Hydrogenation of citral on Ir/SiO2 catalysts. Effect of the addition of Nb2O5 on surface and catalytic properties

Hydrogenation of citral over Ir supported on SiO₂, Nb₂O₅ and Ir/Nb₂O₅-SiO₂ catalysts reduced at 473 K (LT) and 773 K (HT) was studied. High selectivity to unsaturated alcohol was found, the main reaction products being geraniol and nerol. The LT catalysts show higher conversion levels, the one with a higher Nb content displays highest conversion.     

Liquid phase hydrogenation of citral and intermediaries over Ir/TiO2/SiO2 catalysts: Kinetic study

Kinetics of the hydrogenation of citral and its intermediates over Ir/TiO₂/SiO₂ catalysts has been studied. The effect of various parameters such as the initial concentration, H₂ pressure partial, temperature and weight of catalyst were examined. A high selectivity towards unsaturated alcohols using this catalyst was demonstrated. The initial rates increased linearly with the catalyst weight. The reaction rate obeys a kinetics represented by the Langmuir–Hinshelwood model. A single site model suggesting the surface reaction as the rate determining step provided the best fit of the experimental data for the hydrogenation of citral and alcohols (geraniol, nerol and citronellol), while a dual site represent the best kinetics for the hydrogenation of citronellal.     

不同硅源的Cu/SiO2催化糠醛加氢制2-甲基呋喃

以硅溶胶和气相二氧化硅为载体,采用氨蒸法制备了Cu/SiO₂-sol和Cu/SiO₂-aer两种催化剂,采用N₂吸附脱附、X射线衍射（XRD）、傅里叶红外光谱（FT-IR）、透射电子显微镜（TEM）、N₂O-H₂滴定、氢气程序升温还原（H₂-TPR）、氨程序升温脱附（NH₃-TPD）及X射线光电子能谱（XPS）对样品进行表征,在固定床反应器中考察两种催化剂对糠醛气相加氢制2-甲基呋喃的催化性能。结果表明,Cu/SiO₂-sol催化剂具有更好的催化活性,在150 h反应时间内,糠醛转化率为100%,2-MF选择性在91%以上。这主要归因于以硅溶胶为硅源可以生成更多页硅酸铜,还原后催化剂表面Cu的分散性更高、弱酸位更多,有利于提高糠醛的转化率与2-甲基呋喃的选择性。同时Cu/SiO₂-sol具有较大的孔容孔径,有利于降低反应过程中积炭,延长催化剂寿命。     

单分散SiO2的焙烧温度对Rh基催化剂上CO加氢反应性能的影响

在比较了分别以商业SiO2和采用Sto?ber法制备的单分散SiO2为载体的Rh-Mn-Li/SiO2催化剂催化CO加氢反应性能的基础上,进一步调变了Stober法制备SiO2时的焙烧温度,并考察了其对Rh-Mn-Li/SiO2催化CO加氢性能的影响.利用N2吸附-脱附、傅里叶变换红外(FTIR)光谱、H2程序升温还原(H2-TPR)、程序升温表面反应(TPSR)等方法对载体及催化剂的物理化学性能进行了表征.结果表明:不同温度焙烧的载体表面具有不同的Si―OH数量,从而影响金属的分散状态及Rh和Mn之间的相互作用.载体表面较多的羟基有利于Rh的分散和CO的吸附,从而增强催化剂的反应活性.载体表面适当数量的羟基能够得到适中的Rh与Mn之间的相互作用,使催化剂具有合适的CO解离能力,有利于CHx的CO插入反应,从而提高了C2含氧化合物的选择性.     

