损伤演化对韧性金属碎裂过程的影响

固体在冲击拉伸载荷作用下会断裂成多个碎片,基于线性内聚力断裂假设的Mott-Grady模型能较好地预测碎裂过程所产生的平均碎片尺度的下限。然而实际上,韧性金属的损伤演化是多元化的,为此通过数值模拟方法研究了不同损伤演化规律对韧性碎裂过程的影响。利用ABAQUS/Explicit动态有限元软件数值再现了韧性金属杆（45钢）在高应变率下拉伸碎裂的过程,分析了线性和非线性损伤演化对韧性碎裂过程的影响规律。结果表明：损伤演化规律对韧性金属的碎裂过程具有显著影响,非线性指标α越大,碎裂过程产生的碎片数越少;Grady-Kipp碎裂公式仍能在一定范围内预测韧性碎裂过程中产生的碎片尺寸;当非线性指标α远大于零时,在较低冲击拉伸载荷作用下,数值模拟结果和Grady-Kipp模型预测值偏差较大,随着应变率增大,数值模拟结果与Grady-Kipp模型预测值吻合较好。

     

大长细比弹体斜侵彻混凝土靶的动力学响应

基于刚塑性自由梁在横向冲击载荷下的动力学响应研究方法,结合空腔膨胀理论给出的弹体载荷分析,给出了弹体作为自由梁在塑性铰出现之前的响应行为,得到了梁内任一截面在横向载荷下剪力和弯矩分布规律以及轴向载荷下的轴力分布规律。计算结果表明,大长细比结构弹体的危险截面在承受较大轴向惯性压力载荷后,对由非正侵彻导致的横向载荷极为敏感。最后基于压弯联合作用载荷分析,给出了动能弹设计的抗弯极限壁厚要求。     

球体入水空泡演变和运动特性影响试验研究

为了探究表面粗糙度对球体入水空泡演变及运动特性的影响,基于实验室开放水槽试验系统,选取了5种表面粗糙度的球体,使用高速摄像机记录入水过程,并得到了各个球体的入水空泡、喷溅的演变过程以及运动特性的变化。发现入水空泡和喷溅的闭合都会给球体一个负方向的加速度。通过对比不同表面粗糙度球体的位移、速度、加速度曲线,发现表面粗糙度最大的球体在砰击阶段结束后,其速度会明显小于其他球体,并且表面粗糙度对球体运动的影响主要体现在入水早期。分析了上述各球体的入水空泡闭合后,与自由面相连的空泡的收缩运动,发现其收缩速度和加速度曲线均会出现极大值点,呈现出球体表面粗糙度越大出现得越早的趋势。

     

强动载作用下孔洞汇合对延性金属层裂损伤演化过程的影响

针对强动载作用下延性金属的层裂问题,在分析孔洞之间几何关联的基础上,定义了一个新的耦合损伤及孔洞几何信息的孔洞汇合判定方法,同时,基于能量守恒原理,解析了孔洞汇合对损伤快速增长影响的物理机理.通过分析数值计算结果和对比相关文献的实验可知:孔洞汇合后不仅引起损伤增长,而且导致了损伤材料内部微孔洞数目的减少、孔洞平均尺寸的增加。     

冲击回波法对混凝土内部损伤检测的试验研究

通过预加荷载给混凝土试件内部引入一定程度的损伤,分别测量了损伤前后试件内部弹性波的传播速度以及抗压强度,探讨了弹性波波速的降低程度与抗压强度劣化之间的关系。研究表明:在MEM卓越周期图中,主要峰值数量增加和底部边界面反射信号周期加长可作为判别损伤产生的依据;弹性波波速与混凝土内部的损伤程度具有很好的相关性,混凝土损伤程度越大,波速降低值越大;弹性波波速降低程度与抗压强度劣化之间具有线性相关性。根据试验数据拟合出了线性方程。说明采用冲击回波法对混凝土内部损伤程度检测是可行的,在混凝土结构的可靠性与安全性分析方面具有广阔的应用前景。     

Experimental and theoretical study on numerical density evolution of short fatigue cracks

Fatigue testing was performed using a kind of triangular shaped specimen to obtain the characteristics of numerical density evolution for short cracks at the primary stage of fatigue damage. The material concerned is a structural alloy steel. The experimental results show that the numerical density of short cracks reaches the maximum value when crack length is slightly less than the average grain diameter, indicating grain boundary is the main barrier for short crack extension. Based on the experimental observations and related theory, the expressions for growth velocity and nucleation rate of short cracks have been proposed. With the solution to phase space conservation equation, the theoretical results of numerical density evolution for short cracks were obtained, which were in agreement with our experimental measurements. The project supported by the National Natural Science Foundation of China and the Chinese Academy of Sciences.     

