Effect of microwave dielectric heating on intraparticle diffusion in reversed-phase liquid chromatography

The influence of microwave (MW) irradiation on the mass transfer kinetics in reversed-phase liquid chromatography (RPLC) was studied by placing a column in a microwave oven and measuring the incremental change in the temperature of the column effluent stream at various microwave energies and mobile phase compositions. The microwave energy dissipated in the column was set between 15 and 200 W and the mobile phase composition used varied from 100 to 70, 50, and 10% methanol in water at 1.2 mL/min. At all the mobile phase compositions considered, the effluent temperature increased with increasing microwave energy. At 70% methanol, the mobile phase flow rate was set at 1.2, 2.0, and 2.8 mL/min. At 1.2 mL/min, the effluent temperatures at the lowest (15 W) and highest (200 W) microwave energy inputs were 25 +/- 1 degrees C and 41 +/- 1 degrees C for pure methanol, 25 +/- 1 degrees C and 48 +/- 1 degrees C for 70% methanol, 25 +/- 1 degrees C and 50 +/- 1 degrees C for 50% methanol, and, 25 +/- 1 degrees C and 52 +/- 1 degrees C for 10% methanol, respectively. With 70% methanol and microwave energy inputs of 15, 30, and 50 W, the effluent temperature did not change with increasing flow rate; a considerable change was observed at 100, 150, and 200 W between 1.2 and 2.0 mL/min and none between 2.0 and 2.8 mL/min. Chromatographic elution band profiles of propylbenzene were recorded under linear conditions, in 70% methanol solutions, for microwave energy inputs of 0, 15 and 30 W, at constant temperature. The intraparticle diffusion coefficient, De, under microwave irradiation was ca. 20% higher than without irradiation. These preliminary results suggest that microwave irradiation may have a considerable influence on intraparticle diffusion in RPLC.     

Comparison of chromatographic band profiles obtained under microwave irradiated and non-irradiated reversed-phase liquid chromatography column

The possible influence of the application of microwave energy to a reversed-phase liquid chromatography column on the mass transfer kinetics and the thermodynamics of equilibrium between mobile and stationary phases was examined. Chromatograms of propylbenzene and phenol were recorded under the same experimental conditions, on the same column, successively irradiated and not. The effect of microwave irradiation on the mass transfer kinetics was determined by measuring the second moment of small pulses of propylbenzene in a 70:30 (v/v) solution of methanol in water and microwave outputs of 15 and 30 W. The effect of microwave irradiation on the equilibrium thermodynamics was determined by measuring the elution time of breakthrough curves of phenol at high concentrations in a 20:80 (v/v) solution of methanol and water and microwave outputs of 15, 50, and 150 W. A qualitative comparison of the profiles of the propylbenzene peaks obtained with and without irradiation suggests that this irradiation affects significantly the peak shapes. However, a qualitative comparison of the profiles of the breakthrough curves of phenol obtained with and without irradiation suggests that this irradiation has no significant effect on their shapes. The peak sharpening observed may be due to an increase in the diffusivity, resulting from the dielectric polarization under microwave irradiation. This effect is directly related to an increase of the rate of mass transfers in the column. In contrast, the similarity of the overloaded band profiles at high concentrations suggests that the equilibrium thermodynamics is unaffected by microwave irradiation. This may be explained by the transparence of the stationary phase to microwaves at 2.45 GHz. The column temperature was measured at the column outlet under irradiation powers of 15, 30, 50, and 150 W. It increases with increasing power, the corresponding effluent temperatures being 25+/-1, 30+/-1, 35+/-1, and 45+/-1 degrees C, respectively.     

Retention and mass transfer characteristics in reversed-phase liquid chromatography using a tetrahydrofuran-water solution as the mobile phase.

The characteristics of the retention and the mass transfer kinetics in reversed-phase liquid chromatography (RPLC) were measured on a system consisting of a C18-silica gel and a tetrahydrofuran-water (50:50, v/v) solution. These parameters were derived from the first and the second moments of the elution peaks, respectively. Further information on the thermodynamic properties of this system was derived from the temperature dependence of these moments. Some correlations previously established were confirmed for this system, namely, an enthalpy-entropy compensation for both retention and surface diffusion and a linear free-energy relationship. These results are compared with those observed in other similar systems using methanol-water (70:30, v/v) and acetonitnile-water (70:30, v/v) solutions. The contribution of surface diffusion to intraparticle diffusion in C18-silica gel particles was shown to be important. The analysis of the thermodynamic properties of surface diffusion suggests that, in these three RPLC systems, its activation energy is lower than the isosteric heat of adsorption. The nature and the extent of the influence of the mobile phase composition on the parameters describing the retention and the mass transfer kinetics are different but the chromatographic mechanisms involved in RPLC systems appear similar, irrespective of the nature of the organic modifier in the mobile phase.     

