应用近红外透射光谱法测定稻米淀粉消减值的研究

以183份稻米为样品,利用近红外透射光谱分析仪,对样品进行光谱扫描,并用快速黏度分析仪测定黏滞特性值消减值.采用多种计量数学处理方法和不同的回归统计方法进行定标曲线的开发和比较,得到了稻米消减值测定的近红外分析数学模型,数学模型的定标标准偏差(SEC)、交叉检验标准误差(SECV)和定标决定系数(RSQ)分别为:18.69,19.08和O.949 7.相关性达极显著水平,内部交叉验证和外部验证结果表明近红外定量分析消减值有很高的准确度.该研究利用近红外透射光谱技术为快速准确无损测定黏滞特性指标提供了一条新途径.     

Analysis of elements in wine using near infrared spectroscopy and partial least squares regression

The use of visible (VIS) and near infrared spectroscopy (NIRS) to measure the concentration of elements in Australian wines was investigated. Both white (n=32) and red (n=94) wine samples representing a wide range of varieties and regions were analysed by inductively coupled plasma mass spectrometry (ICP-MS) for the concentrations of calcium (Ca), potassium (K), magnesium (Mg), phosphorus (P), sodium (Na), sulphur (S), iron (Fe), boron (B) and manganese (Mn). Samples were scanned in transmittance mode (1mm path length) in a monochromator instrument (400-2500nm). The spectra were pre-treated by second derivative and standard normal variate (SNV) prior to developing calibration models using partial least squares (PLS) regression method with cross-validation. The highest coefficients of determination in cross-validation (R(val)(2)) and the lowest errors of cross-validation (SECV) were obtained for Ca (0.90 and 9.80mgL(-1)), Fe (0.86 and 0.65mgL(-1)) and for K (0.89 and 147.6mgL(-1)). Intermediate R(val)(2) (<0.80) and SECV were obtained for the other minerals analysed. The results showed that some macro- and microelements present in wine might be measured by VIS-NIRS spectroscopy.     

Analysis of grass silage from Northwestern Spain by near-infrared reflectance spectroscopy

Near-infrared reflectance spectroscopy (NIRS) was evaluated for the determination of protein, crude fiber (CF), acid detergent fiber (ADF), and neutral detergent fiber (NDF) in grass silage. Calibration equations were based on analyses of 366 samples of grass silage produced in Northwestern Spain over 4 consecutive years (1992-1995) and validated by analyses of a set of 72 silage samples harvested during 1996. Dried and ground samples were analyzed by chemical and NIRS procedures. The spectral data were analyzed by regression against a range of chemical parameters, using modified partial least-squares (MPLS) multivariate analysis in conjunction with different mathematical treatments of the spectra. For each parameter, the optimum calibration was evaluated on the basis of the coefficient of multiple determination (R2), the coefficient of simple correlation (r2), the standard error of calibration (SEC), the standard error of cross-validation (SECV), and the standard error of validation (SEV). R2 and r2 were >0.90; SEC values were 0.58, 1.04, 1.40, and 1.75; SECV values were 0.64,1.15,1.50, and 2.04; and SEV values were 0.56,1.02, 1.42, and 1.80 for protein, CF, ADF, and NDF, respectively. The ratio of the standard deviation of the reference data to the SEV was >3.0 for each of the 4 parameters, which indicates that the equations can be used in routine analysis.     

近红外光谱技术定量分析连作滁菊土壤中的阿魏酸含量

应用近红外光谱(NIRS)技术定量分析连作滁菊土壤样品中阿魏酸的含量.通过标准杠杆值、学生残差和马氏距离判断异常光谱,经二阶导数和Norris平滑滤噪预处理后,在6000~4000 cm-1范围,最佳因子数为7,采用偏最小二乘法(PLS)构建数学模型.结果表明,模型校正集和验证集与高效液相色谱仪(HPLC)测定的参考值之间均呈现良好相关关系,校正相关系数Rc为0.9914,交叉验证相关系数Rcv为0.9935,校正集误差均方根(RMSEC)为0.484,预测误差均方根(RMSEP)为0.539,交叉验证误差均方根(RMSECV)为0.615.研究结果表明,NIRS分析技术能够实现连作土壤中阿魏酸的快速检测,结果准确可靠.     

