Standardless method for quantitative particle-size distribution studies by gravitational field-flow fractionation. Application to silica particles

Summary Gravitational field-flow fractionation is a separative analytical technique which has already proved suitable for quantitative particle-size distribution analysis. One of the most attractive aspects of the technique is that it can allow for direct conversion of fractograms into size distributions of the samples, although retention exhibits substantial dependence on flow rate, compared to other field-flow fractionation methods. It is shown here that conversion of fractograms into quantitative, size-distribution profiles of micron-sized silica particles is possible through gravitational field-flow fractionation in standardless mode. Standardless means that the conversion of fractograms is performed by single-run analysis because all the parameters necessary for the calculations can be obtained, from sample specifications and previous instrumental calibration, by means of semiempirical models. Work partially presented at FFF’98-7^th International Symposium on Field-Flow Fractionation, Salt Lake City, Utah (USA), February 8–11, 1998     

Quantitative analysis in field-flow fractionation using ultraviolet-visible detectors: an experimental design for absolute measurements

In previous works, it has been shown that a standard ultraviolet-visible detection system can be used for quantitative analysis of heterogeneous systems (dispersed supermicron particles) in field-flow fractionation (FFF) by single peak area measurements. Such an analysis method was shown to require either experimental measurements (standardless analysis) or an accurate model (absolute analysis) to determine the extinction efficiency of the particulate samples. In this work, an experimental design to assess absolute analysis in FFF through prediction of particles' optical extinction is presented. Prediction derives from the semiempirical approach by van de Hulst and Walstra. Special emphasis is given to the restriction of the experimental domain of instrumental conditions within which absolute analysis is allowed. Validation by statistical analysis and a practical application to real sample recovery studies are also given.     

Concentration and characterization of dilute colloidal samples by potential-barrier field-flow fractionation

Summary Potential-barrier field-flow fractionation, which is a combination of potential-barrier chromatography and sedimentation field-flow fractionation, is shown to be a convenient and accurate method for the concentration and analysis (separation and characterization) ofdilute colloidal samples. Two sizes (0.158 and 0.271 μm) of haematite (α-Fe₂O₃) monodisperse colloidal samples diluted in volumes of up to 20 cm³ are used as model colloids. The particle diameters found by the present concentration procedure under various experimental conditions are in good agreement with those determined by conventional sedimentation field-flow fractionation, in which a small concentrated sample volume was injected directly into the column.     

Experimental study on the retention of silica particles in gravitational field-flow fractionation effects of the mobile phase composition

Effects of mobile phase composition can play an effective role in modulating the retention of particles in gravitational field-flow fractionation (GFFF), the simplest and cheapest among field-flow fractionation (FFF) techniques. In the framework of an optimized procedure for the GFFF characterization of particulate systems, an experimental approach to the effects of the mobile phase composition on the retention of silica particles retention is presented. The role of the ionic strength and the presence of surfactant are emphasized, with special regards to the shape of the particles. Moreover, the first experimental evidence of potential-barrier GFFF is reported.     

Different elution modes and field programming in gravitational field-flow fractionation. 2. Experimental verification of the range of conditions for flow-rate and carrier liquid density programming

Gravitational field-flow fractionation utilises the Earth's gravitational field as an external force that causes the settlement of particles towards the channel accumulation wall. Hydrodynamic lift forces oppose this action by elevating of particles from the channel accumulation wall. Therefore there are several possibilities to modulate the resulting force field acting on particles in gravitational field-flow fractionation. Regarding the force field programming in gravitational field-flow fractionation, this work focused on two topics: changes of the difference between particle density and carrier liquid density in Brownian and focusing elution modes and influencing of lift forces achieved by changing the flow-rate in focusing elution mode. We have found and described the experimental conditions applicable to force field programming in the case of separations of silica gel particles by gravitational field-flow fractionation. It was shown that the effect of carrier liquid viscosity in the water-methanol system is implemented as an additional factor enhancing the desired effect of carrier liquid density. Some other forces influencing the retention behaviour of the model particles are discussed.     

