Use of a multifunctional column for the determination of deoxynivalenol in grains, grain products, and processed foods

Deoxynivalenol (DON), also known as vomitoxin, belongs to a class of naturally occurring mycotoxins produced by Fusarium spp. DON, 12, 13-epoxy-3,7 trihydroxytrichothec-9-en-8-one, is one of the most frequently detected mycotoxins in agricultural commodities worldwide. A method consisting of extraction, filtration, column cleanup, and RP-HPLC-UV separation and quantitation was validated for the determination of DON in grains (rice and barley), grain products (whole wheat flour, white flour, wheat germ, and wheat bran), and processed foods (bread, breakfast cereals, and pretzels). A 25 g test portion was extracted with 100 mL acetonitrile-water (84 + 16, v/v). After blending for 3 min, the supernatant was applied to a multifunctional column (MycoSep 225). The purified filtrate (2 mL) was evaporated to dryness and redissolved in the mobile phase. The toxins were then subjected to RP-HPLC-UV analysis. The accuracy and repeatability characteristics of the method were determined. Recoveries of DON added at levels ranging from 0.5 to 1.5 microg/g for all test matrixes were from 75 to 98%. SD and RSD(r) ranged from 0.7 to 11.6% and 0.9 to 12.7%, respectively. Within-laboratory HorRat values were from 0.1 to 0.7 for all matrixes analyzed. The method was found to meet AOAC method performance criteria for grains, grain products, and processed foods. The identity of DON in naturally contaminated test sample extracts was confirmed by HPLC/MS/MS analysis.     

Comparison of four C18 columns for the liquid chromatographic determination of deoxynivalenol in naturally contaminated wheat

Three long and 1 short reversed-phase C18 columns were compared for separation of deoxynivalenol (DON) in extracts of naturally contaminated wheat samples using liquid chromatography with ultraviolet detection and liquid chromatography/mass spectrometry (LC/MS). Among the 3 long columns used, a Symmetry C18 column with an isocratic solvent mixture of water-acetonitrile-methanol (90 + 5 + 5, v/v/v) gave the best separation for DON without interferences from other compounds in the wheat extracts. The Symmetry short (75 mm) column was comparable with the long column (250 mm) in resolving DON but significantly reduced retention time (i.e., 5.8 versus 16.3 min). Increasing the column temperature from 25 to 45 degrees C resulted in a further reduction in retention time. Identity of DON in the wheat extracts and standard solutions was confirmed by LC/MS in the positive ion mode, whereby DON appeared with an (M+1)+ ion at a mass-to-charge ratio of 297 plus fragment ions associated with loss of water and/or a 30 atomic mass unit (amu) CH2O fragment. The Symmetry short column was also capable of separating a mixture of the mycotoxins DON, 15-acetyl-DON, nivalenol, and zearalenone by use of a combination of an isocratic and gradient solvent system. The overall method showed high precision, exhibiting a relative standard deviation of 4.8%, limit of detection of 50 ng/g, and limit of quantitation of 165 ng/g. It was significantly correlated with enzyme-linked immunosorbent assay analysis, indicating its appropriateness for safety and quality assurance of wheat and related grains.     

Interlaboratory comparison study for the determination of the Fusarium mycotoxins deoxynivalenol in wheat and zearalenone in maize using different methods

Seventeen laboratories from six different countries, using their usual in-house methods, participated in an interlaboratory comparison test for the determination of the Fusarium mycotoxins deoxynivalenol (DON) in wheat and zearalenone (ZON) in maize. The toxins generally were extracted from maize and wheat employing mixtures of water, acidified water with an organic solvent or even pure water (for DON). While participants who used enzyme linked immuno sorbent assays (ELISA) for the determination of DON did not perform any clean-up, various techniques were applied for the purification of raw extracts (e.g. liquid/liquid extraction, solid phase extraction (SPE), immuno affinity chromatography (IAC)). For the final separation/quantification step either high performance liquid chromatography (HPLC) (mostly for ZON), gas chromatography (GC) (for DON) or ELISA were employed by participants. The aim of this study was to obtain information about the state of the art of mycotoxin analysis in cereals and to support a knowledge and experience exchange between the participating laboratories in the field of mycotoxin analysis. For each mycotoxin 5 different sample types were distributed, standard solutions (10.10 μg/ml ZON in methanol, 10.09 μg/ml DON in ethyl acetate), blank materials, spiked samples (75.1 μg/kg and 378.3 μg/kg ZON in maize, 126.2 μg/kg and 2519 μg/kg DON in wheat) and naturally contaminated maize and wheat. Coefficients of variation (CV) between laboratory mean results (outliers excluded) ranged from 6.2 to 27.7% for ZON and from 18.9 to 30.0% for DON. Except for the maize samples spiked at 75.1 μg/kg ZON the overall means (outliers rejected) statistically could not be distinguished from the respective target values. Average recoveries of the reported results ranged from 87.7 to 96.2% for ZON and from 94.2 to 108.5% for DON.     

