UV-based solvent system screening for high-speed counter-current chromatography fractionation of compounds with similar UV absorption from complex samples followed by preparative HPLC purification: Flavonoids from barley seedlings as sample

This article proposes a solvent system screening strategy for compounds with similar UV absorption in complex samples by UV spectrophotometer. There is no need to calculate the partition coefficient value of each compound, only the partition coefficient of the whole sample. The partition coefficient value should be close to 1 in order to obtain as many high-speed counter-current chromatography fractions as possible. Then, preparative HPLC was used to purify the high-speed counter-current chromatography fractions. Based on the above strategy, seven c-glycosyl flavonoids and an amino acid were successfully obtained from barley seedlings through high-speed counter-current chromatography fractionation with ethyl acetate/n-butanol/water (8:2:10, v:v:v) system followed by preparative HPLC purification. The research shows that high-speed counter-current chromatography could be well developed as a tool for fractionation before purification, and greatly improves the separation efficiency.     

Iridoid-glycoside isolation and purification from Premna fulva leaves

Premna fulva Craib, rich in iridoid glycosides, is widely used to treat periarthritis, osteoproliferation, pain, and other diseases. However, no studies have reported effective purification methods for obtaining iridoid glycosides as active materials. This paper describes an efficient strategy for separating iridoid glycosides from Premna fulva leaves using high-speed counter-current chromatography and preparative high-performance liquid chromatography. A two-phase solvent system, ethyl acetate/n-butanol/water (7.5:2.5:10, v/v), was selected for high-speed counter-current chromatography separation. The proposed method effectively separated and purified four iridoid glycosides and four lignans, including three new iridoid glycosides ( 4–6 ) and five known compounds ( 1–3, 7, 8 ), from Premna fulva leaves, indicating that high-speed counter-current chromatography combined with prep-HPLC can efficiently isolate catalpol derivatives from the genus Premna. Additionally, the in vitro anti-inflammatory activities of all isolated compounds were analyzed using lipopolysaccharide-stimulated RAW 264.7 cells, and the results indicated that six compounds ( 1 and 3–7 ) exhibited potential anti-inflammatory activities.     

A Three-Phase Solvent System in High-Speed Counter-Current Chromatographic for the Separation and Purification of Bioactive Constituents from Acanthus ilicifolius

A new three-phase solvent system, n-hexane–acetonitrile–dichloromethane–water–ethyl acetate (5:5:1:5:1.5, v/v/v/v/v) was developed for the high-speed counter-current chromatographic (HSCCC) separation and purification of five bioactive constituents, syringic acid (1), vomifoliol (2), vanillic acid (3), 6-hydroxy-2-benzoxazolinone (4), and 2-benzoxazolinone (5), from Acanthus ilicifolius.

     

Preparative Isolation and Purification of Altertoxin I from an Alternaria sp. by HSCCC

Altertoxin I (ATX I) is one of the common mycotoxins produced by genus Alternaria which is a common food pathogen of fruits and grains. To prepare enough quantity of pure ATX I for further research of mutagenicity and toxicology tests, a novel method using preparative high-speed counter-current chromatography (HSCCC) was developed. The ethyl acetate crude extracts of the acetone washes obtained after fermentation of Alternaria sp. was separated using a two-phase solvent system composed of n-hexane–ethyl acetate–methanol–water (2:5:5:6, v/v). Collected fractions were analyzed by LC and identified by EI–MS and NMR analysis. The technique can isolate mg levels of the target compound per run.

     

Large-scale preparation of five polar polyphenols including three isomers from Phyllanthus emblica Linn. by preparative high-speed counter-current chromatography

The separation of polar compounds is challenging work due to poor retention and insufficient selectivity. In the present study, an efficient strategy for large-scale preparation of five polar polyphenols including three isomers from Phyllanthus emblica Linn has been established by preparative high-speed counter-current chromatography. Macroporous resin column chromatography was used for the enrichment of the polar polyphenols. However, sugar and other ultra-polar impurities were co-washed out with the targets. Liquid-liquid extraction with ethyl acetate/water (1/1, v/v) solvent system was developed to remove the ultra-polar impurities with a clearance rate of 95%. Finally, the targets were introduced to preparative high-speed counter-current chromatography for separation using ethyl acetate/n-butanol/acetic acid/water (2/7/1/10, v/v/v/v) solvent system. As a result, 191 mg of Mucic acid 1,4-lactone 5-O-gallate, 370 mg of β-Glucogallin, 301 mg of Gallic acid, 195 mg of Mucic acid 1,4-lactone 3-O-gallate and 176 mg of Mucic acid 1,4-lactone 2-O-gallate with purity higher than 98% were obtained from 1.5 g of sample. Mucic acid 1,4-lactone 3-O-gallate, Mucic acid 1,4-lactone 3-O-gallate, and Mucic acid 1,4-lactone 2-O-gallate are isomers. The results showed that high-speed counter-current chromatography could be well developed for the separation of polar compounds from natural products.     