Effects of elevated temperature and mobile phase composition on a novel C18 silica column

A novel polydentate C18 silica column was evaluated at an elevated temperature under acidic, basic, and neutral mobile phase conditions using ACN and methanol as the mobile phase organic modifier. The temperature range was 40-200 degrees C. The mobile phase compositions were from 0 to 80% organic-aqueous v/v and the mobile phase pH levels were between 2 and 12. The maximum operating temperature of the column was affected by the amount and type of organic modifier used in the mobile phase. Under neutral conditions, the column showed good column thermal stability at temperatures ranging between 120 and 200 degrees C in methanol-water and ACN-water solvent systems. At pH 2 and 3, the column performed well up to about 160 degrees C at two fixed ACN-buffer compositions. Under basic conditions at elevated temperatures, the column material deteriorated more quickly, but still remained stable up to 100 degrees C at pH 9 and 60 degrees C at pH 10. The results of this study indicate that this novel C18 silica-based column represents a significant advancement in RPLC column technology with enhanced thermal and pH stability when compared to traditional bonded phase silica columns.     

Effect of temperature on the chromatographic retention of ionizable compounds. II. Acetonitrile-water mobile phases

The retentive behavior of weak acids and bases in reversed-phase liquid chromatography (RPLC) upon changes in column temperature has been theoretically and experimentally studied. The study focuses on examining the temperature dependence of the retention of various solutes at eluent pH close to their corresponding pKa values, and on the indirect role exerted by the buffer ionization equilibria on retention and selectivity. Retention factors of several ionizable compounds in a typical octadecylsilica column and using buffer solutions dissolved in 30% (v/v) acetonitrile as eluent at five temperatures in the range from 25 to 50 degrees C were carefully measured. Six buffer solutions were prepared from judiciously chosen conjugated pairs of different chemical nature. Their pKa values in this acetonitrile-water composition and within the range of 15-50 degrees C were determined potentiometrically. These compounds exhibit very different standard ionization enthalpies within this temperature range. Thus, whenever they are used to control mobile phase pH, the column temperature determines their final pH. Predictive equations of retention that take into account the temperature effect on both the transfer and the ionization processes are evaluated. This study demonstrates the significant role that the selected buffer would have on retention and selectivity in RPLC at temperatures higher than 25 degrees C, particularly for solutes that coelute.     

Serial coupling of reversed-phase and hydrophilic interaction liquid chromatography to broaden the elution window for the analysis of pharmaceutical compounds

It is presently a common practice in drug discovery to analyse samples by reversed-phase liquid chromatography (RPLC) and hydrophilic interaction chromatography (HILIC). To increase throughput, HILIC was connected in series to RPLC by means of a T-piece with make-up flow. The first column is a 2mm I.D. column having an optimal flow between 0.1 and 0.2mL/min. Via the T-piece, the flow for the second dimension column with an I.D. of 4.6mm is adjusted to 1.5-2.0mL/min with a high acetonitrile content (i.e. >/=80%) mobile phase. Therefore, even in gradient RPLC analysis starting with a mobile phase with high water content, the HILIC column is always operated at high acetonitrile concentration which is required to obtain retention on the HILIC column. The performance of the hyphenated RPLC/HILIC set-up is illustrated with the analysis of two model samples of pharmaceutical interest. Optimization of the conditions in the HILIC dimension is discussed.     

Analysis of adenosine by RP-HPLC method and its application to the study of adenosine kinase kinetics

An RP-HPLC method for the analysis of adenosine (ADO) has been developed and validated. In the present study, we report an RP-HPLC-based method with modifications of mobile phase and shorter retention time that substantially improved the efficiency of ADO analysis. The HPLC separation of the ADO was achieved on a C18 column, using a mobile phase consisting of water, containing 7% v/v ACN, at a flow rate of 0.8 mL/min. The column effluent was monitored by UV detection at 260 nm. A linear response was achieved over the concentration range of 0.25-100.00 micromol/L. The analytical method inter- and intra-run accuracy and precision were better than +/- 15%. The LOQ was 0.25 micromol/L, with ADO detection in the range of 6.25 pmol per sample. The method has been applied to the study of adenosine kinase (AK) kinetics.     