Newly designed flow field-flow fractionation channel for macromolecules and particles in the submicrometer and micrometer range

The flow field-flow fractionation (FIFFF) technique is a promising method for separating and analysing particles and large size macromolecules from a few nanometers to approximately 50 μm. A new fractionation channel is described featuring well defined flow conditions even for low channel heights with convenient assembling and operations features. The application of the new flow field-flow fractionation channel is proved by the analysis of pigments and other small particles of technical interest in the submicrometer range. The experimental results including multimodal size distributions are presented and discussed.     

Newly designed flow field-flow fractionation channel for macromolecules and particles in the submicrometer and micrometer range

The flow field-flow fractionation (FIFFF) technique is a promising method for separating and analysing particles and large size macromolecules from a few nanometers to approximately 50 μm. A new fractionation channel is described featuring well defined flow conditions even for low channel heights with convenient assembling and operations features. The application of the new flow field-flow fractionation channel is proved by the analysis of pigments and other small particles of technical interest in the submicrometer range. The experimental results including multimodal size distributions are presented and discussed.     

Biocompatible channels for field-flow fractionation of biological samples: correlation between surface composition and operating performance

Biocompatible methods capable of rapid purification and fractionation of analytes from complex natural matrices are increasingly in demand, particularly at the forefront of biotechnological applications. Field-flow fractionation is a separation technique suitable for nano-sized and micro-sized analytes among which bioanalytes are an important family. The objective of this preliminary study is to start a more general approach to field-flow fractionation for bio-samples by investigation of the correlation between channel surface composition and biosample adhesion. For the first time we report on the use of X-ray photoelectron spectroscopy (XPS) to study the surface properties of channels of known performance. By XPS, a polar hydrophobic environment was found on PVC material commonly used as accumulation wall in gravitational field-flow fractionation (GrFFF), which explains the low recovery obtained when GrFFF was used to fractionate a biological sample such as Staphylococcus aureus. An increase in separation performance was obtained first by conditioning the accumulation wall with bovine serum albumin and then by using the ion-beam sputtering technique to cover the GrFFF channel surface with a controlled inert film. XPS analysis was also employed to determine the composition of membranes used in hollow-fiber flow field-flow fractionation (HF FlFFF). The results obtained revealed homogeneous composition along the HF FlFFF channel both before and after its use for fractionation of an intact protein such as ferritin.     

场流分级的机内浓缩和再进样方法

<正> 除制备色谱外,一般色谱和场流分级的进样量都是很小的,而溶质层在经过色谱柱或场流分级柱槽后由于分离以及加宽效应浓度又要大大降低,因此,所得级分中溶质的含量极少。如需把所得级分做再进样,则必须在同一条件下重复收集同一集分,经浓缩后再进     

Coupling gravitational and flow field-flow fractionation, and size-distribution analysis of whole yeast cells

This work continues the project on field-flow fractionation characterisation of whole wine-making yeast cells reported in previous papers. When yeast cells are fractionated by gravitational field-flow fractionation and cell sizing of the collected fractions is achieved by the electrosensing zone technique (Coulter counter), it is shown that yeast cell retention depends on differences between physical indexes of yeast cells other than size. Scanning electron microscopy on collected fractions actually shows co-elution of yeast cells of different size and shape. Otherwise, the observed agreement between the particle size distribution analysis obtained by means of the Coulter counter and by flow field-flow fractionation, which employs a second mobile phase flow as applied field instead of Earths gravity, indicates that yeast cell density can play a major role in the gravitational field-flow fractionation retention mechanism of yeast cells, in which flow field-flow fractionation retention is independent of particle density. Flow field-flow fractionation is then coupled off-line to gravitational field-flow fractionation for more accurate characterisation of the doubly-fractionated cells. Coupling gravitational and flow field-flow fractionation eventually furnishes more information on the multipolydispersity indexes of yeast cells, in particular on their shape and density polydispersity.     

