Multicenter validation of PCR-based method for detection of Salmonella in chicken and pig samples

As part of a standardization project, an interlaboratory trial including 15 laboratories from 13 European countries was conducted to evaluate the performance of a noproprietary polymerase chain reaction (PCR)-based method for the detection of Salmonella on artificially contaminated chicken rinse and pig swab samples. The 3 levels were 1-10, 10-100, and 100-1000 colony-forming units (CFU)/100 mL. Sample preparations, including inoculation and pre-enrichment in buffered peptone water (BPW), were performed centrally in a German laboratory; the pre-PCR sample preparation (by a resin-based method) and PCR assay (gel electrophoresis detection) were performed by the receiving laboratories. Aliquots of BPW enrichment cultures were sent to the participants, who analyzed them using a thermal lysis procedure followed by a validated Salmonella-specific PCR assay. The results were reported as negative or positive. Outlier results caused, for example, by gross departures from the experimental protocol, were omitted from the analysis. For both the chicken rinse and the pig swab samples, the diagnostic sensitivity was 100%, with 100% accordance (repeatability) and concordance (reproducibility). The diagnostic specificity was 80.1% (with 85.7% accordance and 67.5% concordance) for chicken rinse, and 91.7% (with 100% accordance and 83.3% concordance) for pig swab. Thus, the interlaboratory variation due to personnel, reagents, thermal cyclers, etc., did not affect the performance of the method, which will be proposed as part of a developing international PCR standard.     

Validation of three rapid screening methods for detection of verotoxin-producing Escherichia coli in foods: interlaboratory study

An interlaboratory study was conducted for the validation of 3 methods for the detection of all verotoxin-producing Escherichia coli (VTEC) in foods. The methods were a multi-analyte 1-step lateral flow immunoassay (LFIA) for detection of E. coli O157 and verotoxin (VT); an enzyme-linked immunosorbent assay targeted against VT1, VT2, and VT2c (VT-ELISA); and a polymerase chain reaction (PCR) method for detection of VT genes (VT-PCR). Aliquots (25 g or 25 mL) of 4 food types (raw minced [ground] beef, unpasteurized milk, unpasteurized apple juice [cider], and salami) were individually inoculated with low numbers (<9 to 375 cells/25 g) of 6 test strains of E. coli (serogroups O26, O103, O111, O145, and O157) with differing VT-producing capabilities. Five replicates for each test strain and 5 uninoculated samples were prepared for each food type. Fourteen participating laboratories analyzed samples using the LFIA, 9 analyzed the samples by ELISA, and 9 by PCR. The LFIA for O157 and VT had a specificity (correct identification of negative samples) of 92 and 94%, respectively, and a sensitivity (correct identification of positive samples) of 94 and 55%, respectively. The VT-ELISA and VT-PCR had a specificity of 98 and 99%, respectively, and a sensitivity of 89 and 72%, respectively.     

RapidChek SELECT Salmonella enteritidis test system for the detection of Salmonella enteritidis in poultry house drag swabs, shell egg pools, and chicken carcass rinsates

The RapidChek SELECT Salmonella Enteritidis Test System was validated for the detection of Salmonella Enteritidis (SE) in poultry house drag swabs, shell egg pools, and chicken carcass rinsates. The method utilizes RapidChek SELECT Salmonella (AOAC PTM License No. 080601) proprietary primary and secondary enrichment media. Following enrichment, an immunochromatographic test strip is inserted into the tube containing the secondary enrichment broth, developed for 10 min, and interpreted. Salmonella Enteritidis-inoculated samples (1-5 CFU SE/analytical unit) were tested by the test method as well as the appropriate cultural reference method U.S. Food and Drug Administration-Bacteriological Analytical Manual (drag swabs and egg pools) or U.S. Department of Agriculture-Food Safety and Inspection Service (chicken carcass rinsates). A total of 80 samples were tested by both methods in the study. Fifty-two samples were positive by the RapidChek SELECT Salmonella Enteritidis method and 38 were found positive by the respective reference method. The sensitivity of the method was 100% and the specificity was 100%. The accuracy of the test method was 137%, indicating that the method was more sensitive than the reference method. The RapidChek SELECT Salmonella Enteritidis method was tested with 82 Salmonella Group D1 strains including 63 Salmonella Enteritidis strains as well as 32 non-Salmonella Group D1 strains representing 10 bacteria genera. The test method detected all 82 Group D1 strains (100% sensitivity). None of the non-Salmonella Group D1 or other genera of bacteria were detected, indicating a specificity of 100%. The method was shown to be highly robust and stable under control and accelerated stability conditions.     