Preparative Isolation and Purification of Two Phenylpropanoids from Daphne giraldii Nitsche by HSCCC

Preparative high-speed counter-current chromatography (HSCCC) was successfully applied to purify phenylpropanoids from the stem and root bark of Daphne giraldii Nitsche, a traditional Chinese medicine. Their structures were identified on the basis of ¹H NMR and ¹³C NMR technology. The two-phase solvent system composed of n -hexane–ethyl acetate–methanol–water (2: 3: 0.5: 4, v/v/v/v) was selected for HSCCC. A total of 8.0 mg woonenoside XI (1) and 18.0 mg daphnetin (2) were obtained in one-step separation from 200 mg of the crude extract with purity of 96.0 and 99.1%, respectively, as determined by LC. And the major compound (2) showed antithrombotic activity in vitro.     

Isolation of three glucaric acids from Leonurus japonicus Houtt. by using high-speed countercurrent chromatography combined with semi-preparative high-performance liquid chromatography

The isomerism of glucaric acids and the complexity of the composition of Leonurus japonicus Houtt. increased the difficulty of the separation of glucaric acids from the herb. In the present study, three glucaric acids were isolated from Leonurus japonicus Houtt. by using high-speed countercurrent chromatography combined with semi-preparative high-performance liquid chromatography. Cation exchange resin chromatography was applied to remove the alkaloids and enrich the glucaric acid fractions. Preliminary separation of the glucaric acid extract by high-speed countercurrent chromatography was carried out at 45℃ by using an optimized solvent system of ethyl acetate/n-butanol/formic acid/water (1:1:0.01:2, v/v/v/v) with satisfied stationary phase retention and separation factor. The semi-preparative high-performance liquid chromatography was used for further separation and purification of the target fractions, and three monomeric compounds were obtained with purities of 90.0, 91.0, and 95.3%. UV spectroscopy, NMR spectroscopy, and mass spectrometry were employed to identify their structures, which were assigned as 2-syringyl glucaric acid, 2,4-disyringyl glucaric acid, and 3,4-disyringyl glucaric acid, respectively, and 2,4-disyringyl glucaric acid was reported for the first time.     

Separation and identification of polyphenols in apple pomace by high-speed counter-current chromatography and high-performance liquid chromatography coupled with mass spectrometry

Apple pomace, a by-product in the processing of apple juice, was investigated as a potential source of polyphenols. Two methods of separation and purification of polyphenols from apple pomace extract were established by combination of gel chromatography with high-speed counter-current chromatography (HSCCC) and solvent extraction with HSCCC, respectively. The optimal separation was performed on a Sephadex LH-20 column using gradient aqueous ethanol as eluting solvent from 0% to 100% in increments of 10%. HPLC analysis indicated that main polyphenols existed in fractions eluted between 40% and 50% aqueous ethanol. The fractions of interest from column were separated by HSCCC with the solvent system hexane–ethyl acetate–1% aqueous acetic acid (0.5:9.5:10, v/v/v). Ethyl acetate fractionation of the apple pomace extract followed by direct HSCCC separation by the same solvent system in the volume ratio of 1:9:10 also produced a good separation of the main polyphenols of interest. Six high-purity polyphenols were achieved tentatively and identified by HPLC/MS: chlorogenic acid (1, m/z 354), quercetin-3-glucoside/quercetin-3-glacaside (2, m/z 464), quercetin-3-xyloside (3, m/z 434), phloridzin (4, m/z 436), quercetin-3-arabinoside (5, m/z 434), and quercetin-3-rhamnoside (6, m/z 448). These results provided a preliminary foundation for further development and exploration of apple pomace.     

