聚丙烯腈的研究——丙烯腈在浓无机盐溶液中的氧化还原引发聚合

丙烯腈在浓硫氰化钠溶液中成功地应用氧化还原引发聚合。所用引发体系为TBH-TEA,TBH-DEA,TBH-MEA,TBH-DMA四类。当TBH与TEA二者克分子比为1∶1左右时,1小时内转化率可达90％以上,分子量为8.5万左右,不同体系的聚合速度与转化率的次序为TBH-TEA>TBH-DEA>TBH-MEA,而它们分别所得聚合物的分子量次序则恰恰相反。 当[TBH]/[TEA]的克分子比增加时则聚合速度增加,最高转化率也增加。以TBH-DMA为引发体系时,转化率最高在60％左右,当增加[DMA]/[TBH]的克分子比时,聚合速度增加但最高转化率反而下降,这与BPO与DMA体系的情况相同。 初步提出了TBH-醇胺引发体系的反应机理。     

过硫酸钾-脲氧化还原引发下的丙烯酰胺水溶液聚合

为制备高分子量聚丙烯酰胺(PAM),对其引发体系,尤其是对氧化还原引发做了许多探索^[1]。     

钒(V)—硫脲氧化还原体系引发丙烯腈聚合的研究 Ⅱ.硫脲在引发聚合中的行为

研究了钒(V)—硫脲氧化还原体系在硝酸溶液中引发丙烯腈聚合动力学,发现硫脲浓度对丙烯腈聚合速度关系曲线上出现两次突跃,第一次突跃相当于在[TU]/[V~(5+)]=0.5～1摩尔比,第二次突跃发生在[TU]/[V~(5+)]=3～4摩尔比的位置上。说明在[TU]/[V~(5+)]摩尔比不同的情况下,作为引发种的V~(5+)—TU络合物的结构和引发历程也不相同。本文在此基础上提出了络合引发机理。     

电荷转移引发聚合——酚噻嗪引发丙烯腈光聚合研究

本文研究了酚噻嗪(PTZ)引发丙烯腈(AN)的光聚合。测定了聚合速率R_p=K[AN]^1.47[PTZ]^0.41及活化能E_α=7.1千卡/摩尔。从PTZ与AN在光照下形成激基复合物的机制讨论了引发聚合机理。     

硫氰化钠对过氧化物引发丙烯腈水溶液聚合的影响

<正> 关于硫氰化物对丙烯腈聚合的影响,早期的报道认为对过硫酸盐引发丙烯腈水溶液聚合时,硫氰化钾起阻聚作用.但丙烯腈在浓硫氰化钠水溶液中,可顺利地用偶氮双异丁腈(AIBN)、光、叔丁基过氧化氢(TBH)或TBH-醇胺引发聚合,在这些聚合反应中硫氰化钠无阻聚或缓聚作用.为了弄清硫氰化钠的影响,我们比较系统地研究硫氰化钠对丙烯腈水溶液聚合的影响.实验结果表明,其影响与所用的引发剂有关.如用TBH时,硫氰化钠起活化作用,缩短反应的诱导期,提高聚合速度与转化率,30—50℃     

可聚合的氧化还原引发体系

胺类具有还原性,可以与多种氧化剂构成氧化还原引发体系,胺类可产生自由基,引发乙烯基单体聚合.若乙烯基单体同时含有胺类基团,则这类自身还原性引发型单体在氧化剂存在的情况下既参与链引发又参与链增长,因此可以形成超支化聚合物.本文首先回顾了胺类氧化还原体系及其引发机理,然后总结自身还原性引发型单体分别与过氧化物、二芳酮、高氧...     