Near-infrared reflectance spectroscopy as a fast and non-destructive tool to predict foliar organic constituents of several woody species

Near-infrared reflectance spectroscopy (NIRS) was used to estimate N, neutral detergent fibre (NDF), acid detergent fibre (ADF), lignin and cellulose contents in leaves of a heterogeneous group of 17 woody species from the Central Western region of the Iberian Peninsula. The sample set consisted of 182 samples of leaves of deciduous and evergreen species, showing a wide range of concentrations determined by reference methods: 6.60–35.2 g kg⁻¹ (N), 15.5–66.0% (NDF), 10.2–57.3% (ADF), 3.45–27.4% (lignin) and 5.79–31.3% (cellulose). Reflectance spectra, obtained for samples of dried and ground leaves, were recorded as log1/R (R=reflectance) from 1,100 to 2,500 nm. NIRS calibrations were developed using multiple linear (MLR) and partial least-squares (PLSR) regressions, and tested by external validation. Spectral data were transformed to the first and second derivative (1D, 2D). The PLSR method and derivative transformations provided the best statistics and showed lower standard errors of calibration (SEC) and higher coefficients of multiple determination (R ²). In the external validation the standard errors of prediction (SEP) were 0.76 g kg⁻¹ (N), 2.11% (NDF), 1.47% (ADF), 0.85% (lignin) and 0.86% (cellulose). The results obtained show that NIRS is very effective for the estimation of these organic constituents in leaf tissue of woody species. This technique can be used in ecological or ecophysiological studies as an alternative to the more time-consuming standard methods.     

Determination of the percentage of milk (cow's, ewe's and goat's) in cheeses with different ripening times using near infrared spectroscopy technology and a remote reflectance fibre-optic probe

In the present work we studied the use of near infrared spectroscopy (NIRS) technology employing a remote reflectance fibre-optic probe (with a 5 cm × 5 cm quartz window) for the analysis of the percentage of milk (cow's, ewe's and goat's) used in the elaboration of cheeses with different ripening times. To do so, cheeses with known and varying percentages of cow's, ewe's and goat's milk were elaborated (112 samples with milk collected in winter and 112 samples with milk collected in summer) and used as reference material, and ripening controls were performed over 6 months. The method allows immediate control of the cheese without prior sample treatment or destruction by direct application of the fibre-optic probe to the sample. The regression method employed was modified partial least squares (MPLS). Of all the samples (224), 200 formed to so-called calibration set and the other 24 were used for external validation. The calibration results obtained using 200 samples of cheese allowed the percentage of cow's, ewe's and goat's milk to be measured. The multiple correlation coefficients (RSQ) and prediction corrected standard errors (SEP(C)) obtained were respectively, 0.834 and 11.6% for cow's milk; 0.871 and 9.8% for goat's milk; 0.880 and 10.6% for ewe's milk. The ratio performance deviation (RPD) values obtained indicate that the NIRS equations can be applied to unknown samples.     

Influence of the procedure used to prepare the calibration sample set on the performance of near infrared spectroscopy in quantitative pharmaceutical analyses

Calibrating near infrared diffuse reflectance spectroscopy (NIRS) methods usually involves preparing a set of samples with a view to expanding the analyte concentration range spanned by production samples. In this work, the performances of the two procedures most frequently used for this purpose in near infrared pharmaceutical analysis, viz., synthetic samples obtained by weighing of the pure constituents of the pharmaceutical and doped samples made by under- or overdosing previously powdered production samples, were compared. Both procedures were found to provide similar results in the quantification of the active compound in the pharmaceutical, which was determined with a relative standard error of prediction (RSEP) of < 1.6%. However, the two types of sample preparation provide different spectra, which precludes the accurate quantification of synthetic samples from calibrations obtained with doped samples and vice versa. None of the mathematical pre-treatments tested with a view to reducing this different scattering (viz., second derivative, standard normal variate and orthogonal signal correction) could effectively solve this problem. This hinders accurate validation of the linearity of the procedure and makes it advisable to use doped samples which are markedly less different to production samples.     