Preparative isolation of diterpenoids from Salvia bowleyana Dunn roots by high-speed countercurrent chromatography combined with high-performance liquid chromatography

The root of Salvia bowleyana Dunn (Lamiaceae) is used as a traditional Chinese medicine that has multiple therapeutic effects. In this study, an efficient strategy was developed to separate diterpenoid compounds, which are the main active ingredients in Salvia bowleyana Dunn roots, from complex crude extracts by high-speed countercurrent chromatography combined with preparative high-performance liquid chromatography. A two-phase solvent system comprising n-hexane–ethyl acetate–methanol–water (7:3:7:3, v/v/v/v) was selected for high-speed countercurrent chromatographic separation. Three major diterpenoids, 6α-hydroxysugiol ( 7 ), sugiol ( 8 ), and 6, 12-dihydroxyabieta-5,8,11,13-tetraen-7-one ( 9 ) were obtained at purities of 98.9, 95.4, and 96.2%, respectively, and minor diterpenoids were enriched via one-step separation. The enriched minor diterpenoids were further purified by continuous preparative high-performance liquid chromatography to yield two new norabietanoids ( 1 , 6 ) and four known compounds ( 2 – 5 ). The structures of these new compounds were determined using NMR spectroscopy, high-resolution electrospray ionization mass spectrometry, and electronic circular dichroism spectroscopy. The results suggest that high-speed countercurrent chromatography combined with preparative high-performance liquid chromatography efficiently isolates diterpenoids, including minor components, from complex natural products.     

Separation of caffeoylquinic acids and flavonoids from Asteris souliei by high‐performance counter‐current chromatography and their anti‐inflammatory activity in vitro

Eleven compounds were successfully separated from Asteris souliei by using a two‐step high‐performance counter‐current chromatography method. The first step involved a reversed phase isocratic counter‐current chromatography separation using hexane/ethyl acetate/methanol/water (1:0.8:1:1 v/v/v/v), which produced three fractions, the first two of which were mixtures. The second step used step‐gradient reversed‐phase counter‐current chromatography with hexane/butanol/ethyl acetate/methanol/water (1:0.5:3.5:1:4 v/v/v/v/v) initially followed by hexane/ethyl acetate/methanol/water (1:2:1:2 v/v/v/v) to separate Fraction 1 into seven compounds; and hexane/ethyl acetate/methanol/water (1:1:1:1.2 v/v/v/v) to separate Fraction 2 into three further compounds. The chemical structures of the separated compounds were identified by ESI‐MS and NMR spectroscopy (¹H and ¹³C). Baicalin ( 5 ), eriodictyol ( 7 ), apigenin‐7‐glycoside ( 8 ), quercetin ( 9 ), luteolin ( 10 ), and apigenin ( 11 ) showed obvious inhibitory effects on lipopolysaccharide‐induced nitric oxide production in RAW264.7 cells at a concentration of 10 μg/mL.     

Preparative Isolation and Purification of Altertoxin I from an Alternaria sp. by HSCCC

Altertoxin I (ATX I) is one of the common mycotoxins produced by genus Alternaria which is a common food pathogen of fruits and grains. To prepare enough quantity of pure ATX I for further research of mutagenicity and toxicology tests, a novel method using preparative high-speed counter-current chromatography (HSCCC) was developed. The ethyl acetate crude extracts of the acetone washes obtained after fermentation of Alternaria sp. was separated using a two-phase solvent system composed of n-hexane–ethyl acetate–methanol–water (2:5:5:6, v/v). Collected fractions were analyzed by LC and identified by EI–MS and NMR analysis. The technique can isolate mg levels of the target compound per run.     

Separation of flavonoids from Millettia griffithii with high‐performance counter‐current chromatography guided by anti‐inflammatory activity

Millettia griffithii is a unique Chinese plant located in the southern part of Yunnan Province. Up to now, there is no report about its phytochemical or related bioactivity research. In our previous study, the n‐hexane crude extract of Millettia griffithii revealed significant anti‐inflammatory activity at 100 μg/mL, inspiring us to explore the anti‐inflammatory constituents. Four fractions (I, II, III, and A) were fractionated from n‐hexane crude extract by high‐performance counter‐current chromatography with solvent system composed of n‐hexane/ethyl acetate/methanol/water (8:9:8:9, v/v) and then were investigated for the potent anti‐inflammatory activity. Fraction A, with the most potent inhibitory activity was further separated to give another four fractions (IV, V, VI, and B) with solvent system composed of n‐hexane/ethyl acetate/methanol/water (8:4:8:4, v/v). Compound V and fraction B exhibited remarkable anti‐inflammatory activity with nitric oxide inhibitory rate of 80 and 65%, which was worth further fractionation. Then, three fractions (VII, VIII, and IX) were separated from fraction B with a solvent system composed of n‐hexane/ethyl acetate/methanol/water (8:1:8:1, v/v), with compound VIII demonstrating the most potent inhibitory activity (80%). Finally, the IC₅₀ values of compound V and VIII were tested as 38.2 and 14.9 μM. The structures were identified by electrospray ionization mass spectrometry and¹H and ¹³C NMR spectroscopy.     