Chemical stability of midazolam injection by high performance liquid chromatography

The chemical stability of midazolam hydrochloride injection, undiluted or diluted with dextrose sterile solution, was studied at different storage conditions by LC. The study was performed at room temperature (23 +/- 2 degrees C) under light exposure and light protection, +8 +/- 1 degrees C and -20 +/- 0.5 degrees C, in glass and plastic containers over 14 days with midazolam hydrochloride injection, undiluted or diluted with 5% dextrose sterile solution. Chromatographic separation was carried out on a RP-18(e) column, using a mobile phase consisting of ACN-phosphate buffer (pH 3.3; 0.1 M) (30:70 v/v) at a flow rate of 1.0 mL/min and UV detection at 220 nm. The concentrations of all samples remained greater than 90% of the original concentration. The chromatographic assay exhibited an adequate linearity (r(2) >0.999), selectivity, precision (RSD <3.1), and accuracy (recoveries from 100.46 to 101.40%). Injectable midazolam hydrochloride was chemically stable in all conditions that were studied.     

High-performance liquid chromatographic determination of pantoprazole and its main impurities in pharmaceuticals

An RP-HPLC method for simultaneous separation and quantification of pantoprazole and its five main impurities in pharmaceutical formulations was developed and validated. The separation was accomplished on a Zorbax Eclipse XDB C18 column (5 microm particle size, 150 x 4.6 mm id) using a gradient with mobile phase A [buffer-acetonitrile (70 + 30, v/v)], and mobile phase B [buffer-acetonitrile (30 + 70, v/v)]. The buffer was 0.01 M ammonium acetate solution with addition of 1 mL triethylamine/L of the solution, adjusted to pH 4.5 with orthophosphoric acid. The eluent flow rate was 1 mL/min, the temperature of the column was 30 degrees C, and the eluate was monitored at 290 nm. Linearity (r = 0.999), recovery (97.6-105.8%), RSD (0.55-1.90%), and LOQ (0.099-1.48 microg/mL) were evaluated and found to be satisfactory. The proposed method can be used for simultaneous identification and quantification of the analyzed compounds in pharmaceutical formulations.     

Comparison of the mass transfer in totally porous and superficially porous stationary phases in liquid chromatography

The characterization of mass-transfer processes in a chromatographic column during a separation process is essential, since the influence of the mass-transfer kinetics on the shape of the chromatographic band profiles and on the efficiency of the separation is crucial. Several sources of mass transfer in a chromatographic bed have been identified and studied: the axial dispersion in the stream of mobile phase, the external mass-transfer resistance, intraparticle diffusion, and the kinetics of adsorption–desorption. We measured and compared the characteristics and performance of a new brand of shell particles and those of a conventional brand of totally porous silica particles. The shell stationary phase was made of 2.7-μm superficially porous particles (a 1.7-μm solid core is covered with a 0.5-μm-thick shell of porous silica). The other material consisted of totally porous particles of conventional 3.5-μm commercial silica. We measured the first and second central moments of the peaks of human insulin over a wide range of mobile phase velocities (from 0.02 to 1.3 mL/min) at 20°C. The plate height equations were constructed and the axial dispersion, external mass transfer, as well as the intraparticle diffusion coefficients were calculated for the two stationary phases.     

Determination of the intraparticle electroosmotic volumetric flow-rate, velocity and Peclet number in capillary electrochromatography from pore network theory

The results obtained from the pore network model employed in this work, clearly show that the magnitudes of the intraparticle electroosmotic volumetric flow-rate, Qintrap, and velocity, (v(intrap,x)), in the pores of the charged porous silica particles considered in this study are greater than zero. The intraparticle Peclet number, Pe(intra, of a solute in these charged porous silica particles would be greater than zero, and, in fact, the magnitude of the intraparticle Peclet number, Pe(intrap), of lysozyme is greater than unity for all the values of the pore connectivity, nT, of the intraparticle pores and of the applied electric potential difference per unit length, Ex, along the axis of the capillary column considered in this work. Furthermore, the values of the intraparticle electroosmotic volumetric flow-rate, Qintrap, and velocity, (v(intrap,x)), as well as the magnitude of the pore diffusion coefficient, Dp, of the solute increase as the value of the pore connectivity, nT, of the intraparticle pores increases. The intraparticle electroosmotic flow can contribute significantly, if the appropriate chemistry is employed in the mobile liquid phase and in the charged porous particles, in (i) decreasing the intraparticle mass transfer resistance, (ii) decreasing the dispersive mass transfer effects, and (iii) increasing the intraparticle mass transfer rates so that high column efficiency and resolution can be obtained.     