ANALYSIS MODEL ON GRADUAL CHANGE PRINCIPLE OF EFFECT ZONES OF LAYER FACE FOR ROLLED CONTROL CONCRETE DAM

The effect zones of layer face for RCC (rolled control concrete) dam have gradual change characteristics. Based on the analysis thought of complex material, a model was built to analyze above principle of RCC dam by use of series-wound and shunt-wound connection. Some methods were proposed to determine the instantaneous Young's modulus, delayed Young's modulus and viscosity coefficient of effect zones of layer face. Above models and methods were used to mine the principle of gradual change of key calculation parameters which can response the characteristics of effect zones. The principle of gradual change was described. A model was established to analyze the three-dimensional viscoelastic problem of RCC dam. Above programs were developed. The examples show that the proposed models and methods to determine the key calculation parameters of effect zones can reflect the status of RCC dam accurately.     

不同循环加载应力下花岗岩Kaiser效应特征的试验研究

为了更准确地获取花岗岩的Kaiser效应点对应的应力值σAE,利用RMT-100B岩石力学伺服试验机和Micro-Ⅱ Express型声发射监测系统,研究不同循环加载应力σci下岩石Kaiser效应特征.结果表明:相比单次加载,在循环加载作用下,试样的应力-应变曲线在加载初期下凸减弱,压密阶段变短;由于试样的加卸载曲线...     

Vibration effect on convection onset in a system consisting of a horizontal pure liquid layer and a layer of liquid-saturated porous medium

The onset of convection in a system of two horizontal layers (a pure liquid and a porous medium saturated with the same liquid) heated from below under the action of vertical vibration is investigated. For describing the free thermal convection, in the liquid layer the Boussinesq approximation and in the porous layer the Darcy-Boussinesq approximation are used. In the limiting case of a thin liquid layer, effective boundary conditions on the upper boundary of the porous layer with account for convection in the liquid layer are obtained and it is shown that vibration has a stabilizing effect, whereas the presence of a liquid layer leads to destabilization. For an arbitrary liquid to porous layer thickness ratio the onset of convection is investigated numerically. In the case of a thin liquid layer there are two (short-and long-wave) unstable modes. In the case of thick layers the neutral curves are unimodal. Vibration has a stabilizing effect on perturbations with any wave number but affects short-wave perturbations much more strongly than long-wave ones.     

近爆荷载作用下装配式钢筋混凝土柱抗爆性能及受损加固试验研究

为研究近爆荷载作用下装配式钢筋混凝土（precast concrete,PC）柱的抗爆性能与受损后的加固修复性能,开展了足尺PC柱化爆试验与受损柱加固修复轴压试验研究。共开展了3次化爆试验,获得了PC柱的动力响应与损伤破坏试验数据,分析了PC柱与现浇钢筋混凝土（reinforced concrete, RC）柱试验结果的差异。近爆荷载作用下,PC柱呈现出局部损伤破坏模式,爆心附近混凝土剥落,出现斜裂缝,装配位置的交界面出现贯穿裂缝,锚浆搭接PC柱比灌浆套筒PC柱的损伤更加严重。两种装配形式的PC柱整体上具有与RC柱相近的抗爆性能,但装配界面削弱了PC柱的整体性与抗剪切能力,是PC柱典型的薄弱位置。轴压试验结果表明,分别采用置换混凝土和置换后外包碳纤维增强复合材料(carbon fiber reinforcement polymer, CFRP)布的方式加固受损的两根PC柱,其轴向承载力均超过了同规格未受损柱的试验承载力和设计承载力。

     