CexZr1-xO2/Co/C-N催化CO2加氢性能研究

将不同比例的铈锆前驱体负载到ZIF-67,氮气气氛焙烧制备CexZr1-xO2/Co/C-N催化剂,对催化剂进行了XRD,H2-TPR、XPS表征,并在固定床反应器评价其CO2加氢制甲醇性能。XRD结果表明,在铈中加入适量锆形成铈锆固溶体,铈锆固溶体与钴物种较强的相互作用力可以阻止表明金属Co的氧化。但过量加入的锆又会削弱这一作用力,部分金属Co被氧化为Co3O4。H2-TPR结果表明适量的锆的加入改善催化剂的还原性能,催化剂还原温度降低。XPS证实了25%Ce0.67Zr0.33O2/Co/C-N催化剂中含有更多的氧空穴及氮含量,氧空穴和碱性氮都有利于CO2的解离吸附。优化后的25%Ce0.67Zr0.33O2/Co/C-N 催化剂在225 oC,2 MPa,GHSV = 6 L/gcat/h反应条件下取得最高甲醇时空收率,为3.0 mmol/gcat/h。     

Selective catalytic oxidation of NO with O2 over Ce-doped MnOx/TiO2 catalysts

A series of Ce-doped MnOx/TiO2 catalysts were prepared by impregnation method and used for catalytic oxidation of NO in the presence of excess O2. The sample with the Ce doping concentration of Ce/Mn=1/3 and calcined at 300°C shows a superior activity for NO oxidation to NO2. On Ce(1)Mn(3)Ti catalyst, 58% NO conversion was obtained at 200°C and 85% NO conversion at 250°C with a GHSV of 41000 h-1, which was much higher than that over MnOx/TiO2 catalyst (48% at 250°C). Characterization results implied that the higher activity of Ce(1)Mn(3)Ti could be attributed to the enrichment of well-dispersed MnOx on the surface and the abundance of Mn3+ and Ti3+ species. The addition of Ce into MnOx/TiO2 could improve oxygen storage capacity and facilitate oxygen mobility of the catalyst as shown by PL and ESR, so that its activity for NO oxidation could be enhanced. The effect of H2O and SO2 on the catalyst activity was also investigated.     

Product oriented oxidative bromination of methane over Rh/SiO2 catalysts

Rh/SiO2 was prepared for the oxidative bromination of methane. The catalyst was prepared by calcination at different temperatures and for different times to obtain catalysts with different specific surface areas for the purposes of producing either CH3Br or CH3Br and CO. It was found that the catalyst having a low specific surface area (calcined at relatively high temperature) favors the selective oxidation of methane to prepare CH3Br, while the catalyst having a high specific surface area favors the deeper partial oxidation of methane, which is good for CH3Br and CO preparation. The 650 h on stream life-time test revealed that the catalytic performance of the 0.4Rh/SiO2--900-10 catalyst was excellent. Both methane conversion and CH3Br selectivity kept increasing trends during the life-time test. No matter how serious was the Rh leaching during the reaction, the 0.4Rh/SiO2--900-10 catalyst did not deactivate at all.     

基于杨梅单宁制备Pt/SiO_2-C催化剂及其对肉桂醛选择性催化加氢性能

以天然植物多酚杨梅单宁(BT)改性的SiO2为载体,经吸附Pt4+、Na BH4还原和碳化处理制得Pt/SiO2-C催化剂.对所制备的催化剂进行了表征,并考察了催化剂对肉桂醛液相选择性催化加氢的性能.结果表明,由于杨梅单宁分子的分散稳定作用,使碳化过程中纳米Pt粒子粒径适度增长且保持高度分散.碳化温度影响杨梅单宁的脱除效果、纳米Pt粒子晶型与粒径,以及载体的比表面积与孔径,最终影响肉桂醛催化加氢性能.500℃碳化处理得到的Pt/SiO2-C-500催化剂的催化性能最佳,在乙醇为溶剂,323.25 K和2MPa氢压条件下,肉桂醛6 h转化率为82.98%,生成肉桂醇的选择性达到91.33%,表现出较高的催化活性和选择性.同时,该催化剂重复使用5次后其催化活性仍为第一次反应活性的81.18%,体现出优良的重复使用性.     