Off-line comprehensive two-dimensional high-performance liquid chromatography system with size exclusion column and reverse phase column for separation of complex traditional Chinese medicine Qingkailing injection

A comprehensive two-dimensional liquid chromatography system was constructed on the combination of size exclusion chromatography (SEC) and reverse phase liquid chromatography (RPLC). The first dimension used a SEC column with 300 mm x 8mm i.d., packed with Toyopearl HW-40S. The column was eluted with 0.05 mol/l Tris-HCl (pH 6.9) at a flow rate of 0.4 ml/min. The second dimension used a RPLC column with 100 mm x 4.6mm i.d., which was operated in gradient form at a flow rate of 1.0 ml/min. An automatic switching valve was used to collect the effluent of the SEC column every 3 min, and the effluent was automatically injected into the RPLC column. Mass spectrometer was used for peak identification. This system was used to separate Qingkailing injection, a traditional Chinese medicine (TCM). The result showed that the total peak capacity of this system could reach 1134 and the qualitative analysis of seven chemical components of the Qingkailing injection was accomplished by this system. The results show that comprehensive two-dimensional liquid chromatography system is of great importance and high value in the separation of complex TCM.     

纤维素衍生物手性固定相高效液相色谱法分离盐酸川丁特罗对映体

以纤维素三-(3,5-二甲基苯基氨基甲酸酯)为手性固定相(Lux Cellulose-1),建立了在正相色谱条件下直接分离盐酸川丁特罗对映体的高效液相色谱法。考察了乙醇、异丙醇等有机改性剂,三氟乙酸、二乙胺等流动相添加剂和柱温对对映体分离的影响。结果显示,酸性和碱性添加剂对对映体分离的影响最为显著: 添加二乙胺时两对映体无分离趋势;添加三氟乙酸时对映体保留强,且分离趋势明显;而同时添加三氟乙酸和二乙胺则两对映体分离显著改善,分离度可达4.0。优化后的色谱条件: 色谱柱为Lux Cellulose-1手性柱(250 mm×4.6 mm, 5 μm),流动相为正庚烷-乙醇-三氟乙酸-二乙胺(88:12:0.3:0.05, v/v/v/v),流速为1.0 mL/min,紫外检测波长为246 nm,柱温为25 ℃。该方法简便,快速,可用于左旋盐酸川丁特罗原料中右旋异构体杂质的检查。     

Covalently bonded polysaccharide-modified stationary phase for per aqueous liquid chromatography and hydrophilic interaction chromatography

The mixed sulfated/methacryloyl polysaccharide derivative was prepared and successfully immobilized onto the surface of porous silica particles by polymerization. Polysaccharide derivative was calculated as 10.33% in the stationary phase prepared. The new stationary phase (PMSP) showed both hydrophilic interaction (HILIC) and per aqueous liquid chromatography (PALC) characteristics. The effects of column temperature, the water content, pH and ion strength of mobile phase on the retention time of test compounds in highly aqueous eluents were investigated to evaluate the PALC features of PMSP. The column efficiency is about 31,000 plates/m for benzoic acid in water/ACN (97/3, v/v) mobile phase at a flow rate of 1.0 mL/min. Compared with C18 column, the PMSP had shorter retention time for weak polar and non-polar compounds, but also showed stronger retention for strong polar compounds. It indicated that PALC was a suitable mode of chromatography as replacement of HILIC and complementarity of reversed-phase liquid chromatography (RPLC).     

Adsorption Characteristics in Reversed-Phase Liquid Chromatography Using Ethanol/Water Mixed Solvent

Adsorption characteristics were studied in a reversed-phase liquid chromatography consisting of an octadecylsilyl (ODS)-silica gel and ethanol/water mixture (70/30, v/v), and were compared with corresponding results obtained by using methanol/water and acetonitrile/water mixtures (70/30, v/v) as mobile phase. Similar tendencies were observed for some adsorption characteristics in the three chromatographic systems. However, the magnitude of the characteristics was not entirely identical in the three systems. Surface diffusion was dominant for intraparticle diffusion in the ODS-silica gel particles irrespective of the type of the organic modifiers in mobile phases. A few correlations were confirmed with regard to surface diffusion, i.e., an enthalpy-entropy compensation and a linear free-energy relation. The analogous correlations on surface diffusion phenomena suggest the similarity in the mechanism of surface diffusion in the three chromatographic systems.     

