ELDRS and dose-rate dependence of vertical NPN transistor

The enhanced low-dose-rate sensitivity (ELDRS) and dose-rate dependence of vertical NPN transistors are investigated in this article. The results show that the vertical NPN transistors exhibit more degradation at low dose rate, and that this degradation is attributed to the increase on base current. The oxide trapped positive charge near the SiO₂-Si interface and interface traps at the interface can contribute to the increase on base current and the two-stage hydrogen mechanism associated with space charge effect can well explain the experimental results.     

基于1/f噪声的NPN晶体管辐照感生电荷的定量分离

本文针对NPN双极性晶体管, 在研究辐照感生的氧化层电荷及界面态对晶体管基极电流和1/f噪声的影响的基础上, 建立辐照感生氧化层电荷及界面态与基极电流和1/f噪声的定量物理模型. 根据所建立的模型, 提出一种新的分离方法, 利用1/f噪声和表面电流求出氧化层电荷密度, 利用所求得氧化层电荷密度和表面电流求出界面态密度. 利用本方法初步实现了辐照感生氧化层电荷及界面态的定量计算.     

Effects of orientation of substrate on the enhanced low-dose-rate sensitivity (ELDRS) in NPN transistors

The radiation effects and annealing characteristics of two types of domestic NPN bipolar junction transistors, fabricated with different orientations, were investigated under different dose-rate irradiation. The experimental results show that both types of the NPN transistors exhibit remarkable Enhanced Low-Dose-Rate Sensitivity (ELDRS). After irradiation at high or low dose rate, the excess base current of NPN transistors obviously increased, and the current gain would degrade rapidly. Moreover, the decrease of collector current was also observed. The NPN transistor with (111) orientation was more sensitive to ionizing radiation than that with (100) orientation. The underlying mechanisms of various experimental phenomena are discussed in detail in this paper.     

Effects of orientation of substrate on the enhanced low-dose-rate sensitivity （ELDRS） in NPN transistors

The radiation effects and annealing characteristics of two types of domestic NPN bipolar junction transistors, fabricated with different orientations, were investigated under different dose-rate irradiation. The experimental results show that both types of the NPN transistors exhibit remarkable Enhanced Low-Dose-Rate Sensitivity (ELDRS). After irradiation at high or low dose rate, the excess base current of NPN transistors obviously increased, and the current gain would degrade rapidly. Moreover, the decrease of collector current was also observed. The NPN transistor with <111> orientation was more sensitive to ionizing radiation than that with <100> orientation. The underlying mechanisms of various experimental phenomena are discussed in detail in this paper.     

Comparison of effect of 5 MeV proton and Co-60 gamma irradiation on silicon NPN rf power transistors and N–channel depletion MOSFETs

NPN transistors and N-channel depletion metal oxide semiconductor field effect transistors (MOSFETs) were irradiated with 5?MeV protons and ⁶⁰Co gamma radiation in the dose ranging from 1?Mrad(Si) to 100?Mrad(Si). The different electrical characteristics of the NPN transistor such as Gummel characteristics, excess base current (ΔI_B), dc current gain (h_FE), transconductance (g_m), displacement damage factor (K) and output characteristics were studied as a function of total dose. The different electrical characteristics of N-channel MOSFETs such as threshold voltage (V_th), density of interface trapped charges (ΔN_it), density of oxide trapped charges (ΔN_ot), transconductance (g_m), mobility (µ) and drain saturation current (I_DSat) were studied systematically before and after irradiation in the same dose ranges. A considerable increase in the base current (I_B) and decrease in the h_FE, g_m and collector saturation current (I_CSat) were observed after irradiation in the case of the NPN transistor. In the N-channel MOSFETs, the ΔN_it and ΔN_ot were found to increase and V_th, g_m, µ and I_DSat were found to decrease with increase in the radiation dose. The 5?MeV proton irradiation results of both the NPN transistor and N-channel MOSFETs were compared with ⁶⁰Co gamma-irradiated devices in the same dose ranges. It was observed that the degradation in 5?MeV proton-irradiated devices is more when compared with the ⁶⁰Co gamma-irradiated devices at higher total doses.     