木薯品质分析的近红外光谱模型建立及其应用研究

应用近红外光谱法(NIRS)建立木薯中淀粉、水分定量分析的近红外光谱数学模型,探讨了修正偏最小二乘法(MPLS)、偏最小二乘法(PLS)以及主成分回归法(PCR)等优化处理对定标模型的影响,确定了修正偏最小二乘法(MPLS)是建立模型最适合的数学方法。并对模型预测结果的准确性进行了评价。结果表明:验证集样品的化学值和近红外预测值拟合存在较好的线性关系,相关性显著。淀粉模型预测标准偏差(Sep)为0.850,系统偏差(Bias)为-0.095,相关系数(r)为0.971。水分模型预测标准偏差(Sep)为0.075,系统偏差(Bias)为0.007,相关系数(r)为0.980。淀粉、水分定量分析的NIRS数学模型具有较高的预测准确性,可应用于木薯批量收购中的品质等分析。     

Fast determination of trace dimethyl fumarate in milk with near infrared spectroscopy following fluidized bed enrichment

Near infrared spectroscopy (NIRS) has been proved to be a powerful analytical tool in different fields. However, because of the low sensitivity in near infrared region, it is a significant challenge to detect trace analytes with normal NIRS technique. A novel enrichment technique called fluidized bed enrichment has been developed recently to improve sensitivity of NIRS which allows a large volume solution to pass through within a short time. In this paper, fluidized bed enrichment method was applied in the determination of trace dimethyl fumarate in milk. Macroporous styrene resin HZ-816 was used as adsorbent material, and 1?L solution of dimethyl fumarate was run to pass through the material for concentration. The milk sample was pretreated to remove interference matters such as protein, fat, and then passed through the material for enrichment; after that, diffuse reflection NIR spectra were measured for the analyte concentrated on the material directly without any elution process. The enrichment and spectral measurement procedures were easy to operate. NIR spectra in 900–1,700?nm were collected for dimethyl fumarate solutions in the concentration range of 0.506–5.060?μg/mL and then used for multivariate calibration with partial least squares (PLS) regression. Spectral pretreatment methods such as multiplicative scatter correction, first derivative, second derivative, and their combinations were carried out to select the optimal PLS model. Root mean square error of cross-validation calculated by leave-one-out cross-validation is 0.430?μg/mL with ten PLS factors. Ten samples in an independent test set were predicted by the model with the mean relative error of 5.33?%. From the results shown in this work, it can be concluded that the NIR technique coupled with on-line enrichment method can be expanded for the determination of trace analytes, and its applications in real liquid samples like milk and juice may also be feasible.     

Near-infrared spectroscopy (NIRS) reflectance technology for the determination of tocopherols in alfalfa

The vitamin E (α- and (β+γ)-tocopherol) contents present in alfalfa (fresh or dehydrated) were analysed using near-infrared spectroscopy (NIRS) technology together with a remote reflectance fibre-optic probe. The range of vitamin E was 0.55–5.16 mg/100 g for α-tocopherol and 0.07–0.48 for (β+γ)-tocopherol. The regression method employed was modified partial least squares (MPLS). The equations developed using the fibre-optic probe for 69 samples of alfalfa (dehydrated and fresh) to determine the content of vitamin E in feeds had multiple correlation coefficients (RSQs) and prediction corrected standard errors (SEP (C)) of 0.946 and 0.321 mg/100 g for α-tocopherol and 0.956 and 0.022 mg/100 g for (β+γ)-tocopherol. The predicted values of vitamin E in feeds using NIRS technology applying the fibre-optic probe directly on the sample with neither previous treatment nor manipulation are comparable to those obtained using the chemical method, which included alkaline hydrolysis and hexane extraction of the vitamin from the unsaponifiable fraction before chromatographic determination.     

