混合碳链烷基聚葡糖苷中相微乳液的研究

用Winsor型相图、δ—γ“鱼状”相图和改进的ε—β“鱼状”相图研究了混合碳链烷基聚葡糖苷(APG：C8／10G1.31和C12／14G1．43)中相微乳液的相行为,结果表明,随醇浓度的增加,微乳液类型发生Winsor Ⅰ→Ⅲ→Ⅱ的转变,从Winsor型相图直接观察到醇浓度增加时,微乳液三种类型的变化、各相体积以及中相微乳液形成和消失时醇的浓度,从“鱼状”相图除得到中相微乳液形成和消失时的组成,以及单相微乳液形成时的组成外,还可得到平衡界面膜的组成、表面活性剂单体分子和醇在油相中的溶解度及表面活性剂形成单相微乳液的效能等,在比较上述两种相图优缺点的基础上,我们首次提出了改进的“鱼状”相图,把两者的优点集中于该图中,既能直观地观察出体系相态的变化,又能得到平衡界面膜的组成等其它性质,为理论和实际应用提供更多信息和方便。     

Studies on the Middle-phase Microemulsion of Lauric-N-methylglucamide

The phase behaviour of the middle-phase microemulsion for the quaternary system lauric-N-methylglucamide （MEGA-12）/n-butanollalkane/water has been studied with Winsor type, δ-γ, fishlike and novel ε-β fishlike phase diagrams. A series of phase inversions Winsor I （2）→Ⅲ（3）→Ⅱ （ 2 ） were observed for the three kinds of phase diagrams. The phase types, the phase volumes and the range of alcohol concentrations from the beginning to the end of the middle-phase microemulsion were obtained from Winsor phase diagram. From δ-γ, fishlike phase diagram, the physicochemical parameters, such as the mass fraction of n-butanol in the hydrophile-lipophile balanced inteffacial layer, A^s, the coordinates of the start and end points of the middle-phase microemulsion, and the solubilities of MEGA-12 and n-butanol in alkane phase were calculated. The novel ε-β fishlike phase diagram was also presented. From this kind of diagram, the above experimental phenomena were observed and the physicochemical parameters were calculated precisely. The novel fishlike phase diagram has advantages over the Winsor and δ-γ fishlike phase diagrams in the evaluation of the solubilization power of the microemulsion and calculation of the related physicochemical parameters.     

Studies on Phase Behavior of Alkyl Polyglucoside Based on Microemulsions with Modified Fishlike Phase Diagram

The three-phase behavior in the quaternary system of an alkyl (C8/10^- or C12/14^-)polyglucoside / 1-butanol / n-octane / water has been studied at 40℃ with the modified fishlike phase diagram, which is presented by us for the first time. The mass fraction of 1-butanol in the hydrophile-lipophile balanced interfacial layer, A^S, the coordinates of the start point B and the end point E of the phase diagram, and the solubilities of alkyl polyglucoside and 1-butanol in n-octane phase were calculated. The solubilization of the microemulsion was also discussed.     

Studies on Middle-Phase Microemulsions of Green Surfactant n-Dodecyl Polyglucoside C12G1.46

The three-phases behavior in the quaternary stsem of n-dodecyl polyglucoside C12G1.46/1-butanol/cyclohexane/water has been studied at 40℃ in terms of the variables γ and δ.Increasing δ at constant γcauses a phase inversion from an oil-in-water microemulsion in contact with excess oil(winsor I or 2) to a water-in-oil microemulsion in contact with excess water (winsor Ⅱor 2)via a middle-phase microemulsion in contact with excess oil and water(winsor Ⅲor 3).By taking into account the different solubilities of alkyl polyglucoside and 1-butanol in the oil phase,the composition of the hydrophile-lipophile balanced interfacial film in the middle of the three-phase body can be calculated.The effects of different oils and aqueous media on the phase behavior and on the composition of the interfacial film and the efficiency for alkyl polyglucoside to make equal weights of water and oil to a single phase were investigated.It was found that the oil molecules with small molecular volumes can improve the solubilizing efficiency of the surfactant to form single-phase microemulsion.In inorganic salt(NaCl) and acid(HCl) solutions,less 1-butanol is needed than that in alkali(NaOH) solution to form middle-phase microemulsion.     