钒(V)—硫脲氧化还原体系引发丙烯腈聚合的研究 Ⅰ.聚合动力学

研究了钒(V)—硫脲氧化还原体系在硝酸溶液中引发丙烯腈的聚合反应.表观聚合速度是:R_p=2.80×10~5e~(-14000/RJ)[AN]~(2.2)[HNO_3]~(0102)[V~(5+)~(0～1/3)[TU]~(0～4/3),实验结果表明钒(V)和硫脲产生引发种是一个相当复杂的过程。     

亚硝酸钠引发丙烯腈聚合的研究

研究了亚硝酸钠引发硝酸溶液中丙烯腈的聚合反应。测得表现聚合速度 Rp=Ae~(-10,800/RT)[AN]~2.2[NaNO_2]~(0.17-1.0)[HNO_3]~(1.0-0.67 丙烯腈-丙烯酸甲酯共聚合反应中竞聚率分别是γ_An=0.96,γ_MA=1.17,表明聚合反应是按自由基机理进行。 根据聚合动力学和红外光谱分析,认为以亚硝酸钠引发硝酸溶液中丙烯腈的聚合反应与电解或金属溶蚀过程中的次级引发相同。     

氧化还原引发体系的丙烯酰胺聚合动力学研究

<正> Suen等采用氯酸盐-亚硫酸盐氧化还原引发体系在不同的pH条件下进行丙烯酰胺溶液聚合,结果表明,起始聚合速度与([ClO_3][H_2SO_3])~(1/2)成正比,井本用K_2S_2O_8为引发剂研究了pH对丙烯酰胺聚合的影响,认为pH在3—8范围内,起始聚合速度几乎不受pH影响,当pH达到9以上时,则急剧下降,我们采用过硫酸盐-亚硫酸盐、过硫     

STUDIES ON THE POLYMERIZATION OF ACRYLONITRILE INITIATED BY METAVANADATE-CONTAININ G ANION EXCHANGER-THIOUREA REDOX SYSTEM

The polymerization of acrylonitrile (AN) in aqueous nitric acid initiated by metavanadate-containing anion exchange resin (PV)-thiourea (TU) redox system at 20—40℃. has been investigated. The overall rate of polymerization (R_p) is given byR_p=1.92×10~4e~(-6.860/RT) [AN]~(1.2) [PV]~(0.44) [TU]~(1.0)[HNO_3]~(1.0)The kinetic parameters differed from those of V~(5+)-TU system indicated that the generation of the primary radicals is mainly a difffusion-controlled reaction. The effect of macromolecular field arisen from the polymer matrix exerts a great influence on the polymerization process.     

负离子引发丙烯腈沉淀聚合动力学研究

从负离子引发丙烯腈沉淀聚合的亚微观过程出发,建立了动力学模型,并通过初生态沉淀聚集体联结方法数的叠加,推导出了动力学方程.在不同条件下(单体浓度、引发剂浓度、时间)对丙烯腈沉淀聚合进行了研究,用推导的动力学方程处理数据后发现实验数据与理论相吻合.丙烯腈负离子沉淀聚合的聚合反应为对单体浓度的一级反应,对引发剂浓度的一级反应,反应速率方程为Rp=k0[M]1.0[I]1.0.     

阴离子交换树脂负载钒(V)—硫脲氧化还原体系引发丙烯腈聚合的研究

用负载偏钒酸根的强碱性阴离子交换树脂(PV)与硫脲(TU)组成氧化还原体系在硝酸溶液中引发丙烯腈(AN)聚合,表观聚合速度是: R=1.92×10~4e~(-6860)/RT[AN]~(1.2)[RV]~(0.44)[TU]~(1.8)[HNO_ 3]~(1.0)聚合动力学参数与V~(6+)—TU体系所得者不同,表明初级自由基的产生受扩散控制因素的重要影响,并且载体树脂在聚合过程中存在着强烈的大分子场效应。聚合诱导期(ι)与引发速度成反比。聚合物分子量与聚合速度成正比,与终止速度和聚合温度成反比。加料方式实验再一次表明了引发种是由五价钒和硫脲络合和/或缔合所产生而不是和异硫脲结合的结果。本文讨论了引发聚合机理。     