Measurement of lactate in whole human blood with near-infrared transmission spectroscopy

We have evaluated the potential of near-infrared spectroscopy (NIRS) as a technique for rapid analysis of lactate in whole blood. To test the NIRS technique, a comparison was made with a standard clinical method using whole blood samples taken from five exercising human subjects at three different stage of exercise. To expand lactate concentration within the physiological range, standard additions method was used to generate 45 unique data points. Spectra were collected over the 2050-2400 nm spectral range with a 1 mm optical path length quartz cell. Reference lactate concentrations in the samples were determined by enzymatic measurements. Estimates and calibration of the lactate concentration with NIRS was made using partial least squares (PLS) regression analysis and leave-N-out cross validation on second derivative spectra. Separate calibrations were determined from each of the subject samples and cumulative PRESS was used to determine the number of PLS factors in the final model. The results from the PLS model presented are generated from the five individual calibration coefficient vectors and provided a correlation coefficient of 0.978 and a standard error of cross validation of 0.65 mmol l⁻¹ between the enzymatic assay and the NIRS technique. To study the parameters that impact the spectra baseline and the correlation between the calculated model and the data, referenced measurements of lactate against baseline spectrum were made for each individual. A correlation coefficient of 0.992 and a standard error of cross validation of 0.21 mmol l⁻¹ were found. The results suggest that NIRS may provide a valuable tool to assess physiological status for both research and clinical needs.     

废旧涤/棉混纺织物近红外定量分析模型的建立及预测

将中红外光谱筛选出的598个纯涤、纯棉及涤/棉混纺样本采用GB/T 2910.11-2009法测定其涤、棉准确含量,其中校正集样本252个,验证集样本346个。使用便携式近红外光谱仪获取样本的原始近红外光谱(NIRS)。校正集样本依据回归系数的分布趋势和范围选取最佳建模谱区,并采用差分一阶导、S-G平滑和均值中心化相结合的方法对原始光谱进行预处理,利用偏最小二乘法(PLS)建立涤/棉混纺织物中涤含量的近红外(NIR)定量分析模型。同时分析了样本颜色对NIRS的影响,探讨了斜线光谱样本、奇异样本和不同组织结构织物对模型预测效果的影响。结果表明:利用PLS法建立的涤/棉混纺织物定量分析模型最优组合包含1个光谱区间和9个主成分因子,校正集相关系数(RC)为0.998,标准偏差(SEC)为0.908。为验证所建模型的有效性和实用性,对346个未参与建模的涤棉样本进行了预测,并将预测结果与国标法测定值进行方差分析,两种方法结果无显著差异,预测正确率达97%以上。模型的建立为废旧涤/棉混纺织物快速、无损分拣提供了基础数据库。     

Analysis of berberine and total alkaloid content in cortex phellodendri by near infrared spectroscopy (NIRS) compared with high-performance liquid chromatography coupled with ultra-visible spectrometric detection

This paper developed a rapid method using near infrared spectroscopy (NIRS) to differentiate two species of Cortex Phellodendri (CP), Cortex Phellodendri Chinensis (PCS) and Cortex Phellodendri Amurensis (PAR), and to predict quantitatively the content of berberine and total alkaloid content in all Cortex Phellodendri samples. Three alkaloids, berberine, jatrorrhizine and palmatine were analyzed simultaneously with a Thermo ODS Hypersil column by gradient elution with a new mobile phase under high-performance liquid chromatography-diode array detection (HPLC-DAD). Berberine content determined by HPLC-DAD was exploited as a critical parameter for successful discrimination between them. Multiplicative scatter correction (MSC), second derivative and Savitsky-Golay (S.G.) were utilized together to correct the scattering effect and eliminate the baseline shift in all near infrared diffuse reflectance spectra as well as to enhance spectral features in order to give a better correlation with the results obtained by HPLC-DAD. With the use of principal component analysis (PCA), samples datasets were separated successfully into two different clusters corresponding to two species. Furthermore, a partial least squares (PLS) regression method was built on the correlation model. The results showed that the correlation coefficients of the prediction models were R = 0.996 for the berberine and R = 0.994 for total alkaloid content. The influences of water absorption bands present in the NIR spectra on the models were also investigated in order to explore the practicability of NIRS in routine use. The outcome showed that NIRS possibly acts as routine screening in the quality control of Chinese herbal medicine.     