Method validation by interlaboratory studies of improved hydrophilic oxygen radical absorbance capacity methods for the determination of antioxidant capacities of antioxidant solutions and food extracts

Hydrophilic oxygen radical absorbance capacity (H-ORAC) is a method for evaluating antioxidant capacities of solutions of hydrophilic compounds. In this study, we improved the original method for H-ORAC determination, and evaluated the precision of the two improved methods (methods A and B) by interlaboratory studies using 5 antioxidant solutions and 5 food extracts as test samples. An interlaboratory study of method A, in accordance with the harmonized protocol, demonstrated satisfactory performance (intermediate precision relative standard deviations (RSD(int)) ranging from 4.6 to 18.8%; the reproducibility relative standard deviations (RSD(R)) ranging from 7.0 to 21.1%, and the HorRat values ranging from 0.40 to 1.93). However, methodological problems remained, and a further improved method, method B, was thus developed. An interlaboratory study of method B by 5 participating laboratories showed better intermediate precision and reproducibility (RSD(int) and RSD(R) ranging from 1.8 to 9.4%, and from 4.4 to 13.8%, respectively), and all HorRat values for the test samples were less than 1.3, suggesting good performance for the H-ORAC measurement.     

Application of capillary isotachophoretic method to the determination of nitrate and nitrite ions in meat products

The application of capillary isotachophoretic method to the simultaneous determination of nitrates and nitrites in meat products was studied. Simple electrolyte system allowed separation of ions in standard solution with within-day and between-days coefficient of variation (CV) of relative step hight in the ranges 2.3–2.5% and 4.1–5.5%, respectively. The levels of nitrates and nitrites ranged from 3 to 65 mg/kg NaNO₃ and from 36 to 111 mg/kg NaNO₂. The coefficients of variation for nitrites were 0.7–3.5% and for nitrates 2.3–5.9%, that indicated satisfactory precision of the proposed method. The recoveries for meat samples spiked with nitrites and nitrates varied between 95–99% and 91–102%, respectively.     

Detection of Salmonella in fresh cheese,poultry products,and dried egg products by the ISO 6579 Salmonella culture procedure and the AOAC official method: collaborative study

Three food types were analyzed for the presence of Salmonella by the AOAC culture method and by the International Organization for Standardization (ISO 6579:2002) culture method. Paired test portions of each food type were simultaneously analyzed by both methods. A total of 21 laboratories representing federal government agencies and private industry, in the United States and Europe, participated in this interlaboratory study. Foods were artificially contaminated with Salmonella and competing microflora if naturally contaminated sources were not available. No statistical differences (p < 0.05) were observed between the AOAC and ISO culture methods for fresh cheese and dried egg products. A statistically significant difference was observed for one of the 2 lots of poultry from the first trial. The poultry meat used in this run was radiation sterilized, artificially contaminated with Salmonella and competitive flora, and then lyophilized. A second trial was conducted with 2 separate lots of raw ground chicken that were naturally contaminated. The results from the second trial showed no statistical difference between the 2 culture methods. A third trial involving 4 laboratories was conducted on 2 separate lots of naturally contaminated raw poultry. Again, no statistically significant differences occurred. It is recommended that ISO 6579:2002 culture method for Salmonella be adopted Official First Action for the analysis of fresh cheese, fresh chilled and frozen poultry, and dried egg products.     

Determination of cholecalciferol (vitamin D3) in selected foods by liquid chromatography: NMKL collaborative study

Results are presented from an NMKL (Nordic Committee on Food Analysis) collaborative study of a method for the determination of cholecalciferol (vitamin D3) in foods. The method is based on the addition of an internal standard (vitamin D2), followed by saponification and extraction with n-heptane. The fraction that contains vitamin D2/D3 is separated by preparative normal-phase liquid chromatography (LC), and the analytes are determined by reversed-phase LC with UV detection at 265 nm. The method was tested by 8 participating laboratories. In this study 6 different matrixes were analyzed for cholecalciferol content: milk, liquid infant formula (gruel), cooking oil, margarine, infant formula, and fish oil. The contents varied from 0.4 to 12 microg/100 g. Three matrixes (milk, gruel, and margarine) were fortified with vitamin D3. In the other matrixes, vitamin D3 was added at 3 different levels at the Swedish National Food Administration. The milk was analyzed as a blind duplicate, whereas the other matrixes were analyzed as split-level pairs. The recoveries from the samples with vitamin D3 added varied from 93 to 102%. The repeatability relative standard deviation (RSDr) values for accepted results varied between 2.2% (fish oil) and 7.4% (cooking oil), whereas the reproducibility relative standard deviation (RSD(R)) values varied between 6.8% (margarine) and 24% (cooking oil).     