高效液相色谱手性流动相添加法拆分奥昔布宁对映体

采用C18固定相,以羟丙基-β-环糊精为手性流动相添加剂,建立了奥昔布宁对映体的高效液相色谱拆分方法。考察了手性添加剂、有机极性调节剂、缓冲盐的种类和浓度以及流动相的pH值和流速及柱温等因素对对映体分离的影响。在最佳分离条件下,奥昔布宁对映体的分离度为1.54,检测限为1.0 ng。该方法简便,重复性好,比手性固定相法更加经济。     

Simultaneous estimation of pantoprazole and domperidone in pure powder and a pharmaceutical formulation by high-perfomance liquid chromatography and high-performance thin-layer chromatography methods

This paper describes validated high-performance liquid chromatography (HPLC) and high-performance thin-layer chromatography (HPTLC) methods for the simultaneous estimation of pantoprazole (PANT) and domperidone (DOM) in pure powder and capsule formulations. The HPLC separation was achieved on a Phenomenex C18 column (250 mm id, 4.6 mm, 5 pm) using 0.01 M, 6.5 pH ammonium acetate buffer-methanol-acetonitrile (30 + 40 + 30, v/v/v, pH 7.20) as the mobile phase at a flow rate of 1.0 mL/min at ambient temperature. The HPTLC separation was achieved on an aluminum-backed layer of silica gel 60F254 using ethyl acetate-methanol (60 + 40, v/v) as the mobile phase. Quantification was achieved with ultraviolet (UV) detection at 287 nm over the concentration range 400-4000 and 300-3000 ng/mL with mean recovery of 99.35+/-0.80 and 99.08+/-0.57% for PANT and DOM, respectively (HPLC method). Quantification was achieved with UV detection at 287 nm over the concentration range 80-240 and 60-180 ng/spot with mean recovery of 98.40+/-0.67 and 98.75+/-0.71% for PANT and DOM, respectively (HPTLC method). These methods are simple, precise, and sensitive, and they are applicable for the simultaneous determination of PANT and DOM in pure powder and capsule formulations.     

Determination of ethambutol hydrochloride in the combination tablets by precolumn derivatization

A new high-performance liquid chromatography method for the quantitative determination of ethambutol hydrochloride in combination tablets is presented. Ethambutol is derivatized with phenylethylisocyanatate at room temperature (22 +/- 2 degrees C) for 5 min. Separation is performed by a C(18) column using methanol-water-glacial acetic acid (70:30:0.2, v/v/v) as the mobile phase. The method is linear for drug concentrations in the range of 20-120 microg/mL (r=0.9995). The intra- and inter-day precisions are lower than 1.46% and 2.22%, respectively. The average recovery of the samples at three levels is 99.8%. The results show that derivatization of ethambutol is stable at 30 degrees C for 24 h. This method is simple, rapid, and stable in the presence of common excipients and antituberculosis drugs in the tablets.     

灵芝发酵液中蛋白酶抑制剂GLPIA2的纯化及其特性

采用乙醇分级沉淀、凝胶色谱纯化、阴离子交换色谱分离等步骤从灵芝深层发酵液中提取得到蛋白酶抑制剂GLPIA1 与GLPIA2。其中GLPIA2仅在215 nm处有紫外吸收,经十二烷基硫酸钠-聚丙烯酰胺凝胶电泳鉴定为单一条带,相对分子质 量为15000。由其氨基酸组成分析谱图可看出,其酸性氨基酸含量较高,碱性氨基酸及芳香族氨基酸含量较低。GLPIA2抑 制剂的底物特异性研究表明,它对天冬氨酸族的胃蛋白酶和酵母蛋白酶A有相对较强的抑制作用。     

Nonaqueous electrochromatography on C30 columns: separation of retinyl esters.

A nonaqueous packed capillary electrochromatographic reversed-phase method for separation of retinyl esters has been developed. The retinyl esters all-trans-retinyl acetate, palmitate, heptadecanoate, stearate, oleoate, and linoleoate were separated on a 180 microm ID column packed with 5 microm C30 particles with a mobile phase consisting of 2.5 mM lithium acetate in N,N-dimethylformamide-methanol (99:1, v/v). With this mobile phase, the electroosmotic flow was 0.8 mm/s at 650 V/cm and 40 degrees C, and the separation was completed in less than 30 min on 30 cm columns. To obtain electrostable frits of the hydrophobic C30 material both the preparation of the frits and the conditioning of the column prior to electroconditioning were of importance. Selectivity changes were introduced by replacing up to 70% v/v of the N,N-dimethylformamide by acetonitrile. The increase in the amount of acetonitrile was, however, accompanied by a significant increase in analysis time. Liver extracts obtained from arctic seal were analyzed.