Preparative isolation and separation of a novel and two known flavonoids from Patrinia villosa Juss by high-speed counter-current chromatography

Preparative high-speed counter-current chromatography (HSCCC) was successfully used for isolation and separation three flavonoids including bolusanthol B, a novel compound named 5,7,2',6'-tetrahydroxy-6,8-di(gamma,gamma-dimethylallyl) flavanone and tetrapterol I from Patrinia villosa Juss using two-phase solvent system composed of n-hexane-ethyl acetate-methanol-water at the volume ratio of 10:11:11:8 (v/v). A total of 25.4 mg bolusanthol B, 52.5 mg 5,7,2',6'-tetrahydroxy-6,8-di(gamma,gamma-dimethylallyl) flavanone and 50.2 mg tetrapterol I were obtained from 250 mg crude extract with purities of 96.8%, 99.2% and 99.3%, respectively determined by HPLC in one single operation and less than 5 h. The structure identification was performed by UV, IR, MS, 1H NMR, 13C NMR and 2D NMR. Among then, bolusanthol B and tetrapterol I were obtained from the plant of Patrinia genius for the first time, and 5,7,2',6'-tetrahydroxy-6,8-di(gamma,gamma-dimethylallyl) flavanone was a novel prenylated flavonoid and discovered from nature for the first time.     

Supercritical fluid extraction of aurentiamide acetate from Patrinia villosa Juss and subsequent isolation by silica gel and high-speed counter-current chromatography

Supercritical fluid extraction (SFE) of aurentiamide acetate from Patrinia villosa Juss was performed. The optimization of parameters was carried out using an analytical-scale supercritical fluid extraction (SFE) system. Then the extraction was scaled up by 100 times using a preparative SFE system under the optimized conditions of 55 degrees C, 35 MPa and modified CO2 with 10% methanol. Then, the crude extract I obtained by SFE was chromatographed on silica gel and the solvent system composed of petroleum ether-ethyl acetate (5:1, v/v) was used to produce the crude extract II, which was further isolated and purified by high-speed counter-current chromatography (HSCCC) with a two-phase solvent system composed of n-hexane-ethyl acetate-methanol-water (1:1.2:1.2:1, v/v/v/v). One hundred fifty-five milligrams of aurentiamide acetate was obtained from 400 mg crude extract II (contained 42% target) with a purity of 99.3% determined by HPLC and 92.3% recovery in one-step elution, and identification was performed by UV, MS, 1H NMR and 13C NMR. As far as we know, this is the first report of discovering aurentiamide acetate from the plant of Patrinia genius.     

Efficient new method for extraction and isolation of three flavonoids from Patrinia villosa Juss. by supercritical fluid extraction and high-speed counter-current chromatography

Supercritical fluid extraction (SFE) of orotinin, orotinin-5-methyl ether and licoagrochalcone B from Patrinia villosa was performed. The optimization of parameters including pressure, temperature, modifier and sample particle size on yield was carried out using an analytical-scale SFE system. The process was then scaled up by 100 times using a preparative SFE system under the optimized conditions of 25 MPa, 45 degrees C, a sample particle size 40-60 mesh and modified CO2 with 20% methanol. The yield of the preparative SFE was 2.82% (crude extract I) and the combined yield of orotinin, orotinin-5-methyl ether and licoagrochalcone B was 0.82 mg/g of dry sample mass. Then the crude extract I was re-dissolved in methanol and methanol soluble fraction (crude extract II, 0.17%) was obtained, which was successfully isolated and separated by a preparative high-speed counter-current chromatography (HSCCC) with a two-phase solvent system composed of n-hexane-ethyl acetate-methanol-water (5:6:6:6, v/v/v/v) by increasing the flow-rate of the mobile phase stepwise from 1.0 to 2.0 ml/min after 3 h. The target compounds isolated and purified by HSCCC were analyzed by high performance liquid chromatography. The separation produced total of 38.2 mg of orotinin at 99.2% purity, 19.8 mg of orotinin-5-methyl ether at 98.5% purity and 21.5 mg of licoagrochalcone B at 97.6% purity from 400 mg of the crude extract in a one-step separation. The recoveries of orotinin, orotinin-5-methyl ether and licoagrochalcone B were 91.1, 91.6 and 90.3%, respectively, and the chemical structure identification was carried out by UV, IR, MS, 1H NMR and 13C NMR.     

