Change in the enzymatic dual function of the peroxiredoxin protein by gamma irradiation

PP1084 protein was exposed to gamma irradiation ranging from 5 to 500 kGy. Native PAGE showed minor structural changes in PP1084 at 5 kGy, and major structural changes at >15 kGy. Size-exclusion chromatography (SEC) showed the formation of a new shoulder peak when the protein was irradiated with 15 and 30 kGy, and a double peak appeared at 100 kGy. The results of PAGE and SEC imply that PP1084 protein is degraded by gamma irradiation, with simultaneous oligomerization. PP1084 chaperone activity reached the highest level at 30 kGy of gamma irradiation, and then, decreased in a dose-dependent manner with increasing gamma irradiation. However, the peroxidase activity significantly decreased following exposure to all intensities of gamma irradiation. The improvement of chaperone activity using gamma irradiation might be promoted by the oligomeric structures containing covalently cross-linked amino acids. Consequently, PP1084 modification using gamma irradiation could elevate chaperone activity by about 3–4 folds compared to the non-irradiated protein.     

Quality of fresh-cut Iceberg lettuce and spinach irradiated at doses up to 4 kGy

Fresh-cut Iceberg lettuce packaged in modified atmosphere packages and spinach in perforated film bags were irradiated with gamma rays at doses of 0, 1, 2, 3, and 4 kGy. After irradiation, the samples were stored for 14 days at 4 °C. O₂ levels in the packages of fresh-cut Iceberg lettuce decreased and CO₂ levels increased with increasing radiation dose, suggesting that irradiation increased respiration rates of lettuce. Tissue browning of irradiated cut lettuce was less severe than that of non-irradiated, probably due to the lower O₂ levels in the packages. However, samples irradiated at 3 and 4 kGy had lower maximum force and more severe sogginess than the non-irradiated control. In addition, ascorbic acid content of irradiated lettuce was 22–40% lower than the non-irradiated samples after 14 days of storage. The visual appearance of spinach was not affected by irradiation even at a dose of 4 kGy. Consumer acceptance suggested that more people would dislike and would not buy spinach that was treated at 3 and 4 kGy as compared to the non-irradiated sample. Overall, irradiation at doses of 1 and 2 kGy may be employed to enhance microbial safety of fresh-cut Iceberg lettuce and spinach while maintaining quality.     

Determination of the changes of antifungal properties of Satureja hortensis,Thymus vulgaris and Thymbra spicata exposed to gamma irradiation

In this research, changes in the antifungal activity of the extract of Satureja hortensis, Thymus vulgaris and Thymbra spicata exposed to gamma irradiation against two aflatoxigenic moulds Aspergillus parasiticus NRRL 2999 and 465 were investigated. The samples of dry plant leaf powder were irradiated with doses of 1.2, 3.0, 5.1 kGy. While the antifungal activity of S. hortensis with 0 and 1.2 kGy dose irradiation against A. parasiticus NRRL 2999 was found to be similar, it decreased with 3.0 and 5.1 kGy irradiation doses (P<0.05). On the contrary, antifungal activity of T. spicata increased until 3.0 kGy and then it decreased with 5.1 kGy irradiation dose (P<0.05). For T. vulgaris, an increase of irradiation dose resulted in a decrease of antifungal activity against aflatoxigenic moulds. This research shows that antifungal properties of some spices can be changed by gamma irradiation.     

Swelling characteristics and application of gamma-radiation on irradiated SBR-carboxymethylcellulose (CMC) blends

Blends of styrene butadiene rubber (SBR) with varying loading degree from 60 wt% to 100 wt% of carboxymethylcellulose (CMC) have been prepared. Gamma radiation vulcanization of prepared blends was carried out with doses varying between 50 kGy and 250 kGy. Mechanical properties, namely, tensile strength (Ts), elongation at break (E_b) and hardness were followed up as a function of loading degree of CMC and gamma irradiation dose. Moreover, physical properties, specifically swelling number (SN) and gel fraction % (GF%) were undertaken. Results obtained showed an improvement in mechanical as well as in physical properties with increasing either CMC content or dose of irradiation. Thermal properties namely thermo gravimetric analysis (TGA) was carried out.     