Analysis of radiometer effect on proof mass in purely gravitational orbit

Spacecrafts with the pure gravity environment are of great significance in precision navigation,gravity field measurement for celestial bodies,and basic physics experiments.The radiometer effect is one of the important interfering factors on the proof mass in a purely gravitational orbit.For the gravity field measurement system based on the inner-formation flying,the relationship between the radiometer effect on the innersatellite and the system parameters is studied by analytical and numerical methods.An approximate function of the radiometer effect suitable for the engineering computation and the correction factor are obtained.The analytic results show that the radiometer effect on the inner-satellite is proportional to the average pressure while inversely proportional to the average temperature in the outer-satellite cavity.The radiometer effect increases with the temperature difference in the cavity,and its minimum exists when the cavity radius increases.When the minimum of the radiometer effect arrives,the ratio of the cavity radius to the inner-satellite radius is 1.189 4.This constant is determined by the spherical cavity configuration and independent of the temperature and pressure distributions.When the ratio of the cavity radius to the inner-satellite radius is more than 10,it is believed that the cavity is large enough,the radiometer effect is approximately proportional to the square of the inner-satellite radius,and the influence of the outer-satellite cavity radius on the radiometer effect can be ignored.     

Numerical study of Prandtl effect on MHD flow at a lid‐driven porous cavity

In this paper, the lattice Boltzmann method is used to study the Prandtl number effect on flow structure and heat transfer rates in a magnetohydrodynamic flow mixed convection in a lid‐driven cavity filled with a porous medium. The right and left walls are at constant but different temperatures (θ_h and θ_c), while the other walls are adiabatic. Gallium and salt water (0.02 < Pr < 13.4) are used as samples of the electroconducting fluids in the cavity. Typical sets of streamlines and isotherms are presented to analyze the flow patterns set up by the competition among the forced flow created by the lid‐driven wall, the buoyancy force of the fluid and the magnetic force of the applied magnetic field. Mathematical formulations in the porous media were constructed based on the Brinkman–Forchheimer model, while the multidistribution‐function model was used for the magnetic field effect. Numerical results were obtained and the effects of the Prandtl number and the other effective parameters such as Richardson, Hartman, and Darcy numbers were investigated. It was found that the fluid fluctuations within the cavity were reduced by increasing the Hartman number. A similar pattern was observed for the Darcy number reduction. Heat transfer was essentially dominated by the conduction for the low Prandtl number and forced convection dominated as the Prandtl number increased. Also, the average Nusselt number was raised by increasing the Prandtl number. It was discovered that a remarkable heat transfer enhancement of up to 28% could be reached by increasing the Prandtl number (from 0.02 to 13.4) at constant Richardson and Darcy numbers. Copyright © 2011 John Wiley & Sons, Ltd.     

Experimental study and direct numerical simulation of the evolution of disturbances in a viscous shock layer on a flat plate

The evolution of disturbances in a hypersonic viscous shock layer on a flat plate excited by slow-mode acoustic waves is considered numerically and experimentally. The parameters measured in the experiments performed with a free-stream Mach number M _∞ = 21 and Reynolds number Re _L = 1.44 · 10⁵ are the transverse profiles of the mean density and Mach number, the spectra of density fluctuations, and growth rates of natural disturbances. Direct numerical simulation of propagation of disturbances is performed by solving the Navier-Stokes equations with a high-order shock-capturing scheme. The numerical and experimental data characterizing the mean flow field, intensity of density fluctuations, and their growth rates are found to be in good agreement. Possible mechanisms of disturbance generation and evolution in the shock layer at hypersonic velocities are discussed. __________ Translated from Prikladnaya Mekhanika i Tekhnicheskaya Fizika, Vol. 47, No. 5, pp. 3–15, September–October, 2006.     

A study of the effect of step excrescences and free‐stream disturbances on boundary layer stability

In this work, a study of the mechanism by which free‐stream acoustic and vorticity disturbances interact with a boundary layer flow developing over a flat plate featuring a step excrescence located at a certain distance from a blunt leading edge is included. The numerical tool is a high‐fidelity implicit numerical algorithm solving for the unsteady, compressible form of the Navier–Stokes equations in a body‐fitted curvilinear coordinates and employing high‐accurate compact differencing schemes with Pade‐type filters. Acoustic and vorticity waves are generated using a source term in the momentum and energy equations, as opposed to using inflow boundary conditions, to avoid spurious waves that may propagate from boundaries. The results show that the receptivity to surface step excrescences is largely the result of an overall adverse pressure gradient posed by the step, and that the free‐stream disturbances accelerate the generation of instabilities in the downstream. As expected, it is found that the acoustic disturbance interacting with the surface imperfection is more efficient in exciting the Tollmien–Schlichting waves than the vorticity disturbance. The latter generates Tollmien–Schlichting waves that are grouped in wave packets consistent with the wavelength of the free‐stream disturbance. Copyright © 2015 John Wiley & Sons, Ltd.