羰基铑簇合物衍生的多相烯烃氢甲酰化催化剂的性能及红外表征

在常压下,Rh_4(CO)_(12)或Rh_6(CO)_(16)簇合物衍生的Rh/SiO_2对乙烯,丙烯氯甲酰化反应表现出良好的催化活性和选择性,并有利于直线醛的形成.乙烯氢甲酰化体系的表面催化比活性与Rh分散性的关系表明.乙烯氢甲酰化反应具有结构敏感性,而乙烯加氢反应具有结构非敏感性,高分散的金属表面有利于主反应的选择性.通过红外光谱跟踪,发现表面Rh在反应气氛中显示零价.根据接触时间对催化反应的影响,推测多相烯烃氢甲酰化及加氢反应都在Ph~0活性中心上进行.另外,担载羰基铑簇合物的热分解红外研究结果指出,表面羰基化合物金属中心上的配位不饱和性对氢甲酰化催化活性似乎起着重要影响,簇合物只有完全脱羰才能提供高活性的催化中心.在反应气氛和CO气氛中,担载Rh_6(CO)_(16)表现出一致的热稳定性,说明反应气中的CO对稳定羰基物起着主导作用.     

双核茂金属催化剂催化聚合反应进展

综述了双核茂金属化合物的研究进展及其在烯烃和极性单体聚合方面的应用及双核茂金属化合物的合成及性能研究；并对双核催化剂的作用机理、催化剂结构与性能的关系也做了介绍。     

Modification of Rhodium Catalyst with Stibines for Hydroformylation of 1‐Pentene

Homogeneous hydroformylation of 1‐pentene under synthesis gas experimental conditions was studied using RhClCO(PPh₃)₂ complex with different triarylstibines. Three different stibine ligands SbR₃ [where R = 2,4,6‐mesityl (TMS), 2‐furyl (TFS), 2‐N,N‐dimethylbenzylamine (TDMBAS)], have been tested. It is interesting to note that 2:1 addition of these stibine ligands to the RhClCO(PPh₃)₂ complex catalyst increases the aldehydes yields with an appreciable n:iso ratio. The catalytic activity of the system shows a TDMBAS > TMS > TFS pattern which indicates that not only basicity of the ligand alone is playing a role in the activity but the steric effect is also very important, and it is combination of these two factors that contributes to the resulting catalytical activity. The maximum yield of aldehydes obtained were 98.7% with n/iso = 1.4 when RhClCO(PPh₃)₂ + TFS system was used and 93.7% with n/iso = 2.43 when TDMBAS ligand was studied.     

Rh/Ph3PO催化剂体系的辛烯氢甲酰化反应性能考察和原位红外表征

考察了反应温度,ＣＯ／Ｈ２压力和Ｐ／Ｒｈ比等因素,对Ｒｈ／Ｐｈ３ＰＯ催化剂催化混合辛烷氢甲酰化反应活性的影响,优化出最佳反应条件,并采用加热加压的原位红外表征方法,跟踪了在１－辛烯反应中Ｒｈ／Ｐｈ３ＰＯ催化剂的活化、中间活性物种的产生和分解消失等瞬态变化情况。     

电感耦合等离子体质谱法测定汽车尾气净化催化剂中铂、钯、铑含量

汽车尾气净化催化剂样品经过氧化钠熔融,用热水浸出,加入盐酸酸化后,分取部分试液用电感耦合等离子体质谱法测定其中铂、钯、铑的含量。选择镉(~(111)Cd)和铊(~(203)Tl)作为内标元素。铂、钯、铑的检出限(3s)分别为0.048,0.056,0.019μg·g~(-1)。方法用于5件催化剂样品的分析,测定结果与光度法测定结果相一致。铂、钯、铑的平均回收率分别为100.0%,100.0%,99.8%;相对标准偏差(n=12)分别为1.3%,1.0%,1.6%。     