Determination of nivalenol and deoxynivalenol in wheat using liquid chromatography-mass spectrometry with negative ion atmospheric pressure chemical ionisation.

A new, rapid and sensitive method has been developed for the determination of nivalenol (NIV) and deoxynivalenol (DON) by using HPLC in combination with an atmospheric pressure chemical ionization (APCI)-interface and a single quadrupole mass spectrometer. Different LC and MS parameters have been optimized prior to this in order to obtain better results and sensitivity. The effect of nebulizing temperature on the sensitivity and fragmentation of NIV and DON in an APCI interface was investigated. Also, the influence of the cone voltage on the fragmentation pattern was studied, which was shown to have a tremendous effect. Furthermore, the effect of modifiers such as ammonium acetate, acetic acid and ammonia on the ionisation yield of the above substances have been investigated. The extraction was carried out using acetonitrile-water. A two step purification was then applied on two different Mycosep clean up columns. We have used a modified, rapid and isocratic HPLC method combined with a negative ion APCI-MS for the separation and quantitative determination of NIV and DON in wheat extract. An RP C18 column was used for the separation of selected compounds in wheat extract with water-acetonitrile-methanol (82:9:9, v/v/v) at a flow-rate of 1 ml/min without a split. Calibration curves show good linearity and reproducibility. The detection limit and precision were determined for NIV and DON. Both compounds could be detected down to microg/kg level in wheat using selected ion monitoring of the [M-H]- ions and the main fragments.     

Isolation and determination of carbendazim residue from wheat grain by matrix solid‐phase dispersion and HPLC

Carbendazim residues were analyzed by column‐switching high‐performance liquid chromatography (HPLC) with photodiode array detection (PDA). The active ingredient was extracted by matrix solid‐phase dispersion (MSPD) from wheat grain on an acidic silica gel column using a methanol‐dichloromethane mixture. The recovery rate for fortified samples was 87.3 ± 3.3% with a standard deviation (SD) of 2.9%. The detection limit was 0.02 μg/mL. The method was applied to the determination of carbendazim residues in wheat grain samples from a treated field.     

Interlaboratory comparison study for the determination of the Fusarium mycotoxins deoxynivalenol in wheat and zearalenone in maize using different methods

Seventeen laboratories from six different countries, using their usual in-house methods, participated in an interlaboratory comparison test for the determination of the Fusarium mycotoxins deoxynivalenol (DON) in wheat and zearalenone (ZON) in maize. The toxins generally were extracted from maize and wheat employing mixtures of water, acidified water with an organic solvent or even pure water (for DON). While participants who used enzyme linked immuno sorbent assays (ELISA) for the determination of DON did not perform any clean-up, various techniques were applied for the purification of raw extracts (e.g. liquid/liquid extraction, solid phase extraction (SPE), immuno affinity chromatography (IAC)). For the final separation/quantification step either high performance liquid chromatography (HPLC) (mostly for ZON), gas chromatography (GC) (for DON) or ELISA were employed by participants. The aim of this study was to obtain information about the state of the art of mycotoxin analysis in cereals and to support a knowledge and experience exchange between the participating laboratories in the field of mycotoxin analysis. For each mycotoxin 5 different sample types were distributed, standard solutions (10.10 μg/ml ZON in methanol, 10.09 μg/ml DON in ethyl acetate), blank materials, spiked samples (75.1 μg/kg and 378.3 μg/kg ZON in maize, 126.2 μg/kg and 2519 μg/kg DON in wheat) and naturally contaminated maize and wheat. Coefficients of variation (CV) between laboratory mean results (outliers excluded) ranged from 6.2 to 27.7% for ZON and from 18.9 to 30.0% for DON. Except for the maize samples spiked at 75.1 μg/kg ZON the overall means (outliers rejected) statistically could not be distinguished from the respective target values. Average recoveries of the reported results ranged from 87.7 to 96.2% for ZON and from 94.2 to 108.5% for DON. Received: 2 December 1996 / Revised: 17 February 1997 / Accepted: 18 February 1997     