烷基聚葡糖苷C9.6G1.3/n-C4H9OH/n-C6H14/H2O微乳液体系的介电弛豫谱研究

The pseudotertiary phase diagram of the microemulsion system alkyl polyglucoside/n-butanol/n-hexane/water was plotted at （30.0±0.1） ℃. The dielectric measurements, including permittivity, conductivity, relaxation strength, characteristic relaxation time, etc,, were applied to investigate the microstructure of the system. Unique dielectric relaxations were observed over the frequency range of 5-10^7 Hz, taking place possibly through an interracial polarization mechanism. According to the results obtained from dielectric spectroscopy, the structures of the microemulsion O/W, BC and W/O were determined, and some dielectric and phase parameters were calculated.     

烷基多苷的粘度及乳化性能研究

考察了不同碳链烷基多苷的粘度特性，以及乳化性能，结果表明碳链较长、聚合度较低的烷基多苷具有良好的粘度和乳化性能。     

烷基芳基磺酸盐结构对微乳液相行为的影响

用Winsor相图法研究了自制的6种不同结构的烷基芳基磺酸盐/不同醇/正癸烷/NaCl/水体系在不同温度下所形成的微乳液。 探讨了烷基芳基磺酸盐结构对微乳液相行为的影响。 同时考察了温度和醇对微乳液相行为的影响。 结果表明,随着烷基芳基磺酸盐长烷基链的增长,中相形成盐度S1、中相消失盐度S2、中相盐宽ΔS和最佳盐浓度S*值均减小,最佳中相体积V*M和最佳增容量σ*值均增大;随着烷基芳基磺酸盐分子的芳环向长烷基链中间位置移动,S1、S2、ΔS、S*值均减小,V*M和σ*值均增大;随着温度升高,V*M和σ*值均减小,S1、S2、ΔS、S*值均增大,在25 ℃时,体系无中相微乳液形成;随着正构醇碳原子数的增加,V*M和σ*值均增大,S1、S2、ΔS、S*值均减小。     

烷基多苷的泡沫性能及在硬水中的稳定性研究

烷基多苷(APG)由葡萄糖的半缩醛羟基和脂肪醇羟基在酸催化下失去一分子水而得到,它与常用的阴离子表面活性剂十二烷基苯磺酸钠有相似的功能,其起泡性以及在硬水中的稳定性更优良。本文对实验室合成的部分烷基多苷产品的泡沫性能以及在硬水中的稳定性进行研究。     

烷基聚葡糖苷微乳液中脂肪酶催化的酯合成反应动力学

在烷基聚葡糖苷C10G1．54／正丁醇／环己烷／磷酸盐缓冲液体系形成的油包水微乳液中,研究了在较高底物浓度下,脂肪酶催化正己酸和正丁醇的酯合成反应动力学及其影响因素。结果表明,在正己酸的初始浓度CHA^0较小时,反应初速率V0随正己酸浓度增大而增大,但随正丁醇表观浓度增大而减小;在CHA^0较大时,反应初速率V0随正丁醇表观浓度增大而增大,但随正己酸浓度增大而减小．在正己酸和正丁醇摩尔浓度之比为3．0左右反应速率最大．这些实验结果与传统的米氏反应不符,为此,从界面膜的构成,尤其是两种底物在界面膜上的分布情况人手进行了探讨．考察了C10G1.54浓度、正丁醇浓度和两者总浓度等对反应初速率V0的影响．     

非离子表面活性剂TWeen80相图的研究

本文研究了醇类（正丁醇、正戊醇、正辛醇和正癸醇）、油类（正十八烷、正十六烷、正十四烷、正十烷、正癸烷和正辛烷）、正十八烷含量以及NaCl浓度对Tween80／醇／油／水体系相图的影响。结果表明，NaCl浓度对Tween80／正辛醇／正十八烷／水体系相图的影响不明显；醇类随着炭原子数目的增加，O／W微乳液区面积增大，W／O微乳液区面积减小，微乳液区总面积增大；不同的油类形成的微乳液区面积由大到小的顺序是：正十六烷≈正十四烷＞正十二烷＞正癸烷＞正十八烷＞正辛烷；随着正十八烷含量的增加，微乳区面积减小。用2277热活性检测系统测定了石油菌B－2分别在非微乳液和助表面活性剂分别是正戊醇、正辛醇，油是正十八烷所形成的微乳液中生长的功率－时间曲线。结果表明微乳液培养基更适用于B－2利用高碳烷烃进行生长；正辛醇作助表面活性剂形成的微乳液培养基比正戊醇作助表面活性剂形成的微乳液培养更为有利；O／W型微乳液比W／O型微乳液对B－2的生长更为有利。     