担载三核羰基钴簇的合成,表征和烯烃氢甲酰化反应

通过配体交换反应合成了膦化硅胶担载的羰基钴簇配合物(Si)—PPh_2[BrCCo_3(CO)_(9-2)],用IR、XPS和DPS对其结构进行了表征,并测得了担载簇配合物的金属含量,研究了担载簇(Si)—PPh_2[BrCCo_3(CO)_(9-2)]在烯烃氢甲酰化反应中的催化活性.结果表明,担载的三核羰基钴簇可达到与均相三核钴簇基本一致的反应活性,在一定的反应条件下,烯烃转化率和醇醛收率均在85％以上,有很少量的加氢产物生成。     

Synthesis and characterisation of two novel Rh(I) carbene complexes: Crystal structure of [Rh(acac)(CO)(L1)]

The [Rh(acac)(CO)(L)] (acac = acetylacetonato; L₁ = 1,3-bis-(2,6-diisopropylphenyl)imidazolinylidene and L₂ = 1,3-bis-(2,4,6-trimethylphenyl)imidazolinylidene) complexes were prepared by the action of the parent carbene on [Rh(acac)(CO)₂] in THF. The crystal structure characterisation of [Rh(acac)(CO)(L₁)] revealed a slightly distorted square planar geometry with the carbene ligand orientated almost perpendicular to the equatorial plane; an elongated trans Rh-O bond of 2.0806(18) Å reflecting the considerable trans-influence of the carbene ligand. By measuring the CO stretching frequencies in a range of [Rh(acac)(CO)(L)] complexes (L = CO, L₁, L₂, PPh₃, PⁿBu₃, P(O-2,4-^tBu₂-Ph)₃) the following electron donating ability series was established: L₁ ∼ L₂ ∼ PⁿBu₃ > PPh₃ > P(O-2,4-^tBu₂-Ph)₃ > CO; indicating the carbenes investigated in this study to have a similar electronic cis-influence as trialkyl phosphines. Both complexes do not display hydroformylation activity towards 1-hexene in the absence of added phosphine or phosphite ligands under the conditions investigated (P = 60; T = 85 °C). In the presence of a phosphine or phosphite ligand the resulting hydroformylation catalysis was identical to that observed for [Rh(acac)(CO)₂] and the corresponding ligand and subsequent high-pressure ³¹P NMR studies confirmed substitution of the carbene ligand under these conditions.     

Kinetics and mechanisms of homogeneous catalytic reactions: Part 6. Hydroformylation of 1-hexene by use of Rh(acac)(CO)2/dppe [dppe = 1,2-bis(diphenylphosphino)ethane] as the precatalyst

A kinetic study of the homogeneous hydroformylation of 1-hexene to the corresponding aldehydes (heptanal and 2-methyl-hexanal) was carried out using a rhodium catalyst formed by addition of 1 equiv. of 1,2-bis(diphenylphosphino)ethane (dppe) to Rh(acac)(CO)₂ under mild reaction conditions (80 °C, 1–7 atm H₂ and 1–7 atm CO) in toluene; in all cases linear to branched ratios were close to 2. The reaction rate is first-order in dissolved hydrogen concentration at pressures below 3 atm, but independent of this parameter at higher pressures. In both regimes (low and high H₂ pressure), the initial rate was first-order with respect to the concentration of Rh and fractional order with respect to 1-hexene concentration. Increasing CO pressure had a positive effect on the rate up to a threshold value above which inhibition of the reaction was observed; the range of positive order on CO concentration is smaller when the total pressure is increased. The kinetic data and related coordination chemistry are consistent with a mechanism involving RhH(CO)(dppe) as the active species initiating the cycle, hydrogenolysis of the acyl intermediate as the rate-determining step of the catalytic cycle at low hydrogen pressure, and migratory insertion of the olefin into the metal-hydride bond as rate limiting at high hydrogen pressure. This catalytic cycle is similar to the one commonly accepted for RhH(CO)(PPh₃)₃ but different from previous proposals for Rh-diphosphine catalysts.     