Evaluation of protein content, lysine and sulfur-containing amino acids content and electrophoretic patterns of soluble proteins for gamma-irradiated semolina before and after milling of durum wheat

Influenced of gamma irradiation (0, 0.25, 1, 2.5, 5 and 10 kGy) on total nitrogen, lysine and sulfur-containing amino acids content and electrophoretic patterns of soluble proteins of semolina was studied. The effect of irradiation before and after milling on previous parameters was also investigated. Protein content of semolina was not affected with gamma irradiation before and after milling. Up to 10 kGy dose, cystine and methionine were not significantly changed, although they increased slightly with increasing irradiation dose. Lysine content decreased significantly (P≤0.05) at irradiation dose higher than 5 kGy. At 10 kGy dose, lysine decreased 5% and 14% for irradiated semolina and that obtained from irradiated wheat grains, respectively. The bands number and intensity of soluble proteins decreased with increasing irradiation dose higher than 5 kGy, as shown on SDS-PAGE electrophoresis. Irradiated semolina and semolina obtained from irradiated wheat grains at 10 kGy showed 13 and 15 bands, respectively. Unirradiated sample showed 19 bands.     

The response characteristics of tetrazolium violet solutions to gamma irradiation

The dosimetry characteristics of various solutions of tetrazolium violet, TV, (2,5-diphenyl-3-(1-naphthyl)-2H-tetrazolium chloride) to gamma irradiation are reported. The optical absorption spectra of these solutions show peaks between 400 and 600 nm with a shoulder at around 550 nm. The dose response of the optical absorbance values of aqueous and aqueous-alcoholic solutions containing different concentrations of TV was measured in the 250 Gy up to 75 kGy dose range. The formation of formazan product was observed due to radiolytic reduction in both solutions. Its formation was found more pronounced in N₂-saturated as well as in alkaline solutions. The results indicate that the 1 mM TV solution can be used for food irradiation and medical sterilization dosimetry at gamma irradiation facilities.     

Effect of gamma radiation on the mechanical and barrier properties of HEMA grafted chitosan-based films

Chitosan films were prepared by dissolving 1% (w/v) chitosan powder in 2% (w/v) aqueous acetic acid solution. Chitosan films were prepared by solution casting. The values of puncture strength (PS), viscoelasticity coefficient and water vapor permeability (WVP) of the films were found to be 565 N/mm, 35%, and 3.30 g mm/m² day kPa, respectively. Chitosan solution was exposed to gamma irradiation (0.1–5 kGy) and it was revealed that PS values were reduced significantly (p≤0.05) after 1 kGy dose and it was not possible to form films after 5 kGy. Monomer, 2-hydroxyethyl methacrylate (HEMA) solution (0.1–1%, w/v) was incorporated into the chitosan solution and the formulation was exposed to gamma irradiation (0.3 kGy). A 0.1% (w/v) HEMA concentration at 0.3 kGy dose was found optimal-based on PS values for chitosan grafting. Then radiation dose (0.1–5 kGy) was optimized for HEMA grafting. The highest PS values (672 N/mm) were found at 0.7 kGy. The WVP of the grafted films improved significantly (p≤0.05) with the rise of radiation dose.     

Effect of combined radiation and NaOCl/ultrasonication on reduction of Bacillus cereus spores in rice

In this study, ionizing radiation in combination with sodium hypochlorite (NaOCl) and ultrasonication (US) was examined for its effectiveness in reducing Bacillus cereus F4810/72 spores in raw rice. We also evaluated whether the combined processing would produce synergistic effects compared to the individual treatments. The concentration of the initial B. cereus spore was approximately 2.9 log₁₀ CFU/g. After 0.1, 0.2 and 0.3 kGy irradiation treatment, spore populations were reduced by 1.3, 1.4 and 1.6 log₁₀ CFU/g, respectively. In the case of combined gamma irradiation and NaOCl/US treatment, the reduction was higher than those of each single treatment. The combined treatment of 0.1, 0.2 and 0.3 kGy and NaOCl (600–1000 ppm)/US (5–20 min) completely destroyed the spores in raw rice while the spores were not completely destroyed in the control treatment (0 kGy). These results indicated that it could be more effective to combine NaOCl with low dose gamma irradiation than high dose (concentration) of individual disinfection treatment to destroy B. cereus spores in food such as raw rice.     