高速逆流色谱分离制备椭圆叶花锚中的2种口山酮苷元

椭圆叶花锚的主要活性成分为口山酮类化合物,这类化合物具有利胆、抗炎、抗菌及抗病毒活性。应用高速逆流色谱法建立了2种高纯度口山酮苷元的分离制备方法。对椭圆叶花锚氯仿萃取部位运用高速逆流色谱分离纯化,以正己烷-乙酸乙酯-甲醇-水(5:5:7:5, v/v/v/v)为两相溶剂系统,上相为固定相,下相为流动相。在主机转速800 r/min,流动相流速1.5 mL/min,检测波长254 nm条件下进行分离制备。所得产物经高效液相色谱分析检测,其化学结构由核磁共振氢谱(1H NMR)和核磁共振碳谱(13C NMR)鉴定。在此条件下,从100 mg粗样品中一步分离得到18 mg 1-羟基-2,3,5-三甲氧基口山酮,14 mg 1-羟基-2,3,4,5-四甲氧基口山酮。经高效液相色谱分析,其纯度均达98%以上。该方法简便、快速,所得产物纯度高,适合于椭圆叶花锚口山酮苷元的制备分离。     

Preparative separation of minor saponins from Platycodi Radix by high-speed counter-current chromatography

Platycosides (PSs), the saponins found in the root of Platycodon grandiflorum (Jacq.) A. DC. (Platycodi Radix), are typically composed of oleanene backbones with two side chains; one is a 3-O-glucose linked by a glycosidic bond, and the other is a 28-O-arabinose-rhamnose-xylose-apiose linked by an ester bond. Minor saponins, acetylated isomers of the major saponin on either the 2' or 3' position of rhamnose, were isolated from Platycodi Radix using a multi-step process including high-speed counter-current chromatography (HSCCC) and preparative reversed-phase high-performance liquid chromatography (RP-HPLC). After the separation of the major components, the enriched minor saponin fraction was used for this study. A two-phase solvent system consisting of chloroform-methanol-isopropanol-water (3:2:2:3, v/v) was used for HSCCC. HSCCC separation of the enriched minor saponin fraction yielded 2'-O-acetylplatycodin D, 3'-O-acetylpolygalacin D, 2'-O-acetylpolygalacin and a mixture of 3'-O-acetylplatycodin D and polygalacin D. The mixture fraction from HSCCC separation was further purified by preparative RP-HPLC, giving 3'-O-acetylplatycodin D and polygalacin D at a purity of over 98.9%. The developed method provides the preparative and rapid separation of minor saponins in the crude extract of Platycodi Radix. To the best of our knowledge, this is the first on the separation of acetylated PSs by HSCCC.     

Preparative separation of rhein from Chinese traditional herb by repeated high-speed counter-current chromatography

High-speed counter-current chromatography (HSCCC) was repeatedly used for isolation and purification of rhein from Rheum officinale Baill (Dahuang) with a two-phase solvent system composed of n-hexane-ethyl acetate-methanol-water (3:7:5:5, v/v), which had been selected by analytical (HSCCC). Using two preparative units of the HSCCC centrifuge, about a 500 mg amount of the crude extract was separated, yielding 6.7 mg of rhein at a high purity of over 97%.     

Two New Dihydroflavanoids from Patrinia villosa Juss

Patrinia villosa Juss is a famous traditional Chinese medicine and often used in folkmedicine as anti-virus and anti-bacteria agent1,2. However, there is little research aboutits chemical study through a literature search. In order to find bioactive princ…     

Preparative separation of six antimycin A components from antimycin fermentation broth by high-speed counter-current chromatography

A method of using high-speed counter-current chromatography (HSCCC) was established for preparative isolation and purification of antimycin A components from antimycin fermentation broth. Six antimycin A components were successfully purified for the first time by HSCCC with a two-phase solvent system composed of n-hexane–ethyl acetate–methanol–water (5:2:4:1, by volume). Total of 20 mg antimycin A₄(a or b), 25 mg antimycin A₃(a or b), 21 mg antimycin A₈(a or b), 34 mg antimycin A₂(a or b), 26 mg antimycin A₁(a or b) and 34 mg antimycin A₁(a or b) with the purities of 93.2, 98.6, 96.2, 94.1, 94.9 and 96.7%, respectively, determined by high-performance liquid chromatography (HPLC), were yielded from 200 mg crude sample only in one HSCCC run.     