C1桥联的茂金属化合物(Cp)CR1R2(Flu)MCl2的合成及其催化烯烃聚合活性

合成了6种单碳桥联的含芴(Flu)茂(Cp)基B族茂金属催化剂,研究了它们催化烯烃聚合的能力.通过IR,¹HNMR,EI-MS和元素分析对化合物进行了表征.用所合成的茂金属化合物与MAO所组成的催化体系对乙烯、丙烯的聚合进行了研究.其中金属为Ti的催化剂没有聚合活性或活性极低.金属为Zr的催化剂有一定的催化活性,用不同的催化剂得到的聚合物性质有一定的差异.     

氧化物担载铑原子簇催化剂的金属载体相互作用的考察——Ⅰ.Rh/V_2O_5和RH/TiO_2催化剂的金属载体强相互作用的比较

本文用XPS和XRD考察了由Rh_4(CO)_(12)出发制得的Rh/V_2O_5和Rh/TiO_2两种催化剂的金属载体强相互作用的差别。实验结果表明,1)高温H_2还原的Rh/TiO_2催化剂,经氧处理后即能恢复吸H_2能力。Rh/V_2O_5催化剂在较低温度(473K)H_2还原时Rh就进入SMSI状态,吸H_2能力被完全抑制,373K氧处理并不能使之恢复,吸H_2性质表现出不可逆性。2)与Rh/TiO_2催化剂的TiO_2相比,Rt/V_2O_5催化剂的V_2O_5更易还原,Rh对V_2O_5的还原有明显的促进作用。3)担载在TiO_2上的Rh比在V_2O_5上更易还原。4)还原后,催化剂表层的Rh/V、RH/Ti均有较大幅度的降低。用氧空位模型能较好地说明Rh/TiO_2催化剂的实验结果,而Rh/V_2O_5催化剂的实验结果适于用钒氧化物覆盖模型解释。     

烯烃氢甲酰化催化剂活性物种的原位1H NMR研究

The rhodium-phosphine complex catalyst Rh(CO)(acac)(PPh3)(Ⅰ) for 1-hexene hydroformylation was studied under the following reaction conditions: CO/H2=1(mole rate), pressure 1.0 MPa, temperature 25-120℃, by using the pressurized in-situ 1H NMR technique. Experimental results indicated that the formation of a rhodium hydride complex from (Ⅰ) began at room temperature and its amount increased with increasing of reaction temperature. This intermediate complex began to decompose at 100℃ and disapeared completely at 120℃. The intensity change of the proton signal was parallel to catalytical activity in hydroformylation of olefins. Under pure CO pressure the proton signal of Ph-H bond was not observed. There was a 0.2 ppm difference in proton chemical shifts of Rh-H bond under pure H2 pressure and under H2+CO pressure. The results showed that the rhodium-hydride carbonyl complex is the active intermediate in the industrial hydroformylation process.     

负载型水相催化剂的制备及其在丙烯氢甲酰化中的应用

以ＳｉＯ２为载体,制备了负载型水相铑膦催化剂。在反应温度为１００－１１０℃,合成气ＣＯ：Ｈ２＝１：１,反应压力２．０ＭＰａ,「Ｒｈ」＝７．５×１０＾５,Ｐ／Ｒｈ＝２５的条件下,进行丙烯氢甲酰化反应。结果表明,时空收率可达１９４－２２８ｇ丁醛,正异比高达约１４．２,反应结束后催化剂与体系易分离,铑在有机相中的浓度仅为１×１０＾－９－４×１０＾－９,基本消除了铑的流失,克服了均相反应中催化剂铑的回收和     

铑钴四核簇合物的合成表征及其对苯乙烯的氢甲酰化反应性能的研究

研究表明，含有铑原子的异多核过渡金属羰基簇合物在一些催化反应中具有好的催化活性；有机膦是比羰基配位能力更强的一类配体，与簇合物中的金属配位后可使簇合物更趋稳定．过渡金属羰基簇合物骨架在催化反应过程中是否能够保持完整性一直是簇合物催化研究领域中的问题之一．为此，我们合成了标题簇合物2(n=1)和3(n=2)，     