重力场流分离系统中载液及流速条件对分离的影响

重力场流分离作为最简单的一种场流分离技术,常用于分离微米级颗粒。选择两种不同粒径(20 μ m和6 μ m)的聚苯乙烯(PS)颗粒作为样品,通过改变载液中叠氮化钠浓度、混合表面活性剂的比例及载液流速,利用自行设计生产的重力场流分离(gravitational flow field-flow fractionation, GrFFF)仪器,对颗粒混合样品进行分离,得到了相关谱图与数据,考察了这3种因素对分离效果(保留比(R)、塔板高度(H))的影响。结果表明:20 μ m PS颗粒的R值均大于6 μ m PS颗粒的R值,H值均小于6 μ m颗粒的H值;PS颗粒的R值与H值均随着载液中叠氮化钠浓度的增加而增加;但随着载液流速的增加,R值增加,H值减小。该研究为GrFFF系统的开发及应用提供了重要的参考价值。     

Separation and characterization of particles in natural water and soil using flow field-flow fractionation

Flow field-flow fractionation (FlFFF) is used to characterize particles in natural water (ground and surface water) and soil. The opposed flow sample concentration (OFSC) mode of FlFFF (OFSC-FlFFF) is employed, where the colloidal sample is continuously fed into the channel so that the particles are focused into a narrow band near the inlet of the FlFFF channel before the separation is initiated. There is no need for stopping the flow for the sample relaxation, which is usually required in conventional FlFFF operations. First, the OFSC-FlFFF is tested with mixtures of polystyrene latex spheres. Then the OFSC-FlFFF procedure is optimized for the analysis of particles in natural water and soil by varying various experimental parameters including the flow rates. Ground water of up to 100 mL has been successfully loaded, concentrated, and characterized by OFSC-FlFFF. Results show that the OFSC-FlFFF provides a simplified alternative to existing off-line concentration procedures, and it shows high potential for application to analysis of dilute colloidal particles in environmental water. The composition of the samples was analyzed using atomic absorption spectrometry.     

Continuous two-dimensional field-flow fractionation: a novel technique for continuous separation and collection of macromolecules and particles

Instrumental techniques to analyse macromolecular and particulate materials have undergone rapid development in response to the need for high resolution, precise identification and characterization, and enrichment and collection for further analysis. Continuous two-dimensional field-flow fractionation (2D-FFF), which is described in this article, is a novel technique for separation and collection of macromolecules and particles. 2D-FFF is based on the conventional field-flow fractionation principle but with carrier flow in two-dimensions. This overview discusses the principle of the technique, describes the instrumentation and suggests potential applications and further extensions. An overview of the basic field-flow fractionation principle is presented.     

Impact of Ionic Strength of Carrier Liquid on Recovery in Flow Field-Flow Fractionation

Asymmetrical flow field-flow fractionation (AF4) and hollow-fiber flow field-flow fractionation (HF5) are techniques widely used in analytical, industrial and biological analyses. The main problem in all AF4 and HF5 analyses is sample loss due to analyte–membrane interactions. In this work the impact of liquid carrier composition on latex nanoparticles (NPs) separation in water and two different concentrations of NH₄NO₃ was studied. In AF4, a constant trend of decreasing the size of 60 and 121.9 nm particles induced by the ionic strength of the carrier liquid has been observed. In contrast, an agglomeration effect of the biggest 356 nm particles was observed when increasing ionic strength, which induced a significant drop of recovery to 35%. H5F provides better resolution and intensified peaks of NPs, but careful optimisation of system parameters is mandatory to obtain good separation.     

Improved accuracy in the determination of field-flow fractionation elution volumes.

Conventional operation of field-flow fractionation (FFF) systems involves carrying out the analysis at a constant flow of carrier; the flow is temporarily interrupted after injection of a sample in order to permit its equilibration under the applied field. Retention is calculated as the ratio of elution times for a non-retained species and the sample of interest, respectively. Such time-based retentions are only valid if the flow-rate is precisely known at all times during the run. The peristaltic pumps often used with FFF equipment are shown to have an output which varies unpredictably in time. Furthermore, initiation of flow after relaxation is shown to result in significant periods of transient behaviour while the system adjusts to the operating pressure. These and other variations in flow-rate can be eliminated as sources of error by basing the retention measurement on effluent weight, rather than on time. For this purpose, an electronic balance is interfaced with the system's computer, so that detector response/effluent weight data pairs are continuously monitored during the course of the FFF analysis.     

