening for high-speed counter-current chromatography fractionation of compounds with similar UV absorption from complex samples followed by preparative HPLC purification: Flavonoids from barley seedlings as sample

This article proposes a solvent system screening strategy for compounds with similar UV absorption in complex samples by UV spectrophotometer. There is no need to calculate the partition coefficient value of each compound, only the partition coefficient of the whole sample. The partition coefficient value should be close to 1 in order to obtain as many high-speed counter-current chromatography fractions as possible. Then, preparative HPLC was used to purify the high-speed counter-current chromatography fractions. Based on the above strategy, seven c-glycosyl flavonoids and an amino acid were successfully obtained from barley seedlings through high-speed counter-current chromatography fractionation with ethyl acetate/n-butanol/water (8:2:10, v:v:v) system followed by preparative HPLC purification. The research shows that high-speed counter-current chromatography could be well developed as a tool for fractionation before purification, and greatly improves the separation efficiency.     

Fast and efficient separation of immunoglobulin M from immunoglobulin G using short monolithic columns

Certain diagnostic, analytical and preparative applications require the separation of immunoglobulin G (IgG) from immunoglobulin M (IgM). In the present work, different ion-exchange methacrylate monoliths were tested for the separation of IgG and IgM. The strong anion-exchange column had the highest dynamic binding capacity reaching more than 20mg of IgM/ml of support. Additionally, separation of IgM from human serum albumin, a common contaminant in immunoglobulin purification, was achieved on the weak ethylenediamino anion-exchange column, which set the basis for the IgM purification method developed on convective interaction media (CIM) supports. Experiments also confirmed flow independent characteristics of the short monolithic columns.     

Membrane affinity chromatography for analysis and purification of biopolymers

Summary Affinity columns suitable for HPLC were prepared by immobilization of various ligands of protein A, human IgG, human IgM and pectinase on GMA modified cellulose membrane. The adsorption capacity, affinity efficiency and activity recovery of various IgGs on these affinity columns were measured. It was observed that the length of the coupling arm plays a very important role in affinity efficiency, and the effect of eluent flow-rate on adsorption capacity was very small. The protein A column was exploited for the process monitoring of dog IgG in clinical experiments on immuno-adsorption therapy. A pectinase column was used for the determination of polygalacturonase inhibiting proteins first purified on a hydroxyapatite column. It took only about 2.5 min for analysis at a flow-rate of 1.0 mL min⁻¹. The high speed analysis of biopolymers could be performed at a flow rate of 6.0 mL min⁻¹ within 15 s. Membrane affinity chromatography gives good reproducibility, high efficiency, low column-pressure and is rapid. It can also be used for micro-scale purification of biopolymers.     

High-performance liquid affinity chromatography for the purification of immunoglobulin A from human serum using jacalin

A high-performance liquid affinity chromatographic method for the purification of serum immunoglobulin A (IgA) using a jacalin column is described. The automated procedure takes about 2 with minimal manipulation. The yields of the isolated IgA and of its IgG and IgM contamination were studied by enzyme-linked immunosorbent assay (ELISA) of 30 sera. Purity was assured by immunoelectrophoresis. The ratio of IgA1 to total IgA was unchanged after purification, as verified by ELISA. The results showed that greater than 90% IgA could be recovered with less than 0.5% total IgG and greater than 2.0% total IgM remaining in the fractions containing purified IgA.     

液相色谱法分离胃蛋白酶原

首次应用高压凝胶过滤色谱和中压阴离子交换色谱提纯胃蛋白酶原,得到抗原ＰＧⅠ和ＰＧⅡ,一次提纯仅需５０ｍｉｎ。与以往文献报道的胃蛋白酶原纯化方法相比,具有简易、快速、高效的特点。     

Integrated process for the purification of antibodies combining aqueous two-phase extraction, hydrophobic interaction chromatography and size-exclusion chromatography

We have evaluated a process incorporating aqueous two-phase extraction, hydrophobic interaction chromatography (HIC) and size-exclusion chromatography (SEC) for the purification of human immunoglobulin G (IgG) from a Chinese hamster ovary (CHO) cell supernatant. These unit operations were chosen not only for allowing the removal of target impurities but also for facilitating the integration of different process units without the need for any conditioning step. Extraction in aqueous two-phase systems (ATPSs), composed of polyethylene glycol (PEG) and sodium citrate, allowed the concentration of the antibodies in the citrate-rich phase and the removal of the most hydrophobic compounds in the PEG-rich phase. An ATPS composed of 10% (w/w) PEG 3350 and 12% (w/w) citrate, at pH 6, allowed the recovery of IgG with a 97% yield, 41% HPLC purity and 72% protein purity. This bottom phase was then directly loaded on a phenyl-Sepharose HIC column. This intermediate purification step allowed the capture of the antibodies using a citrate mobile phase with 99% of the antibody recovered in the elution fractions, with 86% HPLC purity and 91% protein purity. Finally, SEC allowed the final polishing by removing IgG aggregates. HIC-eluted fractions were directly injected in a Superose 6 size-exclusion column affording a 100% pure IgG solution with 90% yield.     