Coordination chemistry of ester-functionalized cp ligands: synthesis and catalytic activity of [Rh{CpCO2(CHPh)2OH}(NBD)] and [Rh{CpCO2(CH2)3OH}(NBD)]

Two new sodium hydroxyalkoxycarbonylcyclopentadienide salts Na[rac-CpCO₂(CHPh)₂OH] (1) and Na[(2S,3S)-CpCO₂(CHPh)₂OH] (2) were prepared by reaction of NaCp with the five-membered cyclic carbonates cis-4,5-diphenyl-1,3-dioxolan-2-one and (4S,5S)-4,5-diphenyl-1,3-dioxolan-2-one. The reaction of these salts with [Rh(NBD)Cl]₂ gave [Rh{rac-CpCO₂(CHPh)₂OH}(NBD)] (3) and (−)-[Rh{(2S,3S)-CpCO₂(CHPh)₂OH}(NBD)] (4) whose catalytic activity in the hydroformylation of hex-1-ene and styrene has been investigated and compared with that of the previously reported rhodium complexes [Rh{CpCO₂(CHR)₂OH}(NBD)] (R=H, Me). In addition we also discuss some preliminary results regarding the behavior of these complexes in the hydrogenation of the same substrates. The reactivity of NaCp toward the six-membered cyclic carbonate 1,3-dioxan-2-one has also been studied and it has been found that the reaction leads to two cyclopentadienide anions [CpCO₂(CH₂)₃OH]⁻ (5) and [CpCO₂(CH₂)₃OC(O)O(CH₂)₃OH]⁻ (6) in amounts strictly dependent on the carbonate/NaCp stoichiometric ratio.     

Kinetics and mechanisms of homogeneous catalytic reactions: Part 7. Hydroformylation of 1-hexene catalyzed by cationic complexes of rhodium and iridium containing PPh3

Cationic rhodium and iridium complexes of the type [M(COD)(PPh₃)₂]PF₆ (M = Rh, 1a; Ir, 1b) are efficient precatalysts for the hydroformylation of 1-hexene to its corresponding aldehydes (heptanal and 2-methylhexanal), under mild pressures (2–5 bar) and temperatures (60 °C for Rh and 100 °C for Ir) in toluene solution; the linear to branched ratio (l/b) of the aldehydes in the hydroformylation reaction varies slightly (between 3.0 and 3.7 for Rh and close to 2 for Ir). Kinetic and mechanistic studies have been carried out using these cationic complexes as catalyst precursors. For both complexes, the reaction proceeds according to the rate law r_i = K₁K₂K₃k₄[M][olef][H₂][CO]/([CO]² + K₁[H₂][CO] + K₁K₂K₃[olef][H₂]). Both complexes react rapidly with CO to produce the corresponding tricarbonyl species [M(CO)₃(PPh₃)₂]PF₆, M = Rh, 2a; Ir, 2b, and with syn-gas to yield [MH₂(CO)₂(PPh₃)₂]PF₆, M = Rh, 3a; Ir, 3b, which originate by CO dissociation the species [MH₂(CO)(PPh₃)₂]PF₆ entering the corresponding catalytic cycle. All the experimental data are consistent with a general mechanism in which the transfer of the hydride to a coordinated olefin promoted by an entering CO molecule is the rate-determining step of the catalytic cycle.     

庚烯羰化制醇的原位红外光谱表征

庚烯羰化制醇的原位红外光谱表征１）焦凤英胡庆云陈艳晶（济南大学实验中心济南２５０００２）牛建中殷元骐（中国科学院兰州化学物理研究所羰基合成与选择氧化国家重点实验室兰州７３００００关键词庚烯均相催化氢甲酰化原位红外光谱铑膦催化剂铑催化剂（以较强碱性的三...     