Purification of deoxynivalenol from Fusarium graminearum rice culture and mouldy corn by high-speed counter-current chromatography

Deoxynivalenol (DON) is a mycotoxin produced by several Fusarium species and is toxic to a wide range of organisms, including human beings and livestock. To produce large amounts of pure DON for research purposes, a novel method using high-speed counter-current chromatography (HSCCC) was developed. Rice cultured with Fusarium graminearum and field mouldy corn infected by F. graminearum were extracted with methanol and found to contain 1.16 and 1.30 mg DON/g, respectively. The extracts were concentrated and then separated using a biphasic solvent system consisting of ethyl acetate-water (1:1, v/v). Collected fractions were analyzed by high-performance liquid chromatography (HPLC) and identified by congruent retention time and UV/vis spectrum and mass spectrometric data. Fractions containing DON were combined and freeze-dried. This method produced 116 mg and 65 mg DON with a purity of greater than 94.9% from 200 g of the rice culture and the mouldy corn, respectively. The HSCCC method had a recovery rate of DON at 88% from the crude extracts of both samples. This one-step purification method provided a simple and effective tool for obtaining a large amount of DON, an essential material for studies related to toxicology and detoxification of this mycotoxin.     

正交设计试验优化高速逆流色谱分离制备玛咖中芥子油苷的条件

基于高速逆流色谱（HSCCC）技术从玛咖中分离制备出两种芥子油苷,苄基芥子油苷（glucotropaeolin, GTL）和甲氧基苄基芥子油苷（glucolimnanthin, GLI）。使用正交设计试验对分离条件进行优化,采用高分辨质谱对制备的组分进行鉴定,采用高效液相色谱法（HPLC）对组分进行定量分析。确定了两个组分GTL与GLI的HSCCC最佳分离条件：溶剂系统为正丁醇-乙腈-200 g/L硫酸铵溶液（1:0.5:2.4, v/v/v）,上相为固定相,下相为流动相,流动相流速2 mL/min,主机转速900 r/min,从玛咖根粗提物中一次性分离得到157.72 mg/kg纯度为97.9%的苄基芥子油苷和31.93 mg/kg的甲氧基苄基芥子油苷,固定相保留率达57.6%。该方法成本低,简便易行,样品损失量小,可大量循环进样制备。     

Suitability of a fully 13C isotope labeled internal standard for the determination of the mycotoxin deoxynivalenol by LC-MS/MS without clean up

Very often, the accuracy of quantitative analytical methods for the determination of mycotoxins by liquid chromatography (LC)-mass spectrometry (MS) and LC-MS/MS is limited by matrix effects during the ionization process in the MS source. Stable isotope labeled standards are best suited to correct for matrix effects and to improve both the trueness and the precision of analytical methods employing LC-MS and LC-MS/MS. This paper describes the successful use of fully ¹³C isotope labeled deoxynivalenol [(¹³C₁₅)DON] as an internal standard (IS) for the accurate determination of DON in maize and wheat by LC electrospray ionization MS/MS. To show the full potential of (¹³C₁₅)DON as IS, maize and wheat extracts were analyzed without further cleanup. Subsequent to calibration for the LC-MS end determination, DON was quantified in matrix reference materials (wheat and maize). Without consideration of the IS, apparent recoveries of DON were 29±6% (n=7) for wheat and 37±5% (n=7) for maize. However, the determination of DON in the reference materials yielded 95±3% (wheat) and 99±3% (maize) when (¹³C₁₅)DON was used as an IS for data evaluation.     