Evaluation of γ-radiation on oolong tea odor volatiles

The aim of this study was to evaluate the gamma radiation effects on odor volatiles in oolong tea at doses of 0, 5, 10, 15 and 20 kGy. The volatile organic compounds were extracted by hydrodistillation and analyzed by GC/MS. The irradiation has a large influence on oolong tea odor profile, once it was identified 40% of new compounds after this process, the 5 kGy and 20 kGy were the doses that degraded more volatiles found naturally in this kind of tea and the dose of 10 kGy was the dose that formed more new compounds. Statistical difference was found between the 5 kGy and 15 kGy volatile profiles, however the sensorial analysis showed that the irradiation at dose up 20 kGy did not interfere on consumer perception.     

Effects of gamma and electron beam irradiation on the survival of pathogens inoculated into sliced and pizza cheeses

The objective of this study was to identify the efficacy of gamma and electron beam irradiation of the food-borne pathogens (Listeria monocytogenes and Staphylococcus aureus) in sliced and pizza cheeses commercially available in the Korean market. Total aerobic bacteria and yeast/mold in the cheeses ranged from 10² to 10³ Log CFU/g. Irradiation of 1 kGy for sliced cheese and 3 kGy for pizza cheese were sufficient to lower the total aerobic bacteria to undetectable levels (10¹ CFU/g). Pathogen inoculation test revealed that gamma irradiation was more effective than electron beam irradiation at the same absorbed dose, and the ranges of the D₁₀ values were from 0.84 to 0.93 kGy for L. monocytogenes and from 0.60 to 0.63 kGy for S. aureus. Results suggest that a low dose irradiation can improve significantly the microbial quality and reduce the risk of contamination of sliced and pizza cheeses by the food-borne pathogens which can potentially occur during processing.     

Degradation of poly(carbonate urethane) by gamma irradiation

Poly(carbonate urethane) (PCU), is a valuable commercial engineering polymer. In order to understand the possible use of PCU in radioactive waste management as a solidifying agent or as a disposal container, radiation stability of the PCU is studied by Co-60 gamma irradiations at two different dose rates of 1540 and 82.8 Gy/h. The total dose of irradiation was up to 6.24 MGy. Degradation nature was tested by studying the changes in mechanical and thermal properties with rate and total dose of irradiation. Ultimate tensile strength and toughness first increased and then decreased with the irradiation dose. Half value dose (HVD) for elongation was 4010 kGy and for tensile strength 6010 kGy at the dose rate of 1540 Gy/h. The non-irradiated PCU transparent color changed to yellow and then brown with increased irradiation dose. The FTIR spectral analysis showed a random scission of polymer with irradiation. From the experimental observation, it was shown that PCU can be used for embedding radioactive waste for about 300 years.     

Applicability of the Sunna dosimeter for food irradiation control

The quick development concerning the commercial application of food irradiation in the USA recently resulted in growing marketing of irradiated red meat as well as irradiated fresh and dried fruits. These gamma and electron irradiation technologies require specific dosimetry systems for process control. The new version of the Sunna dosimeter has been characterized in gamma, electron and bremsstrahlung radiation fields by measuring the optically stimulated luminescence (osl) at 530 nm both below and above 1 kGy, i.e. for disinfestation and for meat irradiation purposes. No humidity and no significant dose rate effect on the green osl signal was observed. The temperature coefficient was determined from 0°C up to about 40°C and to stabilize the osl signal after irradiation a heat treatment method was introduced. Based on these investigations the Sunna ‘gamma’ film is a suitable candidate for dose control below and above 1 kGy for food irradiation technologies.     

The role of gamma irradiation on the extraction of phenolic compounds in onion (Allium cepa L.)

The effect of gamma irradiation on the content of total phenolic compounds, especially quercetin (Q), in onion (Allium cepa L.) skin was investigated. Onion skin extracts contained two predominant flavonoid compounds, Q and quercetin-4′-glucoside (Q4′G). After 10 kGy gamma irradiation, the yield of Q in the extracts increased significantly from 36.8 to 153.9 μg/ml of the extract, and the Q4′G content decreased slightly from 165.0 to 134.1 μg/ml. In addition, the total phenolic compound content also increased after irradiation at 10 kGy, from 228.0 μg/g of fresh weight to 346.6 μg/g; negligible changes (237.1–256.7 μg/g) occurred at doses of up to 5 kGy. As we expected, radical-scavenging activity was enhanced remarkably (by 88.8%) in the 10 kGy irradiated sample. A dose-dependent increase in the peak intensity of the electron paramagnetic resonance (EPR) spectra was observed in all irradiated samples, with a maximum increase at 10 kGy. The intensity relative to that of the control was 0.15, and it increased to 1.10 in 10 kGy irradiated samples. The optimum gamma irradiation dose, which is sufficient to break the chemical or physical bonds and release soluble phenols of low molecular weight in onion skin, is about 10 kGy.     