锚链固定的多相化铑膦配合物氢甲酰化反应催化剂的制备及其催化性能

以溶胶-凝胶与锚链固定相结合的方法制备了新型多相化羰基铑膦配合物催化剂.利用FT-IR,XPS和ICP对催化剂进行了表征.考察了该催化剂对1-己烯氢甲酰化反应的催化性能,得到较佳的反应条件,即反应温度100℃、反应时间12h、催化剂用量为0.3382g(相当于金属铑含量为4.4×10-5mol)、反应压力5.0MPa.此时1-己烯的转化率为98.5%、醛的选择性92.4%、n/i比1.43.该催化剂循环使用7次仍具有较高的催化活性和选择性,表明该催化剂具有好的循环使用性能.XPS、ICP分析证明铑的部分流失主要是由于氢甲酰化反条件下CO取代膦配体所致.     

四膦配体的合成及其金属配合物催化烯烃氢甲酰化反应研究

合成了四膦配体Ｃ（ＣＨ２ＰＰｈ２）４，并研究了由钴－四膦配体组成的催化剂体系对烯烃氢甲酰化反应的催化作用．对反应的各种因素，如反应温度、反应压力、不同Ｐ／Ｃｏ比，不同烯烃等的影响作了探讨，并与不同膦配体体系催化烯烃氢甲酰化作对比，发现膦配体催化活性有如下顺序：Ｃ（ＣＨ２ＰＰｈ２）４≈Ｐｈ２Ｐ（ＣＨ２）２ＰＰｈ２＞Ｐｈ２Ｐ（ＣＨ２）３ＰＰｈ２＞Ｐｈ２ＰＣＨ２ＰＰｈ２＞Ｐｈ２Ｐ（ＣＨ２）４ＰＰｈ２．     

Hydroformylation of oct-1-ene catalyzed by dinuclear gem-dithiolato-bridged rhodium(I) complexes and phosphorus donor ligands

The dinuclear gem-dithiolato bridged compounds [Rh₂(μ-S₂Cptn)(cod)₂] (1) (CptnS₂²⁻ = 1,1-cyclopentanedithiolato), [Rh₂(μ-S₂Chxn)(cod)₂] (2) (ChxnS₂²⁻ = 1,1-cyclohexanedithiolato), [Rh₂(μ-S₂CBn₂)(cod)₂] (3) (Bn₂CS₂²⁻ = 1,3-diphenyl-2,2-dithiolatopropane) and [Rh₂(μ-S₂CⁱPr₂)(cod)₂] (4) (ⁱPr₂CS₂²⁻ = 2,4-dimethyl-2,2-dithiolatopentane) dissolved in toluene in the presence of monodentate phosphine or phosphite P-donor ligands under carbon monoxide/hydrogen (1:1) atmosphere are efficient catalysts for the hydroformylation of oct-1-ene under mild conditions (6.8 atm of CO/H₂ and 80 °C). The influence of the gem-dithiolato ligand, the P-donor co-catalyst and the P/Rh ratio on the catalytic activity and selectivity has been explored. Aldehyde selectivities higher than 95% and turnover frequencies up to 245 h⁻¹ have been obtained using P(OMe)₃ as modifying ligand. Similar activity figures have been obtained using P(OPh)₃ although the selectivities are lower. Regioselectivities toward linear aldehyde are in the range 75–85%. The performance of the catalytic systems [Rh₂(μ-S₂CR₂)(CO)₂(PPh₃)₂]/PPh₃ has been found to be comparable to the systems [Rh₂(μ-S₂CR₂)(cod)₂] at the same P/Rh ratio. The system [Rh₂(μ-S₂CBn₂)(cod)₂] (3)/P(OPh)₃ has been tested in the hydroformylation-isomerization of trans-oct-2-ene. Under optimized conditions up to 54% nonanal was obtained. Spectroscopic studies under pressure (HPNMR and HPIR) evidenced the formation of hydrido mononuclear species under catalytic conditions that are most probably responsible for the observed catalytic activity.