反相液相色谱法制备纯化柠檬苦素类似物配糖体

 利用反相制备液相色谱结合吸附树脂柱色谱和离子交换色谱方法 ,从甜橙种子的提取物中纯化制备了一种柠檬苦素类似物配糖体 ,经 NMR测定为奥巴叩酮配糖体。     

Simultaneous isolation of artemisinin and its precursors from Artemisia annua L. by preparative RP-HPLC

It is still a major challenge to simultaneously isolate artemisinin and its precursors, especially dihydroartemisinic acid and artemisinic acid, from herbal Artemisia annua. A rapid, economical and automatical chromatographic separation process to isolate and purify artemisinin, dihydroartemisinic acid and artemisinic acid at the same time on a preparative scale was developed. The procedure included solvent extraction of ground Artemisia annua leaves by refluxing and purification of crude extract by preparative reverse-phase high-performance liquid chromatography (RP-HPLC). Fractions containing artemisinin and its precursors were collected and identified by gas chromatography and mass spectrometry. High purity of artemisinin, dihydroartemisinic acid and artemisinic acid was obtained by preparative HPLC with a C(18) column and 60% acetonitrile in water as the mobile phase. The techniques described here are useful tools for the preparative-scale isolation of artemisinin and its precursors in a fast, cost-effective and environmental friendly manner.     

Purification and preparation of compounds from an extract of Scutellaria barbata D. Don using preparative parallel high performance liquid chromatography

Preparative parallel high performance liquid chromatography combined with solvent partition and other pretreatments were adopted to separate and purify compounds from an extract of Scutellaria barbata D. Don. Mass-triggered fraction collection allowed the rapid and precise isolation of target compounds. Twelve compounds were isolated from the extract of S. barbata D. Don, their purity in area percent was determined by HPLC analysis, and the structures of seven compounds were further identified with HPLC/ESI-MS, (1)H NMR, and( 13)C NMR, among which 4-(3,4-dihydroxy-phenyl)-but-3-en-2-one, acacetin-7-diglucuronide, and luteolin-7-diglucuronide were the first to be identified from this plant. The results demonstrated that multi-channel parallel preparative HPLC/UV/MS is an efficient method for isolation and purification of compounds from natural products.     

Exploiting pH mismatch in preparative high-performance liquid chromatographic recovery of ertapenem from mother liquor streams

Preparative chromatography was successfully employed to recover ertapenem from mother liquor streams. The recovery process involved concentration of mother liquor stream by evaporation, purification by reversed-phase preparative high-performance liquid chromatography (HPLC), and removal of chromatographic solvents in the recovered fractions by evaporation. HPLC feed was prepared by stripping off the organic solvents from the mother liquor using a wiped-film evaporator. Purification was first carried out on a 25 cm x 0.46 cm analytical column packed with 10-microm Kromasil C8 particles and then scaled up to a 25 cm x 5 cm preparative column. Gram-level recovery of ertapenem with high purity was achieved by exploiting a novel approach based on pH mismatch between the feed and the eluent. Purified ertapenem streams from preparative HPLC runs were combined, evaporated and recycled into the crystallizer for ertapenem isolation.     

Single-step purification of rat C-reactive protein and generation of monospecific C-reactive protein antibody

Although Sepharose-phosphorylcholine affinity chromatography has been used extensively to purify some acute phase proteins, the operation has usually been a laborious multi-step procedure. By modifying previously described multi-step protein purification assays, centigram quantities of pure rat C-reactive protein (CRP) could be obtained in a single chromatographic step using affinity chromatography. Rat serum was passed over a column of p-aminophenylphosphorylcholine and extraneous proteins eluted with Tris-saline-Ca2+ buffer. Similar to other purification procedures, CRP was eluted with phosphorylcholine in a Tris-saline-Ca2+ buffer. The technical detail which distinguished this procedure from others, was the use of a phosphorylcholine gradient shallow enough (0.95 mM-2.5 mM) to resolve the eluent into two peaks; the first peak was composed largely of the contaminant, serum amyloid protein (SAP), and the second was composed of CRP. Although there was some overlap between the first and second peak, pure CRP could be obtained by pooling fractions from the trailing shoulder of the second peak. Using this single step procedure, a greater than 25% yield of SAP-free, purified CRP could be obtained. The purified CRP was free of SAP contamination as measured by sodium dodecyl sulfate gradient polyacrylamide gel electrophoresis. Purified CRP was determined to be free of rat albumin, IgG and the C3 component of complement using immunoelectrophoresis. This one-step affinity column chromatography procedure provides a simple, efficient method for collecting large quantities of rat CRP pure enough to be used to obtain a monospecific goat, anti-rat CRP antibody.     