负载型CuO/TiO2催化剂催化CO2加氢制甲醇

采用浸渍法制备了CuO/TiO_2负载型催化剂,并将其用于CO2加氢制甲醇反应。重点考察了铜的负载量对催化剂性能的影响,并对其物化性能和催化性能之间的关系进行了讨论。结果发现,随着铜负载量的增加,催化剂中金属铜的比表面先增加后减小,当铜的负载量为10%(质量百分数)时达到最大值。催化剂的表面碱性位数量随铜含量的增加持续减小,中等碱位和强碱位的强度下降。当铜的负载量不高于10%时,CO2的转化率与铜的比表面积呈线性关系。甲醇选择性与催化剂的表面碱位性质有关,过强的碱性位会降低甲醇选择性。     

负载型CuO/TiO2催化剂催化CO2加氢制甲醇

采用浸渍法制备了CuO/TiO₂负载型催化剂,并将其用于CO₂加氢制甲醇反应。重点考察了铜的负载量对催化剂性能的影响,并对其物化性能和催化性能之间的关系进行了讨论。结果发现,随着铜负载量的增加,催化剂中金属铜的比表面先增加后减小,当铜的负载量为10%（质量百分数）时达到最大值。催化剂的表面碱性位数量随铜含量的增加持续减小,中等碱位和强碱位的强度下降。当铜的负载量不高于10%时,CO₂的转化率与铜的比表面积呈线性关系。甲醇选择性与催化剂的表面碱位性质有关,过强的碱性位会降低甲醇选择性。     

Transformation of n-hexane on Al2O3and SiO2supported Pt, Pt+Ga and Ir+Pt+Ga catalysts prepared by anchoring methods

Summary Transformation of n-hexane over Al₂O₃and SiO₂supported Pt, Pt+Ga and Ir+Pt+Ga catalysts was studied in a continuous-flow reactor operated under slug-pulse mode at 520°C. Bimetallic catalysts were prepared by introducing first Ga(OEt)₃and then diallylplatinum as precursor compounds. Iridium was then introduced viadecomposition of Ir₄(CO)₁₂adsorbed onto Pt+Ga catalysts. The addition of Ga to Pt/SiO₂catalyst decreased hydrogenation, aromatization and hydrogenolysis selectivity. Over Pt/Al₂O₃catalyst Ga increased hydrogenolysis selectivity and decreased isomerization and C₅-cyclization. The main effect of Ir was to increase hydrogenolysis selectivity and the stability of catalysts.</o:p>     

SiO2改性的V2O5-MoO3/ TiO2催化剂抗碱中毒性能研究

以陶瓷为骨架,用溶胶凝胶法和浸渍法制备了V₂O₅-MoO₃/ TiO₂催化剂,并用SiO₂进行改性。采用浸渍法模拟碱K中毒,研究了SiO₂改性前后催化剂中毒脱硝效率的变化,并通过BET、H₂-TPR、NH₃-TPD等技术手段对催化剂进行了表征。结果表明,加入SiO₂后,催化剂的比表面积明显提高。SiO₂改性后新鲜催化剂还原温度向低温方向迁移10 ℃左右,氧化还原能力得到了提高,其表面酸强度和酸量也得到较大的提高。反应评价结果表明,SiO₂改性可以提高催化剂抗碱中毒的性能。     

Effect of transition metals (Cr, Mn, Fe, Co, Ni and Cu) on selective hydrogenation of cinnamaldehyde over Pt/CNTs catalyst

Summary The effect of transition metals (Cr, Mn, Fe, Co, Ni and Cu) on the selective hydrogenation of cinnamaldehyde (CMA) to the corresponding semi-hydrogenated product over Pt/CNTs catalyst has been studied in ethanol at 343 K under 2.0 MPa H₂ pressure. PtNi/CNTs catalyst shows good catalytic activity and selectivity of C=C bond hydrogenation, 68.4% for conversion of CMA and 97.0% for selectivity of hydrocinnamaldehyde (HCMA). PtCo/CNTs catalyst shows good catalytic activity and selectivity of C=O bond hydrogenation, 91.3% for conversion of CMA and 88.2% for selectivity of cinnamylalcohol (CMO).     