Development of a colloidal gold-based lateral-flow immunoassay for the rapid simultaneous detection of zearalenone and deoxynivalenol

A multianalyte lateral-flow technique using colloidal gold-labeled monoclonal antibodies was developed for the rapid simultaneous detection of deoxynivalenol (DON) and zearalenone (ZEA). The results of this qualitative one-step test were interpreted visually. A very simple and fast sample preparation was used, and the assay procedure could be accomplished within 10 min. When applied to spiked wheat samples, the technique gave accurate and reproducible results. Cut-off levels of 1500 and 100 μg kg⁻¹ for DON and ZEA, respectively, were observed. The described multianalyte format can be used as a reliable, rapid and cost-effective on-site screening technique for the simultaneous determination of mycotoxins in grain samples.     

液相色谱-串联质谱法测定小麦中T-2、ZEN及DON 3种镰刀菌毒素

采用液相色谱-串联质谱建立了小麦中T-2、玉米赤霉烯酮（ZEN）和脱氧镰刀菌烯醇（DON）的测定方法。样品经80% 乙腈-水提取,氨基柱（500 mg,6 mL）杂质吸附模式净化,以5 mmol/L乙酸铵溶液和甲醇为流动相,ZORBAX Extend-C18柱（150 mm×2.1 mm,1.8 μm）进行色谱分离;在电喷雾正离子化模式下,多反应监测方式测定。结果表明：T-2、ZEN和DON分别在0.5~500、5~500、10~2 000 μg/L质量浓度范围内呈良好线性,相关系数分别为0.998 9、0.999 7和0.999 1。通过对空白小麦样品进行3个水平的加标回收实验,T-2、ZEN和DON的回收率分别为86%~94%、80%~101%和81%~105%,相对标准偏差（RSD）分别为2.6%~5.5%、3.6%~8.9%和2.2%~8.1%,方法检出限分别为0.5、8.0、10.0 μg/kg。该方法准确、灵敏、成本低,适用于小麦中T-2、ZEN和DON的同时分析。     

Effects of different extraction methods and conditions on the phenolic composition of mate tea extracts

A simple and rapid HPLC method for determination of chlorogenic acid (5-O-caffeoylquinic acid) in mate tea extracts was developed and validated. The chromatography used isocratic elution with a mobile phase of aqueous 1.5% acetic acid-methanol (85:15, v/v). The flow rate was 0.8 mL/min and detection by UV at 325 nm. The method showed good selectivity, accuracy, repeatability and robustness, with detection limit of 0.26 mg/L and recovery of 97.76%. The developed method was applied for the determination of chlorogenic acid in mate tea extracts obtained by ethanol extraction and liquid carbon dioxide extraction with ethanol as co-solvent. Different ethanol concentrations were used (40, 50 and 60%, v/v) and liquid CO? extraction was performed at different pressures (50 and 100 bar) and constant temperature (27 ± 1 °C). Significant influence of extraction methods, conditions and solvent polarity on chlorogenic acid content, antioxidant activity and total phenolic and flavonoid content of mate tea extracts was established. The most efficient extraction solvent was liquid CO? with aqueous ethanol (40%) as co-solvent using an extraction pressure of 100 bar.     

Reversed-phase high-performance liquid chromatographic separation and electrochemical detection of retinol and its isomers

Baseline separation of the isomers of retinol using reversed-phase high-performance liquid chromatography (HPLC) in less than 30 min is presented. A new approach to the detection of retinol using electrochemical detection is developed. The oxidative electrochemistry of retinol is studied at a glassy-carbon electrode using coulometry, ultraviolet-visible spectrophotometry and HPLC. Amperometric detection in HPLC for retinol provided a linear response from 0 to 1.5 micrograms/ml and a detection limit of 4.1 ng/ml. Electrochemical detection was compared to ultraviolet-visible absorbance detection for the determination of retinol in human serum extracts. Good agreement is found for the results obtained with the two detectors.     