Transport properties of alternative fuel microemulsions based on sugar surfactant

Electrical conductivity of fuel microemulsion composed of diesel, pentanol, water, and sucrose laurate as surfactant was investigated over a wide range of water contents varying from 0 to 90?wt% and temperature varying from 10°C to 50°C. Conductivity measurements were performed on samples, the composition of which lie along the one-phase channel using a conductivity meter. Activation energy of conduction flow was evaluated. The hydrodynamic radius as a function of temperature in the aqueous phase-rich region (90?wt%) was measured using the dynamic light scattering (DLS) method. The microstructure of the microemulsion was further investigated by NMR diffusometry by which the self-diffusion coefficients for water were determined at 25°C. Electrical conductivity increases with water content up to 40?wt% and the percolation threshold was observed, and then stabilizes between 40 and 80?wt% then decreases. Percolation threshold temperature at constant composition was monitored as 36°C for water contents below 80?wt% and as 34°C for water contents above that. As predicted by the conductivity measurements, the determined self-diffusion coefficients of water confirmed the structural transition from discrete W/O droplets to bi-continuous phase and finally to O/W droplet microemulsion.     

辛烷基酚聚氧乙烯醚反相微乳体系的相行为及纳米复合碳酸盐的制备

绘制了一系列辛烷基酚聚氧乙烯醚(OP-10)+正辛醇+环己烷+水(或CaCl₂水溶液)拟三元体系相图,分别研究了助表面活性剂正辛醇的添加比例和CaCl₂水溶液的浓度对微乳区域的影响,发现在OP-10+正辛醇+环己烷+水拟三元体系相图中,随着正辛醇/OP-10的质量比逐渐增大,微乳区的面积逐渐增大,当正辛醇/OP-10质量比为1:2.5时微乳区的面积最大,之后微乳区面积随着其质量比的增大而减小,表明适量地加入助表面活性剂正辛醇有利于微乳区的形成;但过多地增加正辛醇的量反而不利于微乳相的形成。 确定正辛醇/OP-10的质量比为1:2.5,改变CaCl₂的浓度,发现OP-10+正辛醇+环己烷+CaCl₂水溶液拟三元体系相图中,CaCl₂浓度为0.1 mol/L时微乳区面积最大。分别配制总浓度为0.1 mol/L的5种不同摩尔比的Ca²⁺/Ba²⁺微乳液,并与等摩尔的碳酸钠水溶液反应制备共沉淀碳酸盐,使用扫描电子显微镜(SEM)对所制备样品进行表征分析,发现当微乳液为钙离子盐时,主要形成大的立方形颗粒;掺入钡离子,Ca²⁺和Ba²⁺摩尔比为3:1、1:1和1:3时,形成的沉淀分别为四棱锥形、球形和玉米棒形;当微乳液为钡离子盐时,沉淀主要为不规则多面体。     

Effect of Addition of Cosurfactant on the Phase Behaviour of Oil-in-water Aminosilicone Oil Microemulsion

Stable and transparent aminosilicone oil microemulsion of the average particle size below 0.05 micron was prepared. The interaction of the aminosilicone oil, water, complex surfactants and cosurfactant was studied by part pseudotemary phase diagram. The effect of cosurfactants (such as alcohol) and the mechanism of its effect on the phase behaviour of the pseudotemary system were investigated.     

醇对高效氯氟氰菊酯微乳液相图的影响

通过电导率的测定研究了高效氯氟氰菊酯微乳液的结构结构及结构转变。在表面活性剂、高效氯氟氰菊酯环己酮溶液、醇相对含量一定的情况下,当醇为乙醇时,微乳液经历了由W/O到双连续最后到O/W型的变化;当醇为正辛醇时,微乳液经历了由W/O到液晶、双连续最后到O/W型的变化。绘制了不同条件下高效氯氟氰菊酯微乳体系的拟三元相图,讨论了醇种类、醇含量对各类型微乳区形成的影响。结果表明,随着醇碳链的增大,微乳区面积先增大后减小;醇(正辛醇)固定时,随着醇含量增加,微乳区面积先减小后增大。     

Effect of the surfactant alkyl chain length on the stabilisation of lyotropic nematic phases