Preparative separation of six terpenoids from Wedelia prostrata Hemsl. by two-step high-speed counter-current chromatography

Terpenoids are principal chemical compounds of Wedelia prostrata Hemsl. and have different biological activities, thus the study on separation and purification of terpenoids from W. prostrata Hemsl. is necessary. In this paper, high-speed counter-current chromatography (HSCCC) was successfully established for preparative isolation and purification of terpenoids from extracts of petroleum ether fraction which extracted from whole herbs of W. prostrata Hemsl. In the process, a total of 750?mg of sample was prepared for HSCCC isolation. Terpenoids were separated and purified with the two-phase solvent system n-hexane–ethyl acetate–methanol–water (9:1:9:1, 19:1:19:1, v/v/v/v). Therefore, 5α-hydroxy-2-oxo-p-menth-6(1)-ene (4.4?mg), 3α-angeloyloxy-ent-kaur-16-en-oic acid (5.6?mg), 3α-tigloyloxy-ent-kaur-16-en-oic acid (5.7?mg), 3α-phenylpropionoyloxy-ent-kaur-16-en-oic acid (7.3?mg), 3α-senecioyloxy-ent-kaur-16-en-oic acid (11.4?mg), and kaurenoic acid (12.3?mg) were obtained from W. prostrata Hemsl. and their purities reached standard determined by HPLC. Among them, 3α-phenylpropionoyloxy-ent-kaur-16-en-oic acid and 5α-hydroxy-2-oxo-p-menth-6(1)-ene were first isolated with high quantity as a useful chemical resource. The structures of these compounds were identified by ESI-MS, ¹H-NMR, and ¹³C-NMR. The present results demonstrated that high-speed counter-current chromatography was a fast and efficient technique for preparative separation of six terpenoids from W. prostrata Hemsl. which provided a useful reference to solve the problem of their sample availability for drug development.     

Preparative separation of isoflavone components in soybeans using high-speed counter-current chromatography

The analysis of ionic micro-contamination is of growing importance in the disc drive industry. Through the use of ion chromatography, cleanliness of drive components can be assessed. An objective to improve quantification of highly reactive inorganic ions that exist within the drive environment was implemented. This paper presents a new extraction technique used to determine low levels of ammonium, by microbore ion chromatography. Various chemical compounds within adhesive formulations can be a source of extractable ammonium. By combining this new extraction method with ion chromatography, the percentage of different chemical compounds within adhesive formulations was correlated to the level of extractable ammonium observed.     

Preparative separation and purification of squalene from the microalga Thraustochytrium ATCC 26185 by high-speed counter-current chromatography

High-speed counter-current chromatography (HSCCC) was successfully applied to the preparative separation and purification of squalene from microalgae. Crude squalene was obtained from the microalga Thraustochytrium ATCC 26185 by extraction with organic solvents. The crude squalene was further separated using a waterless two-phase solvent system composed of n-hexane-methanol (2:1, v/v). The upper phase as the mobile phase was pumped into the column at a flow-rate of 2.0 ml min(-1) in the tail-to-head elution mode. The fractions purified and collected were analyzed by high-performance liquid chromatography. The method yielded 0.2 mg squalene at 96% purity from 150 mg of the crude squalene (0.14% squalene) with 95% recovery. The separation of squalene by HSCCC was completed in 90 min.     

Preparative isolation of procyanidins from grape seed extracts by high-speed counter-current chromatography

High-speed counter-current chromatography (HSCCC) has been applied to the separation of grape seed procyanidins. The isolation of dimeric to tetrameric procyanidins is achieved after removing the polymeric compounds by solvent precipitation. An additional clean-up by solid-phase extraction on polyamide improved the purities of the isolated compounds. The solvent systems ethyl acetate/2-propanol/water (40:1:40, v/v/v), ethyl acetate/2-propanol/water (20:1:20, v/v/v), and ethyl acetate/1-butanol/water (14:1:15, v/v/v) were successfully used for the fractionation. The combination of HPLC-MS, diode array detection, and NMR analysis, as well as phloroglucinolysis, confirmed the structures of the isolated compounds: B1 [EC-(4beta-->8)-C], B2 [EC-(4beta-->8)-EC], B3 [C-(4alpha-->8)-C], B4 [C-(4alpha-->8)-EC], B5 [EC-4beta-->6-EC], B7 [EC-(4beta-->8)-C], [ECG-(4beta-->8)-C], trimeric procyanidin C1 [EC-4beta-->8-EC-4beta-->8-EC], and the tetrameric procyanidin cinnamtannin A2 (where C: catechin, EC: epicatechin and ECG: epicatechin-3-O-gallate).     