Rapid determination of chlorogenic acid and related compounds in sunflower seeds by high-performance liquid chromatography/atmospheric pressure chemical ionization mass spectrometry

High-performance liquid chromatography (HPLC) in combination with atmospheric pressure chemical ionization mass spectrometry (APcI-MS) was applied to the determination of the phenolic fraction found in methanolic extracts of sunflower seeds (mainly chlorogenic acid and derived compounds). These extracts were directly separated by HPLC and detected by both negative and positive APcI-MS. Abundant structural information about these compounds can be obtained even at low extraction cone voltages. This method has been shown to be a rapid and effective method for the analysis of crude extracts from sunflower seeds.     

The use of supercritical fluid extraction for the determination of 4-deoxynivalenol in grains: The effect of the sample clean-up and analytical methods on quantitative results

Summary Deoxynivalenol (DON) is one of the trichothecene mycotoxins produced byFusarium molds in grains. Polar cosolvents in supercritical carbon dioxide (SC-CO₂) are needed to extract and isolate the polar DON moiety. This unfortunately results in the extraction of many interfering compounds from the grains into the extracts obtained by supercritical fluid extraction (SFE). Analysis of DON by high performance liquid chromatography (HPLC) using ultraviolet detection (UV) does not provide a specific detection method, although specific detection of DON can be enhanced by using purification steps after SFE. Alternatively, combining SFE with an immunoaffinity method can improve detection specificity and sample cleanup. In this study, SFE was employed to determine DON in grains and cereal products. The effectiveness of the SFE method was compared with two different solvent extraction methods. The extracted DON was quantitatively determined by HPLC-UV using external standardization or competitive enzymelinked immunosorbent assay (ELISA). In some cases, extracts were purified prior to quantitative analysis of the DON by using solvent partitioning, and/or solid phase extraction, or immunoaffinity columns. Therefore, this paper describes the analysis of DON in cereals using different extraction, cleanup and analysis methods. Names are necessary to report factually on available data: however, the USDA neither guarantees nor warrants the standard of the product, and the use of the name by USDA implies no approval of the products to the exclusion of others that may also be suitable.     

Determination of nivalenol and deoxynivalenol by liquid chromatography/atmospheric pressure photoionization mass spectrometry

Fusarium species, a plant pathogenic fungus of wheat and other cereals, produces toxic metabolites such as nivalenol (NIV) and deoxynivalenol (DON). Control of contamination by these toxins is very difficult, and a continuous survey of the occurrence is necessary for these toxins. Thus, the accurate and convenient determination of the cereals contaminated with these toxins is important for the supply of safe foods. A selective analytical method based on high‐performance liquid chromatography, combined with atmospheric pressure photoionization (APPI) mass spectrometry, has been developed for simultaneous determination of NIV and DON. The parameters investigated for the optimization of APPI were the ion source parameters fragmentor voltage, capillary voltage, and vaporizer temperature, and also mobile phase composition and flow rate. Furthermore, chemical noise and signal suppression of analyte signals due to sample matrix interference were investigated for APPI. The results indicated that APPI provides lower matrix effect and the correlation coefficient of NIV and DON in the range 0.2–100 ng · mL^?1 was above 0.999. Recoveries of NIV and DON in wheat ranged from 86 to 107% and limits of detection of NIV and DON were 0.20 ng · g^?1 and 0.39 ng · g^?1, respectively. In addition, the proposed method was applied for the analysis of naturally contaminated wheat samples. APPI was found to offer lower matrix effect and was a convenient technique for routine analysis of NIV and DON residues in wheat at trace levels. Copyright © 2009 John Wiley & Sons, Ltd.     

Simultaneous liquid chromatography-fluorescence analysis of type A and type B trichothecenes as fluorescent derivatives via reaction with coumarin-3-carbonyl chloride