Effects of gamma irradiation on the grape vine moth,Lobesia botrana,eggs

Eggs of the grape vine moth, Lobesia botrana (Denis and Schiffermuller), ranging in age from 1–24 to 73–96 h, were exposed, at 24 h intervals, to gamma radiation ranging from 25–600 Gy. The effects of gamma radiation on egg hatch, pupation, adult emergence, sex ratio and rate of development were examined. Results showed that the radiosensitivity of the grape vine moth eggs decreased with increasing age and increased with increasing radiation dose. Egg hatch in 1–24 h old eggs was significantly affected at 25 Gy and completely prevented at 100 Gy. At the age of 25–48 h, radiation sensitivity was only a little lower; egg hatch at 100 Gy was <1% and at 125 Gy no egg hatch was observed. Egg sensitivity to gamma irradiation decreased significantly in the 49–72 h age group; egg hatch was 66% at 100 Gy, and 500 Gy did not completely stop egg hatch (<1%). Eggs irradiated a few hours before egg hatch (73–96 h old) were the most resistant; 150 Gy had no significant effect on egg hatch and at 600 Gy over 33% of the eggs hatched. When pupation or adult emergence was used as a criterion for measuring effectiveness, however, the effects of gamma radiation were very severe. In the most resistant age group (73–96 h old), 150 Gy completely prevented pupation and adult emergence and all larvae resulting from eggs irradiated <49 h old died before pupation. In addition, the rate of development of immature stages resulting from irradiated eggs was negatively affected and sex ratio was skewed in favor of males.     

Gamma irradiation improves the antioxidant activity of Aloe vera (Aloe barbadensis miller) extracts

Aloe has been widely used in food products, pharmaceuticals, and cosmetics because of its aromatic and therapeutic properties. In the present study, the ethanolic extracts of aloe gel were gamma-irradiated from 10 to 100 kGy. After gamma irradiation, the color of the ethanolic extracts of aloe gel changed to red; this color persisted up to 40 kGy but disappeared above 50 kGy. Liquid chromatography/mass spectrometry analysis demonstrated the production of a new, unknown compound (m/z=132) after gamma irradiation of the ethanolic extracts of aloe gel. The amount of this unknown compound increased with increasing irradiation up to 80 kGy, and it was degraded at 100 kGy. Interestingly, it was found that gamma irradiation significantly increased the antioxidant activity, as measured by the 1,1-diphenyl-2-picrylhydrazyl-radical scavenging capacity. The antioxidant activity of aloe extract was dramatically increased from 53.9% in the non-irradiated sample to 92.8% in the sample irradiated at 40 kGy. This strong antioxidant activity was retained even at 100 kGy. These results indicate that gamma irradiation of aloe extract can enhance its antioxidant activity through the formation of a new compound. Based on these results, increased antioxidant activity of aloe extracts by gamma rays can be applied to various industries, especially cosmetics, foodstuffs, and pharmaceuticals.     

Evaluation of instant cup noodle,irradiated for immuno-compromised patients

In the present study, initial microbial load of instant cup noodle (ICN) was investigated and gamma irradiation applied to develop immuno-compromised patients food for their safe consumption. The initial microbial population of dried vegetable and meat, and noodle was below the detection limit (1 log CFU/g); however, that of seasoning powder was just above 4 log CFU/g. Moreover, rehydrated-ICN with water at 100 °C still show above 3 log CFU/g of microbial load, which indicates the need for an additional process to control microbial safety of the seasoning powder. The total aerobic bacteria in seasoning powder and rehydrated-ICN could be controlled with 17 kGy gamma irradiation. This result referred 17 kGy gamma irradiation could reach ‘practical sterility’ of ICN. The overall difference in sensory properties between the non-irradiated and irradiated ICN was insignificant. Thus, gamma irradiation could improve the microbial quality of ICN, and reduce the risk of infection posed by the seasoning powder, without any adverse effects on their sensory quality. These results suggest that gamma-irradiated ICN can be used as a snack food for immuno-compromised patients.     