Determination of particle size distribution by gravitational field-flow fractionation: Dimensional characterization of silica particles

Summary Gravitational field-flow fractionation (GFFF) is the simplest and cheapest of field-flow fractionation (FFF) techniques, although it is still at an early development stage. The application of GFFF to the determination of particle size distribution (PSD) of silica particles used as chromatographic supports is described. The accuracy of the method is evaluated by comparing PSDs obtained by GFFF with those obtained by laser diffraction, a non-separative technique widely applied to particle characterization. It is ultimately demonstrated that a low-cost GFFF channel can simply replace the column of a standard HPLC system, allowing laboratories that are not specialized in size analysis to perform accurate PSD studies with standard HPLC expertise.     

Gravitational field-flow fractionation in combination with flow injection analysis or electrothermal AAS for size based iron speciation of particles

A simple gravitational field-flow fractionation (GrFFF) system was used for size separation of micron sized silica particles coated with hydrous iron oxide (geothite). The amount of iron on the particles was monitored either on-line by reverse-flow injection analysis (r-FIA) with chemiluminescence detection using luminol or off-line by electrothermal atomic absorption spectrophotometry (ETAAS). The combination of GrFFF with reverse FIA or with ETAAS has been demonstrated to be a cost-effective tool for size based iron speciation of particles.     

Fractionation and characterization of nano- and microparticles in liquid media

Submicron and micron particles present in liquid environmental, biological, and technological samples differ in their dimensions, shape, mass, chemical composition, and charge. Their properties cannot be reliably studied unless the particles are fractionated. Synthetic particles applied as components of analytical systems may also need preliminary fractionation and investigation. The review is focused on the methods for fractionation and characterization of nanoparticles and microparticles in liquid media, the most representative examples of their application, and the trends in developing novel approaches to the separation and investigation of particles. Among the separation techniques, the main attention is devoted to membrane filtration, field-flow fractionation, chromatographic, and capillary electrokinetic methods. Microfluidic systems employing the above-mentioned and other separation principles and providing a basis for the fabrication of lab-on-chip devices are also examined. Laser light scattering methods and other physical techniques for the characterization of particles are considered. Special attention is given to “hyphenated” techniques which enable the separation and characterization of particles to be performed in online modes.     

Combination of gravitational SPLITT fractionation and field-flow fractionation for size-sorting and characterization of sea sediment

A combination of gravitational split-flow thin (SPLITT) fractionation and sedimentation/steric field-flow fractionation (Sd/StFFF) has been used for continuous size-sorting of a sediment sample and for size analysis of the collected fractions. An IAEA (International Atomic Energy Agency) sediment material was separated into four size fractions (with theoretical size ranges <1.0, 1.0–3.0, 3.0–5.0, and >5.0 m in diameter) by means of a three-step gravitational SPLITT fractionation (GSF) for which the same GSF channel was used throughout. The GSF fractions were collected and examined by optical microscopy (OM) and by Sd/St FFF. The mean diameters of the GSF fractions measured by OM were within the size interval predicted by GSF theory, despite the theory assuming that all particles are spherical, which is not true for the sediment particles. The Sd/St FFF results showed that retention shifted toward shorter elution time (or larger size) than expected, probably because of the shape effect. The results from GSF, OM, and Sd/StFFF are discussed in detail.     

Simulation of the motion of solid particles in the carrier liquid flow in a rotating coiled column

Particle fractionation is necessary to solve problems related to the determination of impurity speciation of natural waters, soils, and bottom sediments. It was shown earlier that rotating coiled columns are suitable for field-flow fractionation of particles in a transverse centrifugal field. However, the wide use of rotating coiled columns for separating particles in the substance analysis of natural materials is hampered by the progress of theoretical aspects of the method. In this work, a mathematical model is proposed to describe the behavior of solid particles in the carrier liquid flow in rotating coiled columns. The motion of particles in the flow of a carrier liquid and their migration along the column walls are considered. Equations relating the velocity, radius, and density of a particle; the density and viscosity of the carrier liquid; and the operational and construction parameters of the rotating column are derived. Some practical recommendations are made for the selection and optimization of fractionation conditions.__________Translated from Zhurnal Analiticheskoi Khimii, Vol. 60, No. 4, 2005, pp. 349–356.Original Russian Text Copyright © 2005 by Fedotov, Kronrod, Kasatonova.