过氧化氢的热分解及其引发丙烯腈聚合反应的研究

本文研究了过氧化氢在二甲基甲酰胺中的热分解反应,测定了不同温度下的分解速率常数和表现活化能。同时研究了过氧化氢引发丙烯腈的聚合反应,确定了聚合动力学方程。     

KINETIC STUDIES ON THE POLYMERIZATION OF ACRYLONITRILE INITIATED BY METALLIC MAGNESIUM-NITRIC ACID SYSTEM

This article reports the polymerization kinetics of acrylonitrile initiated by metallic magnesiumnitric acid system. The rate of polymerization is independent of the amount of magnesium used; when the concentration of nitric acid is higher than acrylonitrile, the equation of polymerization kinetics may be expressed asR_p =1.91×10~5e~(-15000)/RT[Mg]~0 [AN]~(2.2) [HNO_3]~(0.45)The result of copolymerization of acyrlonitrile and methyl acrylate supports a free-radical mechanism.     

STUDY ON THE POLYMERIZATION OF ACRYLONITRILE INITIATED BY POLYPROPYLENE-BASED VANADYL POLYIMIDODIACETATE——THIOUREA REDOX SYSTEM

The present paper deals with the kinetics of polymerization of acrylonitrile (AN) initialed by the redox system of polypropylene-based vanadyi polyimidodiacetate (PV)-thiourea (TU)in aqueous sulfuric acid in the temperature range from 25 to 40℃. The polymerization rate was measured by varying the concentrations of monomer, vanadyl polyimidodiacetate, thiourea and sulfuric acid. The overall rate of polymerization was summarized asRp=2.2×10~5e~(-6.560/RT) [AN]~(1.0)[PV]~(0.50)[TU]~(1.5)[H_2SO_4]~(2.0)The molecular weight of polyacrylonitrile based on the experimental data was:(?)=k 1/T [pv]~(0.50)[TU]~(1.5)[H_2SO_4]~(2.0)These results indicated that the chain radicals are terminated by combination and/or disproportionation rather than chain transfer. The cooperation effect of carboxylic groups and the macromolecular field effect of polymer supporter are the characters of vanadyl polyimidodiacetate such as the case reported in early paper.     

KINETICS OF POLYMERIZATION OF ACRYLONITRILE INITIATED BY VANADIUM(V)-THIOUREA REDOX SYSTEM

The kinetics of polymerization of acrylonitrile (AN) initiated by quinquevalent vanadium (V~(5+))-thiourea (TU) redox system has been investigated in aqueous nitric acid in the temperature range from 30 to 50℃. The polymerization rate (R_p) can be expressed as follows: In the copolymerization of acryionitrile with methyl acrylate (MA), the reactivity ratios were found to be 1.0 and 1.1, respectively. The experimental observations suggest that the initiating species is probably a complex consisting of a central ion of Lewis acid-VO_2~+ and the ligands of Lewis bases-acrylonitrile, thiourea, and nitrate anions, while the initiating system in lower concentration, the polymerization of acrylonitrile does not occur if the thiourea is acidified prior to its reaction with quinquevalent vanadium. This indicates that the primary radicals (or the monomeric radicals in the present article) are produced by associated thiourea rather than isothlourea.     

POLYMERIZATION OF ACRYLAMIDE IN AQUEOUS MEDIUM INITIATED BY REDOX SYSTEM OF 4-CARBOXYBENZOPHENONE AND SULFUR-CONTAINING COMPOUNDS

A series of sulfur-containing compounds was investigated as electron donors in photoinduced free-radical polymerization, in conjunction with 4-carboxybenzophenone (CB) as sensitizer. These compounds included (phenylthio) acetic acid, ethionine, methionine, Gly-Met, Met-Gly and methionine methyl ester. The results were compared with the nonsulfur-containing compounds, alanine and triethanolamine. The best initiation yields is observed for the system CB-(phenylthio)acetic acid.