Rapid Purification of Fucoxanthin from Phaeodactylum tricornutum

Fucoxanthin is a natural marine xanthophyll and exhibits a broad range of biological activities. In the present study, a simple and efficient two-step method was used to purify fucoxanthin from the diatom, Phaeodactylum tricornutum. The crude pigment extract of fucoxanthin was separated by silica gel column chromatography (SGCC). Then, the fucoxanthin-rich fraction was purified using a hydrophile–lipophile balance (HLB) solid-phase extraction column. The identification and quantification of fucoxanthin were determined by high-performance liquid chromatography (HPLC) and electrospray ionization mass spectrometry (ESI-MS). This two-step method can obtain 92.03% pure fucoxanthin and a 76.67% recovery rate. In addition, ¹H and ¹³C NMR spectrums were adopted to confirm the identity of fucoxanthin. Finally, the purified fucoxanthin exhibited strong antioxidant properties in vitro with the effective concentration for 50% of maximal scavenging (EC50) of 1,1-Dihpenyl-2-picrylhydrazyl (DPPH) and 2,2′-Azinobis-(3-ethylbenzthiazoline-6-sulphonate) (ABTS) free radicals being 0.14 mg·mL⁻¹ and 0.05 mg·mL⁻¹, respectively.     

Isolation of human serum immunoglobulins with a new salt-promoted adsorbent

In this work a highly acetylated-ethylenediamine-Novarose (HA-EDA-Novarose) gel was synthesized and used as a new agarose-based salt-promoted adsorption chromatography (SPAC) matrix to effectively isolate serum immunoglobulins without the need of denaturing conditions. Samples of human serum in 0.5 M Na2SO4, 10 mM 3-(N-morpholino)-propane-sulfonic acid (MOPS), pH 7.6 were applied to a chromatographic column packed with the SPAC gel. Immunoglobulins (Igs) with affinity for the HA-EDA ligands were specifically adsorbed to the matrix, non-bound serum proteins were readily removed by washing the column with the same feed solution buffer. Bound Igs were effectively and very gently eluted by simply removing the salt from the feed solution buffer. The elution buffer consisted thus of only 10 mM MOPS, at pH 7.6 and no salt. The salt-dependent adsorption capacity of this system was estimated to be 7.3 mg/ml with protein recovery of about 93%. Sodium dodecyl sulfate-polyacrylamide gel (SDS-PAGE) electrophoresis analysis, radial immunodiffusion and enzyme-linked immunosorbent assays showed that immunoglobulins G, M and A (IgG, IgM and IgA) were the main components present in the elution fraction. The new SPAC adsorbent was used to purify Igs from human serum and IgG and IgA from non-pure commercially available Igs preparations in a very gentle single step.     

Ion-exchange high-performance liquid chromatographic purification of bovine cardiac and rabbit skeletal muscle troponin subunits

Bovine cardiac and rabbit skeletal troponin complexes were separated into their respective subunits employing high-performance liquid chromatographic (HPLC) techniques on CM-300 and Q-300 ion-exchangers. Bovine cardiac and rabbit skeletal subunits were separated on the strong anion-exchanger, Q-300, in 8 M urea, 50 mM Tris, 2 mM EGTA, 0.5 mM dithiothreitol, pH 7.5, employing a linear salt gradient and on the weak cation-exchanger, CM-300, in 8 M urea, 50 mM potassium dihydrogen phosphate, 2 mM EGTA, 0.5 mM dithiothreitol, pH 6.5, using a linear salt gradient. To obtain complete purification of all components of troponin both ion-exchangers were required. The initial separation of troponin was carried out on the strong anion-exchanger followed by weak cation-exchange chromatography of the troponin I collected from the strong anion-exchange column. The troponin T subunits obtained from Q-300 chromatography demonstrated heterogeneity (three components: T1, T2 and T3) while the troponin I collected from both sources on the Q-300 column were both resolved into major doublets (I1 and I2) when rechromatographed on the CM-300 column. The three troponin T fractions and two troponin I fractions isolated from ion-exchange HPLC were examined by sodium dodecyl sulfate-urea polyacrylamide gel electrophoresis and two-dimensional gel electrophoresis to confirm that the heterogeneity was due to differences in charge and not molecular weight. These results were in agreement with the charge differences observed from retention times on ion-exchange HPLC. When comparing the same troponin subunit from different muscle sources, considerable differences in the content of charged amino acid residues were also observed.     

Selective high-performance liquid chromatographic purification of bispecific monoclonal antibodies.

The recent development of improved production techniques for bispecific monoclonal antibodies (biMAbs) has significantly increased interest in specific purification procedures. In this investigation, a general high-performance liquid chromatographic (HPLC) purification method is proposed that allows highly purified biMAbs to be obtained from mouse ascites fluid containing a mixture of different antibodies, i.e., parental MAbs, active biMAb and a mixture of randomly assembled heavy and light chains. Proteins from ascites fluid were precipitated with ammonium sulphate and applied to a high-performance protein A column to separate the total immunoglobulin fraction. BiMAbs were isolated from other immunoglobulins by two subsequent passages through a high-performance hydroxyapatite (HPHT) column. This purification protocol combines specificity of protein A for immunoglobulin G (IgG) and high selectivity of hydroxyapatite for different IgG idiotypes. All purification steps were performed rapidly and reliably by HPLC. This method was applied to the purification of six different biMAbs with consistently high yields, purity and homogeneity. This general purification method may prove extremely valuable when highly pure preparation of biMAbs is required, as for in vivo use.