Reveal Salmonella enteritidis test for detection of Salmonella enteritidis in shell eggs and environmental samples

Reveal Salmonella Enteritidis (SE) is a lateral flow-based immunodiagnostic assay used for rapid detection of Salmonella enterica serovar Enteritidis from pooled shell eggs and environmental samples. This assay uses highly specific antibodies to accurately detect S. Enteritidis. Studies were conducted to compare the performance of this test against reference procedures for detection of S. Enteritidis from both pooled shell eggs and environmental samples. Pooled shell eggs were inoculated with low levels ofS. Enteritidis and were enriched according to the procedure prescribed by the U.S. Food and Drug Administration. Uninoculated samples were included in each trial. Reveal SE exhibited 100% sensitivity and 100% specificity in comparison to the reference method in all trials. An abbreviated 48 h/(no hold) enrichment procedure was also developed and validated for detection ofS. Enteritidis from pooled shell egg samples. This shortened enrichment procedure can be used in conjunction with the Reveal SE test and offers a significant enrichment time savings of 96 h. Chi-square analysis revealed that there was no significant difference between the abbreviated Reveal method and the reference procedure for detection ofS. Enteritidis from pooled shell egg samples. Out of 245 natural drag swabs screened internally, only three samples tested Reveal SE positive and were confirmed by the reference procedure, resulting in 100% sensitivity and 100% specificity. An external laboratory screened 147 poultry house environmental samples and obtained 35 Reveal SE confirmed positives for Reveal SE sensitivity of 100% and specificity of 90%. Inoculation trials with drag swabs resulted in 96% sensitivity and 100% specificity. Thus, these data demonstrate that Reveal SE is a highly sensitive and specific assay for the detection of S. Enteritidis from both pooled shell eggs and environmental samples.     

Determination of semicarbazide in baby food by liquid chromatography/tandem mass spectrometry: interlaboratory validation study

An interlaboratory validation study funded by the European Commission, Directorate General for Health and Consumer Protection (DG SANCO), was conducted to evaluate the effectiveness of a liquid chromatography/tandem mass spectrometry (LC/MS/MS) method for the determination of semicarbazide (SEM) in different types of baby food at a possible future European regulatory limit (10 ng/g). The test portion of the sample was extracted with hydrochloric acid, and the analyte was derivatized with 2-nitrobenzaldehyde, with 1,2-[15N2, 13C] SEM as an internal standard. The extract was neutralized and then purified on a solid-phase extraction cartridge. The SEM was determined by reversed-phase LC with detection by MS/MS. Apple puree, rice pudding, and meat/vegetable meal baby food materials, spiked with SEM at levels of about 3, 10, and 30 ng/g, respectively, were sent to 20 laboratories in 12 different European countries, which submitted results from 17 participants. Recoveries ranged from 88.8 to 106.1%. Based on results for spiked samples (blind pairs at 3 levels), the relative standard deviations for repeatability (RSDr) ranged from 4.2 to 6.9% and the relative standard deviations for reproducibility (RSDR) ranged from 16.6 to 24.3%. The method showed acceptable within- and between-laboratory precision for all 3 matrixes, as evidenced by HorRat values, at the target levels for the determination of SEM.     

Toward an international standard for PCR-based detection of foodborne Escherichia coli O157: validation of the PCR-based method in a multicenter interlaboratory trial

The performance of a polymerase chain reaction (PCR) method for detection of Escherichia coli O157, previously validated on DNA extracted from pure cultures, was evaluated on spiked cattle swabs through an interlaboratory trial, including 12 participating laboratories from 11 European countries. Twelve cattle swab samples, spiked at 4 levels (0, 1-10, 10-100, and 100-1000 colony-forming units, in triplicate) with E. coli O157 were prepared centrally in the originating laboratory; the receiving laboratories performed pre-PCR treatment followed by PCR. The results were reported as positive when the correct amplicons were present after gel electrophoresis. The statistical analysis, performed on 10 sets of reported results, determined the diagnostic sensitivity to be 92.2%. The diagnostic specificity was 100%. The accordance (repeatability) was 90.0%, calculated from all positive inoculation levels. The concordance (reproducibility) was 85.0%, calculated from all positive inoculation levels. The concordance odds ratio (degree of interlaboratory variation calculated from all positive inoculation levels) was 1.58, indicating the robustness of the PCR method. Thus, the interlaboratory variation due to personnel, reagents, minor temperature or pH fluctuations and, not least, thermal cyclers, did not affect the performance of the method, which is currently being considered as part of an intenational PCR standard.     