Si_3N_4钝化层对横向PNP双极晶体管电离辐射损伤的影响机理

航天器中电子器件在轨服役期间,会遭受到空间带电粒子及各种射线的辐射环境的显著影响,易于造成电离辐射损伤.本文采用60Coγ射线辐照源,针对有/无Si_3N_4钝化层结构的横向PNP型(LPNP)双极晶体管,开展了电离辐射损伤效应及机理研究.利用KEITHLEY 4200-SCS半导体参数测试仪测试了LPNP晶体管电性能参数(包括Gummel特性曲线和电流增益等).采用深能级瞬态谱分析仪(DLTS),对辐照前后有/无Si_3N_4钝化层结构的LPNP晶体管的电离缺陷进行测试.研究结果表明,在相同吸收剂量条件下,与无Si_3N_4钝化层的晶体管相比,具有Si_3N_4钝化层的LPNP晶体管基极电流退化程度大,并且随吸收剂量的增加,电流增益退化更为显著.通过DLTS分析表明,与无Si_3N_4钝化层的晶体管相比,有Si_3N_4钝化层的晶体管辐射诱导的界面态能级位置更接近于禁带中心.这是由于制备Si_3N_4钝化层时引入了大量的氢所导致,而氢的存在会促使辐射诱导的界面态能级位置更接近于禁带中心,复合率增大,从而加剧了晶体管性能的退化.     

Radiation-induced 1/f noise degradation of PNP bipolar junction transistors at different dose rates

It is found that ionizing-radiation can lead to the base current and the 1/f noise degradations in PNP bipolar junction transistors. In this paper, it is suggested that the surface of the space charge region of the emitter-base junction is the main source of the base surface 1/f noise. A model is developed which identifies the parameters and describes their interactive contributions to the recombination current at the surface of the space charge region. Based on the theory of carrier number fluctuation and the model of surface recombination current, a 1/f noise model is developed. This model suggests that 1/f noise degradations are the result of the accumulation of oxide-trapped charges and interface states. Combining models of ELDRS, this model can explain the reason why the 1/f noise degradation is more severe at a low dose rate than at a high dose rate. The radiations were performed in a Co~(60) source up to a total dose of 700 Gy(Si). The low dose rate was 0.001 Gy(Si)/s and the high dose rate was 0.1 Gy(Si)/s. The model accords well with the experimental results.     

Degradation mechanisms of current gain in NPN transistors

An investigation of ionization and displacement damage in silicon NPN bipolar junction transistors (BJTs) is presented. The transistors were irradiated separately with 90-keV electrons, 3-MeV protons and 40-MeV Br ions. Key parameters were measured {\em in-situ} and the change in current gain of the NPN BJTS was obtained at a fixed collector current (I_{\rm c}=1~mA). To characterise the radiation damage of NPN BJTs, the ionizing dose D_{\i} and displacement dose D_{\d} as functions of chip depth in the NPN BJTs were calculated using the SRIM and Geant4 code for protons, electrons and Br ions, respectively. Based on the discussion of the radiation damage equation for current gain, it is clear that the current gain degradation of the NPN BJTs is sensitive to both ionization and displacement damage. The degradation mechanism of the current gain is related to the ratio of D_{\rm d}/(D_{\rm d}+D_{\rm i}) in the sensitive region given by charged particles. The irradiation particles leading to lower D_{\rm d}/(D_{\rm d}+D_{\rm i}) within the same chip depth at a given total dose would mainly produce ionization damage to the NPN BJTs. On the other hand, the charged particles causing larger D_{\rm d}/(D_{\rm d}+D_{\rm i}) at a given total dose would tend to generate displacement damage to the NPN BJTs. The Messenger--Spratt equation could be used to describe the experimental data for the latter case.     

Analysis of displacement damage effects on bipolar transistors irradiated by spallation neutrons

Displacement damage induced by neutron irradiation in China Spallation Neutron Source(CSNS) is studied on bipolar transistors with lateral PNP, substrate PNP, and vertical NPN configurations, respectively. Comparison of the effects on different type transistors is conducted based on displacement damage factor, and the differences are analyzed through minority carrier lifetime calculation and structure analysis. The influence of CSNS neutrons irradiation on the lateral PNP transistors is analyzed by the gate-controlled method, including the oxide charge accumulation, surface recombine velocity,and minority carrier lifetime. The results indicate that the total ionizing dose in CSNS neutron radiation environment is negligible in this study. The displacement damage factors based on 1-MeV equivalent neutron flux of different transistors are consistent between Xi'an pulse reactor(XAPR) and CSNS.     