A method for the simultaneous LC-fluorescence detection (FLD) determination of eight trichothecenes A and B by pre-column derivatization with coumarin-3-carbonyl chloride, a highly fluorescent fluorophore, has been developed. The reaction conditions (temperature, reaction time, reactant ratios) were optimized to give a reproducible quantitative conversion. All derivatives were characterized by LC-MS. The chromatographic parameters were optimized (column, eluent) to give a very good separation of three type A (diacetoxyscirpenol, T-2 toxin, HT-2 toxin) and five type B trichothecenes [deoxynivalenol (DON), nivalenol, fusarenon-X, 3-acetyldeoxynivalenol, 15-acetyldeoxynivalenol]. The best conditions were obtained on a narrow-bore C18 column with a water-methanol gradient. The detection limits (S/N = 3:1) in grain samples, with an injected volume of 5 microl, were 0.2-1 ng/g for all trichothecenes. These values are more than one order of magnitude lower than those of other LC-FLD and LC-MS methods and are similar to those obtained by GC-MS. The calibration curves were linear between 100 and 2500 ng/g. The method was successfully applied to the analysis of a certified wheat reference material, after solvent extraction and clean-up on a Mycosep column, obtaining a good recovery (89% for DON) and a high accuracy (z-score value: 0.67).     

Determination of T-2 toxin in cereal grains by liquid chromatography with fluorescence detection after immunoaffinity column clean-up and derivatization with 1-anthroylnitrile

1-Anthroylnitrile (1-AN) has been shown to be an efficient labelling reagent for the determination of T-2 toxin (T-2) by high-performance liquid chromatography (HPLC)-fluorescence detection. This reaction has been used to develop a sensitive, reproducible and accurate method for the determination of T-2 in wheat, corn, barley, oats, rice and sorghum. The method uses immunoaffinity columns containing antibodies specific for T-2 for extract clean-up, pre-column derivatization with 1-AN and HPLC with fluorescence detection for toxin determination. Ground cereal samples were extracted with methanol-water (80:20, v/v), the extracts were purified by immunoaffinity columns and the toxin was quantified by reversed-phase HPLC with fluorometric detection (excitation wavelength 381 nm, emission wavelength 470 nm) after derivatization with 1-AN. Recoveries from the different cereals spiked with T-2 at levels ranging from 0.05 to 1.5 microg/g were from 80 to 99%, with relative standard deviations of less than 6%. The limit of detection was 0.005 microg/g, based on a signal-to-noise ratio of 3:1.     

Analysis of alkyl organoiodide mixtures by high-performance liquid chromatography using electrochemical detection with a post-column photochemical reactor

A method for the analysis of six alkyl organoiodides (iodomethane, iodoethane, 1-iodopropane, 1-iodobutane, 1-iodopentane, 1-iodohexane) commonly found in acetic acid process was developed. In this method the target analytes were determined by high-performance liquid chromatography (HPLC) using a post-column photochemical reactor with electrochemical detection (ED) in less than 30 min. HPLC was performed in ODS C18 reversed-phase column (5 microm, 250 x 4.6 mm I.D.) under isocratic conditions with methanol-0.067 M acetate buffer (70:30, v/v), pH 6.2 as mobile phase at flow-rate 1.1 ml/min. Alkyl organoiodides, which are electrochemically inactive, were made oxidizable at potential of 120 mV after post-column irradiation with low-pressure mercury lamp in a knitted PTFE tube. The photoreactor was placedin an aluminum housing full of nitrogen in order to prevent from the interference of oxygen. The detection limit for most analytes was of the order of 1-2 microg/l. The HPLC-ED method with a post-column photochemical reactor has good precision and linearity and can be readily applied to the routine determination of alkyl organoiodides in real acetic acid samples.     

New strategy for the determination of microcystins and diarrhetic shellfish poisoning (DSP) toxins, two potent phosphatases 1 and 2A inhibitors and tumor promoters

A new analytical strategy was established to improve the determination and identification performance during analyses of microcystins and diarrhetic shellfish poisoning (DSP) toxins in different matrices. Automated high performance size exclusion chromatography (gel permeation chromatography, SEC) was applied for the clean-up of raw extracts from algae and mussel tissue containing either microcystins or DSP toxins. The cleaned raw extracts are well suited for the direct determination of microcystins and DSP toxins by HPLC/MS. The analyses of cleaned raw extracts containing microcystin by HPLC and UV/diode array detection (DAD) revealed chromatograms without interfering peaks. Additionally, methods for the identification of unknown microcystins and those not available as standards were developed and established. The proposed strategy is exemplarily demonstrated for the analyses of a natural algae community from a lake in Slowakia and a naturally contaminated mussel from Portugal.