Qualitative PCR method for Roundup Ready soybean: interlaboratory study

Quantitative and qualitative methods based on PCR have been developed for genetically modified organisms (GMO). Interlaboratory studies were previously conducted for GMO quantitative methods; in this study, an interlaboratory study was conducted for a qualitative method for a GM soybean, Roundup Ready soy (RR soy), with primer pairs designed for the quantitative method of RR soy studied previously. Fourteen laboratories in Japan participated. Each participant extracted DNA from 1.0 g each of the soy samples containing 0, 0.05, and 0.10% of RR soy, and performed PCR with primer pairs for an internal control gene (Le1) and RR soy followed by agarose gel electrophoresis. The PCR product amplified in this PCR system for Le1 was detected from all samples. The sensitivity, specificity, and false-negative and false-positive rates of the method were obtained from the results of RR soy detection. False-negative rates at the level of 0.05 and 0.10% of the RR soy samples were 6.0 and 2.3%, respectively, revealing that the LOD of the method was somewhat below 0.10%. The current study demonstrated that the qualitative method would be practical for monitoring the labeling system of GM soy in kernel lots.     

食品中沙门菌和单增李斯特菌的多重PCR-芯片电泳快速检测

建立了食品中沙门菌和单增李斯特菌的多重PCR-芯片电泳快速检测方法。根据沙门菌和单增李斯特菌的特征基因合成2对特异性引物,优化聚合酶链反应(PCR)体系,采用芯片毛细管电泳快速检测食品中上述2种致病菌的多重PCR扩增产物。在优化的实验条件下,6 min内即可完成沙门菌和单增李斯特菌的同时检测;迁移时间的日内精密度为0.20%～1.7%,日间精密度3.7%～4.5%。     

Reveal Salmonella 2.0 test for detection of Salmonella spp. in foods and environmental samples. Performance Tested Method 960801

Reveal Salmonella 2.0 is an improved version of the original Reveal Salmonella lateral flow immunoassay and is applicable to the detection of Salmonella enterica serogroups A-E in a variety of food and environmental samples. A Performance Tested Method validation study was conducted to compare performance of the Reveal 2.0 method with that of the U.S. Department of Agriculture-Food Safety and Inspection Service or U.S. Food and Drug Administration/Bacteriological Analytical Manual reference culture methods for detection of Salmonella spp. in chicken carcass rinse, raw ground turkey, raw ground beef, hot dogs, raw shrimp, a ready-to-eat meal product, dry pet food, ice cream, spinach, cantaloupe, peanut butter, stainless steel surface, and sprout irrigation water. In a total of 17 trials performed internally and four trials performed in an independent laboratory, there were no statistically significant differences in performance of the Reveal 2.0 and reference culture procedures as determined by Chi-square analysis, with the exception of one trial with stainless steel surface and one trial with sprout irrigation water where there were significantly more positive results by the Reveal 2.0 method. Considering all data generated in testing food samples using enrichment procedures specifically designed for the Reveal method, overall sensitivity of the Reveal method relative to the reference culture methods was 99%. In testing environmental samples, sensitivity of the Reveal method relative to the reference culture method was 164%. For select foods, use of the Reveal test in conjunction with reference method enrichment resulted in overall sensitivity of 92%. There were no unconfirmed positive results on uninoculated control samples in any trials for specificity of 100%. In inclusivity testing, 102 different Salmonella serovars belonging to serogroups A-E were tested and 99 were consistently positive in the Reveal test. In exclusivity testing of 33 strains of non-salmonellae representing 14 genera, 32 were negative when tested with Reveal following nonselective enrichment, and the remaining strain was found to be substantially inhibited by the enrichment media used with the Reveal method. Results of ruggedness testing showed that the Reveal test produces accurate results even with substantial deviation in sample volume or device development time.     

Determination of Nicarbazin in Animal Feed by High-Performance Liquid Chromatography with Interlaboratory Evaluation

A liquid chromatographic method was developed for the determination of nicarbazin in feed. The samples were extracted with 90 percent acetonitrile, purified on alumina, and analyzed by high-performance liquid chromatography. The developed method was validated in-house and further verified by interlaboratory studies. The limits of detection and quantification of the method were 0.05 and 0.10 milligram per kilogram, respectively. The recoveries of nicarbazin in feed ranged between 98.3 and 111 percent, with acceptable intralaboratory reproducibility. In the interlaboratory comparison, one contaminated and three uncontaminated poultry feed samples were analyzed by thirteen laboratories using the method developed in this study. Statistical analysis confirmed the accuracy and precision of the method with verification in the interlaboratory comparison.     