Design and investigation of novel ultra-high-voltage junction field-effect transistor embedded with NPN

Ultra-high-voltage(UHV) junction field-effect transistors(JFETs) embedded separately with the lateral NPN(JFETLNPN), and the lateral and vertical NPN(JFET-LVNPN), are demonstrated experimentally for improving the electrostatic discharge(ESD) robustness. The ESD characteristics show that both JFET-LNPN and JFET-LVNPN can pass the 5.5-k V human body model(HBM) test. The JFETs embedded with different NPNs have 3.75 times stronger in ESD robustness than the conventional JFET. The failure analysis of the devices is performed with scanning electron microscopy, and the obtained delayer images illustrate that the JFETs embedded with NPN transistors have good voltage endurance capabilities. Finally,the internal physical mechanism of the JFETs embedded with different NPNs is investigated with emission microscopy and Sentaurus simulation, and the results confirm that the JFET-LVNPN has stronger ESD robustness than the JFET-LNPN,because the vertical NPN has a better electron collecting capacity. The JFET-LVNPN is helpful in providing a strong ESD protection and functions for a power device.     

Comparison of 1 MeV electron,Co-60 gamma and 1 MeV proton irradiation effects on silicon NPN transistors

The total dose effects of 1?MeV electrons on the dc electrical characteristics of silicon NPN transistors are investigated in the dose range from 100?krad to 100?Mrad. The different electrical characteristics such as Gummel characteristics, excess base current (ΔI_B), dc current gain (h_FE), transconductance (g_m), displacement damage factor (K) and output characteristics were studied in situ as a function of total dose. A considerable increase in base current (I_B) and a decrease in h_FE, g_m and I_CSat was observed after 1?MeV electron irradiation. The collector–base (C–B) junction capacitance of transistors was measured to estimate the change in the effective carrier concentration. After 1?MeV electron irradiation, a considerable degradation in capacitance was observed. The plot of (1/C²) versus voltage shows that the effective carrier concentration and built-in voltage (V_bi) increase marginally upon 1?MeV electron irradiation. The results of 1?MeV electron irradiation were compared with 1?MeV proton and Co-60 gamma irradiation results in the same dose range. The degradation for 1?MeV electron and Co-60 gamma-irradiated transistors was significantly less when compared to 1?MeV proton-irradiated transistor. The 1?MeV proton, 1?MeV electron and Co-60 gamma-irradiated transistors were subjected to isochronal annealing to analyze the recovery of the electrical parameters.     

60Co γ-ray induced gain degradation in bipolar junction transistors

Commercial indigenously made npn and pnp bipolar junction switching transistors used for space applications are investigated for ⁶⁰Co γ-ray induced effects. The on-line as well as off-line measurements indicate that the forward current gain of the transistors decreases significantly as the accumulated dose increases. Excess base current model is employed to account for the current gain degradation. The pnp transistor undergoes as much degradation as the npn type. It is found that bulk degradation by displacement damage is the dominant mechanism leading to reduction in forward current gain of npn transistors. On the other hand it appears that, in addition to bulk damage, surface degradation due to accumulation of interface states at the silicon-silicon dioxide interface also contributes significantly to gain degradation in pnp transistor as evident from thermal annealing studies. Further, estimation reveals that the transistor with larger base width has higher displacement damage factor.     

半导体器件总剂量辐射效应的热力学影响

对商用三极管和MOS场效应晶体管进行了不同环境温度下的总剂量辐照实验,对比了不同辐照温度对这两种器件辐射效应特性的影响。实验结果表明,对于同一辐照总剂量,三极管的基极电流、电流增益和MOS场效应晶体管的阈值电压漂移值都随着辐照温度的不同而存在较大的差异。总剂量为100 krad,辐照温度分别为25,70,100 ℃时,NPN三极管的电流增益倍数分别衰减了71,89和113,而NMOS晶体管的阈值电压V_T分别减少了3.53,2.8,2.82 V。     

Evaluation of channel hot carrier effects in n-MOS transistors at 77 K with the charge pumping technique

With the charge pumping technique, the role of hot holes in the channel hot carrier degradation of short channel n-MOS transistors is shown to be less pronounced at 77 K than at 300 K. Also fewer fast interface states are generated at 77 K for the same substrate current level in the low gate bias regime. Furthermore, the dominant device degradation is found to be in the high gate bias regime at 77 K, in contrast to the case of 300 K. This is due to the presence of negative charge in the oxide or in acceptor-type interface states.     