Chemoselective Transfer Hydrogenation of Cinnamaldehyde over Activated Charcoal Supported Pt/Fe3O4 Catalyst

A variety of spherical and structured activated charcoal supported Pt/Fe₃O₄ composites with an average particle size of ～100 nm have been synthesized by a self-assembly method using the difference of reduction potential between Pt (IV) and Fe (Ⅱ) precursors as driving force. The formed Fe₃O₄ nanoparticles (NPs) effectively prevent the aggregation of Pt nanocrystallites and promote the dispersion of Pt NPs on the surface of catalyst, which will be favorable for the exposure of Pt active sites for high-efficient adsorption and contact of substrate and hydrogen donor. The electron-enrichment state of Pt NPs donated by Fe₃O₄ nanocrystallites is corroborated by XPS measurement, which is responsible for promoting and activating the terminal C=O bond of adsorbed substrate via a vertical configuration. The experimental results show that the activated charcoal supported Pt/Fe₃O₄ catalyst exhibits 94.8% selectivity towards cinnamyl alcohol by the transfer hydrogenation of cinnamaldehyde with Pt loading of 2.46% under the optimum conditions of 120℃ for 6 h, and 2-propanol as a hydrogen donor. Additionally, the present study demonstrates that a high-efficient and recyclable catalyst can be rapidly separated from the mixture due to its natural magnetism upon the application of magnetic field.     

La2O3助剂对Rh/SiO2催化CO加氢反应性能的影响

采用溶胶凝胶法制备了SiO_2和La_2O_3-SiO_2载体,再通过浸渍法分别引入Rh-La和Rh组分,研究考察了La引入方式对Rh/SiO_2催化CO加氢反应性能的影响。结果表明,La的添加有利于提高Rh的分散度,促进Rh+中心数的增加,有效地抑制产物中CO2的生成,提高含氧化合物选择性。此外,La的引入方式会影响La与Rh间的相互作用强弱,Rh和La共浸渍制得的2Rh-5La_2O_3/SiO_2催化剂中Rh-La相互作用较强,削弱的Rh-CO键有利于反应过程中CO的插入反应,使得产物以C_(2+)含氧化合物为主。而La以助剂形式掺入SiO_2制得的2Rh/5La_2O_3-SiO_2催化剂具有较弱的La-Rh相互作用,其产物则以甲醇、乙醇等低碳醇为主。     

Study of CO2 Hydrogenation to Methanol over Cu-V/γ-Al2O3 Catalyst

The effect of vanadium addition to CU/γ-Al2O3 catalyst used in the hydrogenation of CO2 to produce methanol was studied. It was found that the catalytic performance of the Cu-based catalyst improved after V addition. The influence of reaction temperature, space velocity and the molar ratio of H2 to CO2 on the performance of 12%Cu-6%V/γ-Al2O3 catalyst were also studied. The results indicated that the best conditions for reaction were as follows: 240℃, 3600 h-1 and a molar ratio of H2 to CO2 of 3:1. The results of XRD and TPR characterization demonstrated that the addition of V enhanced the dispersion of the supported CuO species, which resulted in the enhanced catalytic performance of CU-V/γ-Al2O3 binary catalyst.     

Photocatalytic Synthesis of Hydrocarbon Oxygenates from C2H6 and CO2 over Pd-MoO3/SiO2 Catalyst

Pd-MoO3/SiO2 catalyst has been prepared using the method of incipient wetness impregnation. The photo absorbing behaviors and chemisorbing properties of the catalyst have been characterized by UV-vis spectra and TPD-MS experiments. The results indicated that metal Pd loaded on MoOe/SiO2 has a significant effect on the photo absorbing performance of MoO3/SiO2, and an obvious blue shift of the absorption edge is produced. Under UV irradiation, the chemisorption state of CO2 undergoes decomposing process to form CO at 481 K, and a two-site adsorption state of ethane can be formed at around 496 K. Photo-oxidation of ethane using carbon dioxide can mainly produce propanal, ethanol and acetaldehyde in the temperature range of 353-423 K. The presence of metal Pd improves the catalytic activity remarkably.     