Radiation-induced synthesis of low molecular weight of PTFE and their crosslinking in acetone medium

Polytetrafluoroethylene was obtained by radiation-induced polymerization of tetrafluoroethylene in acetone at 195 K. An average diameter of the products was very small compared with the commercial one; it was about 0.2 μm. The yield was reached to 100% with a dose of 4 kGy. The crystallinity of the products is decreasing with increasing dose. The crystallinity becomes low, for higher irradiation doses. It was found that PTFE obtained by irradiation of TFE in acetone at 195 K has Y-type crosslinking structure. This was demonstrated by means of ¹⁹F MAS NMR.     

Effect of post-irradiation thermal treatments on the stability of gamma-irradiated glass dosimeter

A commercial window glass has been investigated as a routine high dose dosimeter for gamma irradiation. The irradiated samples showed rapid fading at room temperature immediately after irradiation. This short-term rapid fading was followed by a slow fading at long-term. This strong initial fading is a problem for dosimetry purposes. However, when the dosimeter is measured at the same time interval after irradiation, it maintains proportionality to dose. Calibration curves have to be used for different time intervals after irradiation. In order to improve post-irradiation stability dosimeters were submitted to different post-irradiation thermal treatments from (−20) up to 150 °C. After that, optical absorbance measurements were carried out up to 2 months at room temperature. The heating at 150 °C for 20 min was found to be the most suitable procedure for the removal of unstable entities responsible for the initial rapid fading. Due to these heat treatments, variation of response was found almost negligible 24 h after irradiation for several months. Calibration curves demonstrated the applicability of this glass as routine dosimeter in the dose range of 0.5–90 kGy.     

Sensory evaluation by gamma radiation effect on protein allergen of laying hen eggs

Although considered the most complete food and nutritionally shown to be part of a healthy diet, the egg is the source of many eating disorders, especially for infants. Irradiation has been used in studies not only as a means of microbiological control, but also on its structural action in the substances molecules and has been used to reduce the allergenic effects. The aim of this study was to evaluate the sensory effects of Co⁶⁰ gamma radiation on proteins, enabling the acceptability of allergy food for genetically intolerant people. Eggs commercial fresh and freeze-dried and subjected to gamma irradiation by Co⁶⁰ source at doses 0 (control), 10 kGy; 20 kGy and 30 kGy and rates of doses of 19.4 kGy/h and 31.8 kGy/h. Acceptability test was used by the hedonic scale, since it is necessary to know the “affective status” of consumers for the product, implying a preference, i.e. the most preferred samples are the most accepted and vice versa. The samples were presented as the habit of consumption (cooked) to a group of 41 adults panelists of both gender, aged from 21 to 40 years, and served under complete block design balanced with respect to the order of presentation. The evaluated attributes was flavor, appearance and overall acceptability. In general, for boiled eggs and freeze-dried, it was observed that the control sample was the most acceptable, followed by the sample irradiated with 10 kGy in both dose rates. In addition, panelists presented in testimony that they found interesting changes due to irradiation; also said they would not buy the product because of the marked change in appearance and smell, which at one point he ended up in disgust and detract from sales of the product, but they would buy irradiated with 10 kGy in both dose rate and dose of 20 kGy at a dose rate of 19.4 kGy/h.     

Nutritional,physiological, physicochemical and sensory stability of gamma irradiated Kimchi (Korean fermented vegetables)

Effects of gamma irradiation on nutritional, physiological, physicochemical and sensory properties of the Korean lactic acid fermented vegetable, Kimchi, were investigated. The composition of amino acids and organic acids in Kimchi were not influenced by gamma irradiation less than 10 kGy. Angiotensine converting enzyme inhibitory, xanthin oxidase inhibitory, electron donating and antimicrobial activity of Kimchi extract were stable up to 10 kGy. There were no significant changes in pH and texture at less than 10 kGy. Color values were influenced at 10 kGy of gamma irradiation, and resulted in the increase of L*- and reduction of a*-value. About 90% of panelists identified a sensory difference between non-irradiated and 10 kGy-irradiated sample, and Kimchi irradiated at 10 kGy had lower scores in acceptability than those of the control or irradiated at 2.5 and 5 kGy.