偏置条件对NPN及PNP双极晶体管电离辐射损伤的影响研究

本文采用低能电子辐照源对NPN及PNP晶体管进行辐照试验. 在辐照试验过程中, 针对NPN及PNP晶体管发射结施加不同的偏置条件, 研究偏置条件对NPN及PNP晶体管辐射损伤的影响. 使用Keithley 4200-SCS半导体特性测试仪在原位条件下测试了双极晶体管电性能参数随低能电子辐照注量的变化关系. 测试结果表明, 在相同的辐照注量条件下, 发射结反向偏置时双极晶体管的辐照损伤程度最大; 发射结正向偏置时双极晶体管的辐照损伤程度最小; 发射结零偏时双极晶体管的辐照损伤程度居于上述情况之间. 关键词： 双极晶体管 低能电子 电离辐射     

超深亚微米器件总剂量辐射效应三维数值模拟

本文分析了浅槽隔离(STI)结构辐射诱导电荷的分布情况,给出一种模拟超深亚微米器件总剂量辐射效应的新方法.研究结果表明,如果在栅附近沿着STI侧墙不加辐照缺陷,仿真出的0.18 μm超深亚微米晶体管亚阈区I-V特性没有反常的隆起,并且能够很好地反映试验结果.在研究总剂量辐照特性改善方面,在剂量不是很大的情况下,采用超陡倒掺杂相对于均匀掺杂能有效地减小辐照所引起的泄漏电流.如果采用峰值(Halo)掺杂,不仅有利于提高超深亚微米器件的抗辐照能力,而且在大剂量的情况下,可以得到明显的效果. 关键词： 总剂量 超陡倒掺杂 Halo掺杂 辐射效应     

不同顺序中子/γ辐照对双极器件电流增益的影响

利用CFBR-Ⅱ快中子反应堆(中国第二座快中子脉冲堆)和60Co装置开展不同顺序的中子/γ辐照双极晶体管的实验。在集电极-发射极电压恒定条件下,测量了双极晶体管电流增益随集电极电流的变化曲线,研究不同顺序中子/γ辐照对双极晶体管电流增益的影响。分析实验结果发现,集电极-发射极电压一定时,集电极电流极低情况下电流增益退化比较大,随集电极电流增加电流增益逐渐减小;就实验选中的两类晶体管而言,先中子后γ辐照造成双极晶体管电流增益的退化程度大于先γ后中子辐照,而且PNP型晶体管比NPN型晶体管差异更明显。本文进行了双极晶体管电离/位移协同辐照效应相关机理的初步探讨。     

The effects of high-energy ion irradiations on the I–V characteristics of silicon NPN transistors

The silicon NPN rf power transistors were irradiated with different linear energy transfer (LET) ions such as 50?MeV Li³⁺, 80?MeV C⁶⁺ and 150?MeV Ag¹²⁺ ions in the dose range of 1–100?Mrad. The SRIM simulation was used to understand the energy loss and range of these ions in the transistor structure. The different electrical parameters such as Gummel characteristics, excess base current (ΔI_B), DC current gain (h_FE), displacement damage factor (K) and output characteristics were systematically studied before and after irradiation. The ion irradiation results were compared with ⁶⁰Co-gamma irradiation result in the same dose range. A considerable increase in base current (I_B) and a decrease in h_FE and I_CSat were observed after irradiation. The degradation in the electrical parameters was comparably very high for Ag¹²⁺ ion-irradiated transistor when compared to other ion-irradiated transistors, whereas the degradation in the electrical parameters for Li³⁺ and C⁶⁺ ion-irradiated transistors was comparable with gamma-irradiated transistor. The isochronal annealing study was conducted on the 100?Mrad irradiated transistors up to 500°C to analyze the recovery in different electrical parameters. The h_FE and other electrical parameters of irradiated transistors were almost recovered after 500°C for 50?MeV Li³⁺, 80?MeV C⁶⁺ ion and ⁶⁰Co-gamma-irradiated transistors, whereas for 150?MeV Ag¹²⁺ ion-irradiated transistor, the recovery in electrical characteristics is not complete.     

Research on total-dose hardening for H-gate PD NMOSFET/SIMOX by ion implanting into buried oxide

In this work,we investigate the back-gate I-V characteristics for two kinds of NMOSFET/SIMOX transistors with H gate structure fabricated on two different SOI wafers.A transistors are made on the wafer implanted with Si+ and then annealed in N2,and B transistors are made on the wafer without implantation and annealing.It is demonstrated experimentally that A transistors have much less back-gate threshold voltage shift AVth than B transistors under X-ray total dose irradiation.Subthreshold charge separation technique is employed to estimate the build-up of oxide charge and interface traps during irradiation,showing that the reduced △Vth for A transistors is mainly due to its less build-up of oxide charge than B transistors.Photoluminescence (PL) research indicates that Si implantation results in the formation of silicon nanocrystalline (nanocluster) whose size increases with the implant dose.This structure can trap electrons to compensate the positive charge build-up in the buried oxide during irradiation,and thus reduce the threshold voltage negative shift.