Preparative isolation of three anthraquinones from Rumex japonicus by high-speed counter-current chromatography

Three anthraquinones--emodin, chrysophanol, and physcion--were successfully purified from the dichloromethane extract of the Chinese medicinal herb Rumex japonicus by high-speed counter-current chromatography (HSCCC). The extract was separated with n-hexane-ethanol-water (18:22:3, v/v/v) as the two-phase solvent system and yielded 3.4 mg of emodin, 24.1 mg of chrysophanol, and 2.0 mg of physcion from 500 mg of sample with purities of 99.2 %, 98.8% and 98.2%, respectively. The HSCCC fractions were analyzed by high-performance liquid chromatography (HPLC) and the chemical structures of the three anthraquinones were confirmed by 1H-NMR and 13C-NMR analysis. This is the first time these anthraquinones have been obtained from R. japonicus by HSCCC.     

Preparative isolation and purification of alkaloids from the Chinese medicinal herb Evodia rutaecarpa (Juss.) Benth by high-speed counter-current chromatography

High-speed counter-current chromatography (HSCCC) with a two-phase solvent system composed of n-hexane-ethyl acetate-methanol-water system (5:5:7:5, v/v) was applied to the isolation and purification of alkaloids from the Chinese medicinal plant Evodia rutaecarpa (Juss.) Benth. Five kinds of alkaloids were obtained and yielded 28 mg of evodiamine (I), 19 mg of rutaecarpine (II), 21 mg of evocarpine (III), 16mg of 1-methy-2-[(6Z,9Z)]-6,9-pentadecadienyl-4-(1H)-quinolone (IV), 12 mg of 1-methyl-2-dodecyl-4-(1H)-quinolone (V) from 180 mg of crude extract in a one-step separation, with the purity of 98.7%, 98.4%, 96.9%, 98.0%, 97.2%, respectively, as determined by high performance liquid chromatography (HPLC). The structures of these compounds were identified by 1H NMR and 13CNMR.     

Preparative separation and purification of deoxyschisandrin and gamma-schisandrin from Schisandra chinensis (Turcz.) Baill by high-speed counter-current chromatography

High-speed counter-current chromatography (HSCCC) was successfully applied to the preparative separation and purification of deoxyschisandrin and gamma-schisandrin from the crude petroleum ether extracts of Schisandra chinensis (Turcz.) Baill. The optimum solvent system composed of n-hexane-methanol-water (35:30:3, v/v) led to the successful preparation of deoxyschisandrin and gamma-schisandrin. The analysis of HPLC for each peak fraction of preparative HSCCC showed that the purity of deoxyschisandrin (8 mg) was over 98% and gamma-schisandrin (12 mg) was over 96% from 100 mg of the crude petroleum ether extracts in one-step separation.     

Preparative separation of cichoric acid from Echinacea purpurea by pH-zone-refining counter-current chromatography

pH-zone-refining counter-current chromatography was successfully applied to the separation of cichoric acid from Echinacea Purpurea (L.) Moench. A 3.0 g quantity of sample was separated using the following two-phase solvent system: MtBE-CH3CN-water (4:1:5, v/v), 10 mM trifluoroacetic acid in organic stationary phase and 10 mM ammonia in aqueous mobile phase. The obtained fractions were analyzed by high-performance liquid chromatography and negative ion electrospray ionization mass spectrometry. Double separations were performed with the same solvent system yielding 563 mg cichoric acid at 95.6% purity.     

Preparative purification of anti-tumor derivatives of honokiol by high-speed counter-current chromatography