Determination of phosphorous in titanium bearing minerals by potentiometric titration using Pb-ion selective electrode

A method for phosphorous determination in titanium bearing minerals by potentiometric titration using a Pb-ion selective electrode has been developed. Sample decomposition is achieved by means of K(2)CO(3) fusion in a platinum crucible at 800 degrees C for 30 min in a muffle furnace, and subsequent leaching with water of the fused melt. The aqueous leachate is neutralised with HClO(4) and subsequent boiling. The obtained solution is used for titration with Pb(ClO(4))(2), and the Pb-ion selective electrode detects the end point. The lowest concentration determinable is 0.02% P(2)O(5) in a solid sample. The method was applied on in-house titanium bearing mineral samples and on IGS-31 ilmenite sample (British Geological Survey, UK). Synthetic samples were prepared and analysed, and phosphorous recovery is in the range 98-106%. The recovery and accuracy of the present method have been validated by spiking experiments and by comparing with the spectrophotometric values, respectively. The precision of the proposed method in terms of relative standard deviation is 2.0%.     

黄原脂棉富集—火焰原子吸收光谱法测定白酒中微量铅

探讨了黄原脂棉富集铅的条件,试验表明,pH为3－7时黄原脂棉能定量富集微量铅,以硝酸（1＋99）5ml,水浴20min即可定量解脱,用火争原子吸收光谱法进行测定,相对标准偏差为5．35％,回收率为98．8％－10．52％,结果满意。     

高分辨快速液相色谱-串联质谱法测定肉制品中的刚果红

建立了肉制品中刚果红的高分辨快速液相色谱-串联质谱(RRLC-MS/MS)测定方法。均质后的样品经乙腈与正己烷混合溶剂(1∶1)提取,乙腈提取层离心后直接上机测试。使用Agilent XDB C18色谱柱,以乙腈和10 mmol/L甲酸铵水溶液为流动相梯度洗脱,采用多反应监测方式(MRM)负离子模式检测,定量离子对与定性离子对分别为m/z 325.0/416.0与m/z 651.0/152.0,外标法定量。结果表明,刚果红在0.1～10mg/L范围内线性关系良好(r2>0.999),加标回收率为91%～102%,RSD为1.2%～4.0%,检出限与定量下限分别为0.07 mg/kg和0.18 mg/kg。该方法准确、高效,可用于肉制品中刚果红染料的快速检测。     

Proficiency testing of eight French laboratories in using the AOAC mouse bioassay for paralytic shellfish poisoning: interlaboratory collaborative study

In an interlaboratory study, 8 French laboratories were tested for their proficiency in using the AOAC mouse bioassay for paralytic shellfish poisoning (PSP). Each laboratory received 1 saxitoxin (STX) standard solution, 1 STX acidified water solution for determination of the titer, 1 noncontaminated shellfish sample, 1 naturally contaminated shellfish sample, and 2 shellfish samples spiked, respectively, at low (152.8 microg STX/100 g meat) and moderate (334.7 microg STX/100 g meat) levels. All samples were analyzed in duplicate. Mean recoveries were 35.1% for the low level and 46.6% for the moderate level. Relative standard deviations (RSD) for within-laboratory variations (repeatability) ranged from 5.4 to 9.8%; RSD for between-laboratory variations (reproducibility) varied from 7.8 to 39.6%, depending on STX level. On the basis of overall performance, all 8 participating laboratories were proficient in their use of the AOAC mouse bioassay.     

A flow injection sampling resonance light scattering system for total protein determination in human serum

A novel flow injection method with resonance light scattering detection was developed for the determination of total protein concentrations. This method is based on the enhancement of RLS signals from Methyl Blue (MB) by protein. The enhanced RLS intensities at 333 nm, in a pH 4.1 acidic aqueous solution, were proportional to the protein concentration over the range 2.0-37.3 and 1.0-36.0 microg ml-1 for human serum albumin (HSA) and bovine serum albumin (BSA), respectively. The corresponding limits of detection (3sigma) of 45 ng ml-1 for HSA and 80 ng ml-1 for BSA were attained. The method was successfully applied to the quantification of total proteins in human serum samples, the maximum relative error is less than 1% and the recovery is between 98% and 102%. The sample throughput was 60 h-1.