Hydrogenation of nitrate in water over bimetallic Pd-Ag/Al2O3 catalysts

Hydrogenation of nitrate (NO₃ ⁻) in water was studied with 0.8 ×10⁻³–3.2 ×10⁻³ mol/dm³ of reactant in the temperature range of 293–313 K over palladium promoted Ag catalysts. Pd-Ag catalysts with a low ratio of Ag/Pd were characterized by high efficiency in the reduction of nitrates. The degradation of nitrates followed approximately first order decay and the estimated apparent activation energy was about 4 kJ/mol.     

蒸氨压力对Cu/SiO_2催化剂的影响及其草酸二甲酯加氢性能

以Si O2为载体,铜氨溶液为前驱体,采用蒸氨法在不同蒸氨压力下制备了系列铜负载量质量分数为20.0%的Cu/Si O2催化剂。采用X射线衍射(XRD)、H2-程序升温还(H2-TPR)、高分辨透射电子显微镜(HRTEM)、X射线诱导俄歇电子能谱(XAES)等技术手段对催化剂的物理化学性能进行了表征。考察了蒸氨速率对催化剂物化结构及其草酸二甲酯催化加氢制乙二醇的催化性能影响。在反应温度200℃、压力3.0 MPa、液时空速LHSV=0.4 h-1、氢气草酸二甲酯摩尔比80∶1的反应条件下测定了催化剂的活性。结果表明,在蒸氨压力为31.3 k Pa条件下制备的催化剂表现出了最佳活性和选择性,草酸二甲酯转化率达到了99.9%,乙二醇选择性达94.4%。H2-TPR、XRD、TEM、FTIR及XAES表征结果表明,较低蒸氨压力有利于铜氨离子快速分解负载在载体上,避免铜粒子聚集长大,还原后形成Cu2O和Cu0物种颗粒尺寸较小,分散比较均匀,催化活性,尤其是乙二醇的选择性更佳。     

Zn4Si2O7(OH)2H2O盐修饰的纳米Ru催化剂催化苯选择加氢制环己烯

利用沉淀法制备了纳米Ru催化剂, 在ZnSO₄存在下考察了Na₂SiO₃·9H₂O和二乙醇胺作反应修饰剂对Ru催化剂催化苯选择加氢制环己烯性能的影响, 并用X-射线衍射(XRD)、X-射线荧光光谱(XRF)和透射电镜-能量散射谱(TEM-EDS)等物理化学手段对加氢前后Ru催化剂进行了表征。结果表明, 在水溶液中Na₂SiO₃与ZnSO₄可以反应生成Zn₄Si₂O₇(OH)₂H₂O盐、H₂SO₄和Na₂SO₄, 化学吸附在Ru催化剂表面上的Zn₄Si₂O₇(OH)₂H₂O盐起着提高Ru催化剂环己烯选择性的关键作用。Na₂SiO₃·9H₂O量的增加, 生成的Zn₄Si₂O₇(OH)₂H₂O盐逐渐增加, Ru催化剂的活性降低, 环己烯选择性逐渐升高。向反应体系中加入二乙醇胺, 它可以中和Na₂SiO₃与ZnSO₄反应生成的硫酸, 使化学平衡向生成更多的Zn₄Si₂O₇(OH)₂H₂O盐的方向移动, 导致Ru催化剂环己烯选择性增加。当Ru催化剂与ZnSO₄·7H₂O、Na₂SiO₃·9H₂O和二乙醇胺、分散剂ZrO₂的质量比为1.0:24.6:0.4:0.2:5.0时, 2 g Ru催化剂上苯转化73%时环己烯选择性和收率分别为75%和55%, 而且该催化剂体系具有良好的重复使用性和稳定性。