Determination of five toxic alkaloids in two common herbal medicines with capillary electrophoresis

Calycosin was purified from an ethyl acetate extract of the root of Astragalus membranaceus Bge. var. mongholicus (Bge.) Hsiao by high-speed counter-current chromatography. The separation was performed in two steps with a two-phase solvent system composed of n-hexane-chloroform-methanol-water (1:3:3:2, v/v). From 200 mg of the crude extract, 14.8 mg of calycosin was obtained at over 99% purity as determined by HPLC analysis, and its chemical structure was confirmed by MS, 1H and 13C nuclear magnetic resonance.     

Preparative Isolation of Imperatorin, Oxypeucedanin and Isoimperatorin from a Traditional Chinese Herb Using a HSCCC Strategy Based on Optimization of Rapid Flow Rate

Preparative high-speed counter-current chromatography has been used successfully for the isolation and purification of imperatorin, oxypeucedanin and isoimperatorin from traditional Chinese herb “bai zhi”—Angelica dahurica (Fisch. ex Hoffm) Benth. et Hook using high-speed counter-current chromatography (HSCCC). This was achieved in two stages. The first stage used a high flow HSCCC protocol with a two-phase solvent system composed of n-hexane–ethyl acetate–methanol–water (HEMW) with volume ratios of 5:5:5:5, v/v which isolated isoimperatorin but co-eluted imperatorin and oxypeucedanin. The second stage used HEMW 5:5:4:6, v/v at low flow rate to resolve the co-eluted components from the first stage. The flow rate was optimized by preparative HSCCC. 300 mg of the crude extract was separated, yielding 18.5 mg of imperatorin, 8.3 mg of oxypeucedanin and 9.8 mg of isoimperatorin all at a high purity of over 98%.     

Isolation of three sesquiterpene lactones from the roots of Cichorium glandulosum Boiss. et Huet. by high-speed counter-current chromatography

Because of the skeletal complexity and similarity of the polarity, little research was reported on the isolation of sesquiterpene lactones by high-speed counter-current chromatography (HSCCC). Herein, three sesquiterpene lactones were successfully purified from the ethyl acetate extract of the roots of the traditional Uyghur medicinal plant Cichorium glandulosum Boiss. et Huet. by HSCCC. The separation was performed in two steps with two solvent systems: n-hexane-ethyl acetate-methanol-water (1.5:5:2.75:5, v/v/v/v) and ethyl acetate-methanol-water (20:1:20, v/v/v). From 166 mg of the ethyl acetate extract, 19 mg of lactucopicrin was isolated with the first solvent system and 10 mg of 11beta,13-dihydrolactucin and 16 mg of lactucin were obtained with the second solvent system. All purified compounds were over 94% purity as determined by HPLC analysis, and these chemical structures were confirmed by (1)H NMR and (13)C NMR.     

Separation of five flavone glycosides including two groups with similar polarities from Dracocephalum tanguticum by a combination of three high-speed counter-current chromatography modes

The separation of compounds with similar polarities is challenging. In the present study, five flavone glycosides, including two groups with similar polarities, were obtained from Dracocephalum tanguticum by three high-speed counter-current chromatography modes, including flow rate conversion mode, recycling mode, and heart-cut mode. With flow rate conversion mode, compounds 3 and 4 with similar polarities and compound 5 were separated by high-speed counter-current chromatography with ethyl acetate/methanol/water (5.0% acetic acid) (8:2:10, v/v) system. The flow rate was controlled as: 1.8 mL/min for 0–160 min, 2.2 mL/min for 160–200 min, and 2.5 mL/min for 200–400 min. However, compounds 1 and 2 with similar polarities were not separated due to the similar distributive properties. Then, a recycling and heart-cut mode were introduced to improve the separation efficiency. The heart-cut mode was introduced in the second and third cycles, and compounds 1 and 2 were well separated in the fourth cycle. Consequently, five flavone glycosides, including two groups with similar polarities were obtained and identified as cosmosiin (1), pedaliin (2), quercetin-3-O-rutinoside (3), pedaliin-6''-acetate (4), and sorbifolin-6-O-β-glucopyranoside (5). The current strategy provides a reference for separating compounds with similar polarities from a crude sample.     