In our program to synthesize a series of novel derivatives as potential analogs of honokiol for anti-tumor treatment, we have found that at least three of the derivatives of honokiol showed more potency to inhibit the proliferation of K562 leukemia cells and SPC-A1 adenocarcinoma cells. As a critical step to our further series synthesis of derivatives of honokiol, three derivatives of honokiol composed of two isomers and one compound with two formyl groups, which were hardly separated by common purification methods, needed to be rapidly separated and purified. The present work describes analytical and preparative high-speed counter-current chromatography (HSCCC) for the isolation and purification of these three C-formylation derivatives of honokiol, named 3'-formylhonokiol, 5-formylhonokiol and 3',5-diformylhonokiol, respectively. The solvent system for HSCCC separation was composed of hexane-ethyl acetate-methanol-water with the ratio of 1:0.4:1:0.4 (v/v). The one-step purification produced 157.8 mg, 121.6 mg and 21.2 mg of 3'-formylhonokiol, 5-formylhonokiol, 3',5-diformylhonokiol from crude sample of 400mg with purities of 98.6%, 99.2% and 99.6%, respectively, in an elution time of 2.5 h. The purities and structural identification were determined by HPLC, (1)H NMR, (13)C NMR and mass spectroscopy. Their anti-proliferation effects on K562, A549 and SPC-A1 cell lines were evaluated by MTT [3-(4,5-dimethylthiazol-2-yl)-2,5-diphenyltetrazolium bromide] assay.     

高速逆流色谱分离制备陈皮中的黄酮类化合物

应用高速逆流色谱法分离制备了陈皮中3种黄酮类化合物。以石油醚-乙酸乙酯-甲醇-水(体积比为2∶4∶3∶3)为两相溶剂系统,在主机转速850 r/min、流动相流速1.7 mL/min、检测波长280 nm条件下进行分离制备,6 h内从4.0 g陈皮粗提物中一步分离制备得到橙皮苷10.1 mg、桔皮素49.8 mg和5-羟基-6,7,8,3′,4′-五甲氧基黄酮50.6 mg,纯度均达97.0%以上,各化合物结构经质谱和核磁共振氢谱、碳谱鉴定。利用该方法可以对陈皮中的黄酮类化合物进行快速的分离和纯化。     

Preparative isolation and purification of anthocyanins from purple sweet potato by high-speed counter-current chromatography

High-speed counter-current chromatography (HSCCC) was applied to the preparative isolation and purification of peonidin 3-O-(6-O-(E)-caffeoyl-2-O-β-D -glucopyranosyl-β-D -glucopyranoside)-5-O-β-D -glucoside ( 1 ), cyanidin 3-O-(6-O-p-coumaroyl)-β-D -glucopyranoside ( 2 ), peonidin 3-O-(2-O-(6-O-(E)-caffeoyl-β-D -glucopyranosyl)-6-O-(E)-caffeoyl-β-D -glucopyranoside)-5-O-β-D -glucopyranoside ( 3 ), peonidin 3-O-(2-O-(6-O-(E)-feruloyl-β-D -glucopyranosyl)-6-O-(E)-caffeoyl-β-D -glucopyranoside)-5-O-β-D -glucopyranoside ( 4 ) from purple sweet potato. Separation of crude extracts (200 mg) from the roots of purple sweet potato using methyl tert-butyl ether/n-butanol/acetonitrile/water/trifluoroacetic acid (1:4:1:5:0.01, v/v) as the two-phase solvent system yielded 1 (15 mg), 2 (7 mg), 3 (10 mg), and 4 (12 mg). The purities of 1 – 4 were 95.5%, 95.0%, 97.8%, and 96.3%, respectively, as determined by HPLC. Compound 2 was isolated from purple sweet potato for the first time. The chemical structures of these components were identified by ¹H NMR, ¹³C NMR and ESI-MSⁿ.     

Preparative isolation and purification of coumarins from Peucedanum praeruptorum Dunn by high-speed counter-current chromatography

A preparative high-speed counter-current chromatography (HSCCC) method for isolation and purification of coumarins from Peucedanum praeruptorum Dunn (Baihuaqianhu in Chinese) was successfully established by using light petroleum-ethyl acetate-methanol-water as the two-phase solvent system in gradient elution mode. The upper phase of light petroleum-ethyl acetate-methanol-water (5:5:5:5, v/v) was used as the stationary phase of HSCCC. The mobile phase used in HSCCC was the lower phase of light petroleum-ethyl acetate-methanol-water (5:5:5:5, v/v) and light petroleum-ethyl acetate-methanol-water (5:5:6.5:3.5, v/v) that was changed in gradient. Four kinds of coumarins and another unknown compound were obtained and yielded 5.3 mg of qianhucoumarin D, 7.7 mg of Pd-Ib, 35.8 mg of (+)-praeruptorin A, 31.9 mg of (+)-praeruptorin B and 6.4 mg of unknown compound with the purity of 98.6%, 92.8%, 99.5%, 99.4% and 99.8% in one-step separation, respectively. The structures of the coumarins were identified by 1H NMR and 13C NMR.