Rapid Simultaneous Determination of Andrographolides in Andrographis paniculata by Near-Infrared Spectroscopy

The potential of near-infrared spectroscopy (NIRS) for the quality control of traditional Chinese medicine has been evaluated. Seven quantitative parameters, andrographolide, deoxyandrographolide, dehydroandrographolide, neoandrographolide, moisture, ash content, and alcohol-soluble extract of Andrographis paniculata, were evaluated by NIRS. The reference values of andrographolides were determined by high-performance liquid chromatography, and the others were obtained using the standard methods of the 2015 Chinese Pharmacopoeia. The predicted values were determined by a quantitative model using NIRS based on partial least square regression. Different spectral preprocessing methods, spectral ranges, and optimum number of factors were selected to optimize the models. All models were estimated by the combination of various parameters, including the correlation coefficient of calibration for andrographolide, deoxyandrographolide, dehydroandrographolide, neoandrographolide, moisture, ash content, alcohol-soluble extract (values of 0.980, 0.984, 0.989, 0.983, 0.987, 0.988, 0.979, respectively), root mean square error of calibration (values of 0.156, 0.038, 0.050, 0.029, 0.604, 0.431, 0.135, respectively), root mean square error of prediction (values of 0.169, 0.041, 0.050, 0.033, 0.280, 0.493, 0.140, respectively), root mean square error of cross-validation (values of 0.626, 0.114, 0.158, 0.046, 1.145, 0.774, 0.508, respectively), and ratio of standard deviation to standard error of prediction (values of 4.583, 4.690, 4.796, 4.899, 4.899, 4.690, 5.099, respectively). The results show that the calibration models by NIRS are reliable and can be applied for the quantification for seven parameters from A. paniculata for quality control in traditional Chinese medicine production and processing.     

Determination of inorganic elements in animal feeds by NIRS technology and a fibre-optic probe

In the present work we study the use of near infra-red spectroscopy (NIRS) technology together with a remote reflectance fibre-optic probe for the analysis of the mineral composition of animal feeds. The method allows immediate control of the feeds without prior sample treatment or destruction through direct application of the fibre-optic probe on the sample.The regression method employed was modified partial least squares (MPLS). The calibration results obtained using forty samples of animal feeds allowed the determination of Fe, Mn, Ca, Na, K, P, Zn and Cu, with a standard error of prediction (SEP(C)) and a correlation coefficient (RSQ) of 0.129 and 0.859 for Fe; 0.175 and 0.816 for Mn; 5.470 and 0.927 for Ca; 2.717 and 0.862 for Na; 4.397 and 0.891 for K; 2.226 and 0.881 for P; 0.153 and 0.764 for Zn, and 0.095 and 0.918 for Cu, respectively.The robustness of the method was checked by applying it to 10 animal feeds samples of unknown mineral composition in the external validation.     

Use of NIRS technology with a remote reflectance fibre-optic probe for predicting major components in bee pollen

In the present work, we study the use of near infra-red spectroscopy (NIRS) technology together with a remote reflectance fibre-optic probe for determination of the major components in bee pollen. The method allows immediate control of the bee pollen without prior sample treatment or destruction through direct application of the fibre-optic probe to the sample.The regression method employed was modified partial least squares (MPLS). The calibration results obtained using 45 samples of bee pollen allowed the measurement of protein, moisture, ash, reducing sugars, and pH with multiple correlation coefficients (RSQ) and prediction corrected standard errors (SEPC) of 0.91, 0.56% for protein, of 0.78 and 0.49% for moisture; 0.92 and 0.049% for ash; 0.81 and 1.32 g of glucose/100 g of bee pollen; 0.84 and 0.15 for pH, respectively.The prediction capacity of the pattern was checked by applying it to samples of unknown pollen in external validation.     