Application of preparative high-speed counter-current chromatography for separation of methyl gallate from Acer truncatum Bunge

Preparative separation of methyl gallate in leaves extract of Acer truncatum Bunge was conducted using high-speed counter-current chromatography (HSCCC) with a solvent system composed of ethyl acetate-ethanol-water at volume ratios of 5:1:5 (v/v/v). In a single operation, 57.5 mg of methyl gallate was obtained from 120 mg of the extract. HPLC analyses of the counter-current chromatography (CCC) fraction revealed that the methyl gallate was having over 97% purity. Its structure was identified by 1H NMR and 13C NMR.     

Development of an efficient method for the preparative isolation and purification of chlorophyll a from a marine dinoflagellate Amphidinium carterae by high-speed counter-current chromatography coupled with reversed-phase high-performance liquid chromatography

In our research into chlorophylls of marine dinoflagellates, chlorophyll a was separated rapidly from the hexane extract of Amphidinium carterae in three steps. The first step was silica gel column chromatography, where elution was performed with 0–50% ethyl acetate in n-hexane. The second was high-speed counter-current chromatography using a two-phase solvent system consisting of n-hexane–ethyl acetate–methanol–water (5:5:5:1, v/v), and the third step was preparative reversed-phase high-performance liquid chromatography using a solvent system of acetone–water (89:11, v/v). HPLC analysis showed that the purity of chlorophyll a from the second step was over 83%, and after the third it was over 99%. Thirty milligrams of chlorophyll a was isolated from a crude sample of 250 mg of chlorophylls, and its structure was identified by analyzing its MS, ¹H NMR and ¹³C NMR spectra.     

Preparative separation of six terpenoids from Wedelia prostrata Hemsl. by two-step high-speed counter-current chromatography

Terpenoids are principal chemical compounds of Wedelia prostrata Hemsl. and have different biological activities, thus the study on separation and purification of terpenoids from W. prostrata Hemsl. is necessary. In this paper, high-speed counter-current chromatography (HSCCC) was successfully established for preparative isolation and purification of terpenoids from extracts of petroleum ether fraction which extracted from whole herbs of W. prostrata Hemsl. In the process, a total of 750?mg of sample was prepared for HSCCC isolation. Terpenoids were separated and purified with the two-phase solvent system n-hexane–ethyl acetate–methanol–water (9:1:9:1, 19:1:19:1, v/v/v/v). Therefore, 5α-hydroxy-2-oxo-p-menth-6(1)-ene (4.4?mg), 3α-angeloyloxy-ent-kaur-16-en-oic acid (5.6?mg), 3α-tigloyloxy-ent-kaur-16-en-oic acid (5.7?mg), 3α-phenylpropionoyloxy-ent-kaur-16-en-oic acid (7.3?mg), 3α-senecioyloxy-ent-kaur-16-en-oic acid (11.4?mg), and kaurenoic acid (12.3?mg) were obtained from W. prostrata Hemsl. and their purities reached standard determined by HPLC. Among them, 3α-phenylpropionoyloxy-ent-kaur-16-en-oic acid and 5α-hydroxy-2-oxo-p-menth-6(1)-ene were first isolated with high quantity as a useful chemical resource. The structures of these compounds were identified by ESI-MS, ¹H-NMR, and ¹³C-NMR. The present results demonstrated that high-speed counter-current chromatography was a fast and efficient technique for preparative separation of six terpenoids from W. prostrata Hemsl. which provided a useful reference to solve the problem of their sample availability for drug development.     

Application of preparative high-speed counter-current chromatography for separation and purification of arctiin from Fructus Arctii

Following an initial clean-up step on the AB-8 resin (polystyrene resin, 0.3-1.25 mm: NanKai Chemical Factory, Tianjin, China), high-speed counter-current chromatography (HSCCC) was used to purify an arctiin from an extract of the fruits of the Arctium lappa L. Arctiin is a major lignan compound in the traditional Chinese medicinal herb A. lappa L. The two-phase solvent system used was composed of ethyl acetate-n-butanol-ethanol-water at an optimized volume ratio of 5:0.5:1:5 (v/v/v/v). The upper phase was used as the mobile phase in the head to tail elution mode. A total amount of 159 mg of arctiin at 98% purity was obtained from 350 mg of the crude extract (containing 49% arctiin) with 91% recovery. The preparative isolation and purification of arctiin by HSCCC was completed in 5 h in a separation. Identification of the target compound was performed by LC-electrospray ionization MS and 13C-NMR. The structure of the product was further confirmed by comparison with authentic sample (National Institute of the Control of Pharmaceutical and Biological Products, Beijing, China).