Lyotropic quaternary mixtures of potassium alkanoates (KCx) and sodium alkyl sulphates (NaCxS), where x is the number of carbon atoms in their alkyl chains, were prepared to investigate the effect of the surfactant alkyl chain length on the stabilisation of lyotropic nematic phases. The lyotropic mixtures investigated were formed by the dissolution of KCx (NaCxS) surfactants in the mixture of Rb₂SO₄/1-decanol/water (Na₂SO₄/1-decanol/water), separately. The uniaxial-to-biaxial nematic phase transitions were identified from the temperature dependence of the birefringences of the nematic phases by means of laser conoscopy. The micelle dimensions were obtained from small-angle X-ray scattering measurements. It was observed that the increase in the surfactant alkyl chain length causes the micellar growth in the plane perpendicular to the main amphiphile bilayer. The surfactant alkyl chain length plays a key role on the shape anisotropy of micelles, which triggers the orientational fluctuations that are responsible for the stabilisation of the different lyotropic nematic phases.     

Adsorption Kinetics of Alkyl Polyglucoside at the Air—Solution Interface

The air-solution equilibrium tension γe and dynamic surface tension γt,of nonionic surfactant alkyl polyglucoside have been studied. γe was measured by the Wilhelmy method with Rruess K12 tensiometer. The CMC and the surface excesses T were determined from the surface tension vs. concentration curve. The γt decays were measured in the range 0.2-20s using a maximum bubble pressure instrument and analyzed with the Ward and Tordai equation.     

SDS-正戊醇与SDS-正丁醇微乳体系相行为模拟

利用净平均曲率模型重现了以十二烷基硫酸钠(SDS)为表面活性剂,正丁醇和正戊醇为助剂,短碳链烷烃的相行为和增溶参数的变化情况。模拟了Winsor相图及最佳增溶参数曲线,并和实验进行了对比,与实验结果吻合的较好,并且发现在相同表面活性剂和助剂下,油越轻,增溶量越大,采用正戊醇做为助剂增溶轻油的能力约为采用正丁醇的3倍。在表面活性剂用量相差不大,助剂量相同的情况下,出现中相所需的盐度都是正己烷正庚烷正辛烷正十二烷,以正戊醇为助剂所需的盐度远小于以正丁醇为助剂所需的盐度。     

Kinetics of the Esterification Reaction Catalyzed by Lipase in W／O Microemulsions of Alkyl Polyglucoside

A novel kinetic mechanism of esterification reaction of 1-hexanoic acid with 1-butanol,catalyzed by lipase, was studied in water-in-oil microemulsions. The microemulsions were formed by alkyl polyglucoside C10G1.54/1-butanol/cyclohexane/phosphate buffer solution. The restult shows that when the ratio of mol concentration of 1-butanol to 1-hexanoic acid is about 3.0,the initial rate V0 get the maximum values. This phenomenon was explained by the modified fishlike phase diagrams.     

柴油中相微乳液的制备和相图分析

制备了柴油/复合表面活性剂/正戊醇/MnCl2盐水五元微乳液;研究了MnCl2浓度、表面活性剂浓度及正戊醇浓度对五元微乳液体系中相微乳液的形成和鱼尾相图的影响.结果表明,用MnCl2扫描时形成的中相微乳液范围较窄;在鱼尾相图中,当复合表面活性剂D0821(双(C8-10烷基)二甲基氯化铵)和AEO-3(脂肪醇聚氧乙烯醚)的质量比为4∶6时,形成单相微乳液的表面活性剂效率最高,最佳表面活性剂的质量分数为8.3%.     

Phase Diagrams and Solubilization of Chlorocarbons in Chlorocarbon/Water/Anionic Surfactant/Alcohol Microemulsion Systems

The solubilization abilities of various chlorocarbons were investigated in a middle phase microemulsion system anionic surfactant sodium dodecyl sulfate (SDS) or sodium dodecyl sulfonate (AS)/n-butanol/chlorocarbon/brine with a ε-β fishlike phase diagram. The composition of the balanced interfacial layer of the microemulsion and some other parameters are calculated. The result shows that surfactant little dissolves in water and chlorocarbon phases, while alcohol mainly dissolves in water and oil phases besides in the interfacial layer. The order of the solubilization ability is dichloromethane (CH₂Cl₂) ～ carbon tetrachloride (CCl₄) > tetrachloroethylene (PCE) > o-dichloro-benzene. The solubility of the alcohol decreases with the increase in NaCl concentrations, which should be compensated by the increase in the amount of alcohol as cosolvent (Cs), so as to maintain the balanced interfacial layer. Salinity has little effect on the partition of surfactant between phases.