稻米及其植株器官、环境土壤中总汞的快速测定

为了快速获得稻米及其植株器官、环境土壤等系列相关样品中总汞的含量,运用直接测汞仪测量了稻米及其植株器官、环境土壤等系列相关样品中总汞含量,建立了一种快速检测稻米及其植株器官、环境土壤中总汞的方法.优化了仪器的各项参数,最佳仪器条件为裂解温度为650℃保持40 s,释放温度900℃;验证了液体或固体标准物质作外标曲线对样...     

Use of NIRS technology with a remote reflectance fibre-optic probe for predicting major components in cheese

In the present work the potential of near infra-red spectroscopy technology (NIRS) together with the use of a remote reflectance fibre-optic probe for the analysis of fat, moisture, protein and chlorides contents of commercial cheeses elaborated with mixtures of cow's, ewe's and goat's milk and with different curing times was examined. The probe was applied directly, with no previous sample treatment. The regression method employed was modified partial least squares (MPLS). The equations developed for the cheese samples afforded fat, moisture, protein, and chloride contents in the range 13-52%, 10-62%, 20-30%, and 0.7-2.9%, respectively. The multiple correlation coefficients (RSQ) and prediction corrected standard errors (SEP (C)) obtained were respectively 0.97 and 0.995% for fat; 0.96% and 1.640% for moisture; 0.78% and 0.760% for protein, and 0.89% and 0.112% for chlorides.     

Development of Near-Infrared Reflectance Spectroscopy Models for Quantitative Determination of Water-Soluble Carbohydrate Content in Wheat Stem and Glume

Water-soluble carbohydrate (WSC) reserved in stem is an important agronomic trait for crop improvement. The intact samples and pieces of chipped samples were employed to determine WSC content by near-infrared reflectance spectroscopy (NIRS). Three NIRS models were developed to predict WSC content in wheat stem lower internode, upmost internode, and wheat glume, respectively. Moreover, a mixed model was developed for WSC quantitative analysis in the mixed sample of the three wheat organs. Statistics analysis indicated that the four models showed a high determination coefficient (R² ≥ 0.97) and ratio of standard deviation to RMSECV (RPD ≥ 5.99). The NIRS models would allow rapid and high throughout assessments and selections of WSC contents in wheat genetics and breeding programs.     

Determination of amylose in Iranian rice by multivariate calibration of the surface plasmon resonance spectra of silver nanoparticles

A simple and non-separative analytical method for selective determination of amylose in Iranian rice has been developed. It was based on the reduction of silver ions by amylose and production of Ag nanoparticles, which exhibit surface plasmon resonance (SPR) spectra in the ultraviolet/visible region. The formation of Ag nanoparticles in the presence of amylose was monitored by transmission electron microscopy (TEM) and dynamic light scattering (DLS). The experimental conditions were optimized to obtain the highest yield for nanoparticle formation. Partial least square (PLS) regression as an efficient multivariate spectral calibration method was employed to make a connection between the SPR spectra of the generated Ag nanoparticles and the amylose content (AC) of the rice starch. The number of PLS latent variables was optimized by leave-one-out cross-validation utilizing prediction residual error sum of square (PRESS). The proposed model exhibited a high ability for prediction of amylose concentration in both standard starch samples and real rice samples prepared from different regions of Iran. The relative errors of prediction were almost lower than ±5% for different real samples and the detection limit was 3.23 weight percent of amylose in rice. In comparison to the reference method (Juliano method), the proposed method is simpler and does not need tedious sample preprocessing steps.