Study of Dislocation Distribution in NaCl?NaBr and NaCl?CaCl2 Crystals Grown from Melt

Dislocation distribution and content have been studied using etch pit method in the single crystals of mixed solids NaCl NaBr and NaCl CaCl₂. In both the solid solutions the dislocation content is higher as compared to that in pure crystals of NaCl and NaBr grown under similar conditions. In mixed crystals of NaCl NaBr the block structure of subgrain boundaries is not observed. The subgrain boundaries are highly fragmentary and the dislocations form arrays running randomly to short distances. In NaCl crystals doped with CaCl₂ dislocation loops and impurity-decorated dislocations are observed. The dislocation content is higher in impurity segregated regions. The impurity decorates both isolated dislocations and subgrain boundaries in calcium-doped crystals. The results are discussed.     

Growth and etching of calcite crystals

Single crystals of calcite (CaCO₃) have been grown by the method employed by GRUZENSKY , using an aquoeus solution of CaCl₂ and a solid (NH₄)₂SO₃, The chemical reaction takes place according to the following equation: CaCl₂ + (NH₄)₂SO₃ CaCO₃ + 2 NH₄Cl The crystals grown by this method are about 0.2 to 0.8 mm in edge dimensions. Synthetic calcite crystals have been cleaved along (100) planes and the cleavage surfaces have been studied by multiple beam interferometry. The interferograms have revealed that the cleavages are quite flat. The cleavage faces have also been chemically etched and the etch patterns studied optically. By etching a cleavage successively for three different periods it was found that the bottoms of the point-bottomed pits follow a linear etch path. By etching a cleavage pair, one face in one etchant and the other face in a different etchant and by comparing the etch patterns produced, before and after polishing a cleavage face it has been shown that the etch pits nucleate at the sites of dislocations in the crystal. The etch patterns have also been compared with those produced on the cleavage faces of natural crystals. The density of dislocations in the syntheitc calctie crystals was generally less than the density of dislocations in the natural calcite crystals. The implications have been discussed.     

Semi-Batch Precipitation of Calcium Oxalate Monohydrate

Calcium oxalate monohydrate (COM) formation on the semi-batch precipitation of CaCl₂ and Na₂C₂O₄ solutions in the stoichiometric ratio carried out at pH = 6 and 37 or 70°C, respectively, was studied. When a certain level of supersaturation in the system is reached, individual COM crystals of a rather uniform size are formed. These crystals then grown and form ‘loose’ agglomerates that later develop into compact and spherical particles. The particle size distribution (PSD) rapidly shifts during early stages of precipitation towards larger sizes as a result of crystal growth and agglomeration. Later the PSD reaches a shape and position on the size axis that remain virtually constant with progressing precipitation. COM agglomerates consisting of mainly intergrown crystals are formed by mechanism of primary and secondary agglomeration. The primary agglomeration can constitute an important factor in urolithiasis.     

Growth of Single Crystals of Calcium Sulfite in Silica Gels

The paper reports on the growth of single crystals of calcium sulfite, CaSO₃ 0.5 H₂O, by reaction of aqueous solutions of CaCl₂ and Na₂SO₃ in silica gels. Na₂SO₃ incorporated gels give spherulites whereas CaCl₂ incorporated gels give transparent single crystals. The morphology of the crystals depends on the region of the gel and the type of reactant incorporated into the gel-forming solution. Initially formed precipitate and dendrites are converted into good quality single crystals by dissolution and recrystallization processes.     

Growth and characterization of Mn2+ doped calcium l‐tartrate crystals

Single crystals of Mn²⁺ doped calcium levo‐ tartrate tetrahydrate (CLTT) were grown by single diffusion gel growth technique in silica hydro‐gel media. The doping of Mn²⁺ was varied by mixing 0.001M, 0.005M, 0.01M, 0.05M, and 0.1M solutions of MnCl₂ with 1M CaCl₂ solution in equal volumes in the supernatant solutions. The actual amount of Mn²⁺ doping in CLTT crystals was estimated by ICP (Inductively Coupled Plasma) technique. The powder XRD of the samples suggested no significant change in the unit cell dimensions and the presence of any extra phase. The FT‐IR spectra indicated the presence of water molecule, O‐H bond, C‐O bond and carbonyl C=O bond. The EPR spectra confirmed the presence of Mn²⁺ ions in the crystals. The variation of the dielectric constant with temperature confirmed the earlier results of pure calcium tartrate crystals and indicated the ferroelectric nature of the doped crystals. As the amount of doping of Mn²⁺ increased the value of dielectric constant increased. The results are discussed. (© 2006 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Growth of calcium phosphate crystals in Silica gel

The results of a study of the crystal growth of calcium phosphates in silica gel employing double diffusion system with CaCl₂ and KH₂PO₄ aqueous solutions are reported. Liesegang rings, spherical crystalline agglomerates and brushite dendrites are formed near the CaCl₂ solution. It was found that the agglomerates consist of octacalcium phosphate and hydroxyapatite crystals with the predominance the former.     

Synthesis,growth, morphology and characterization of ferroelectric glycine phosphite single crystals

Glycine phosphite (NH₃CH₂COO.H₃PO₃), a potential ferroelectric material, was grown as single crystals from aqueous solutions by slow evaporation and slow cooling methods. Laboratory synthesized title compound was purified by recrystallization method and confirmed by Fourier transform infrared and Laser Raman studies. Temperature dependent solubility in double distilled water in the range between 288 and 328 K was determined by gravimetric method. Morphological importance of various growth faces were studied by optical goniometry. Powder x‐ray diffraction study performed on the grown crystals confirms the crystal system and lattice parameters of the unit cell. Optical transparency of the grown crystals in the ultraviolet–visible ‐near infrared region was studied by spectroscopic method. Thermal stability of the grown crystals in the temperature region above ambient until melting was studied using differential scanning calorimetry. (© 2011 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Crystal growth and investigation of CuAlxGa1−xTe2 solid solutions

Alloys of the CuGaTe₂‐CuAlTe₂ system have been synthesized by the one‐temperature method and homogenized by annealing. It was established for the first time by X‐ray and DTA methods that a continuous row of solid solutions is formed in the system. Large block crystals of CuAl_xGa_1−xTe₂ solid solutions have been grown by the Bridgman method (horizontal version). Measurements of density, microhardness and thermal expansion have been carried out on the grown crystals. It has been established, that the density and thermal expansion coefficients are changed linearly with composition, microhardness has a maximum at x = 0.6. (© 2004 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Elastic, piezoelectric, and dielectric properties of α-GeO2 single crystals

The elastic, piezoelectric, and dielectric characteristics of α-GeO₂ crystals are studied at room temperature. The measurements were performed by the resonance method on crystals grown on α-quartz seeds from solutions in the recirculating mode. In germanium dioxide crystals, the piezoelectric moduli have high values. The characteristic features of variations of the electromechanical and elastic properties in crystals with the quartzlike structure observed earlier are confirmed.     

Cover Picture: Cryst. Res. Technol. 10/2011

The cover picture shows gypsum crystals formed from (CaCl₂·2H₂O + Na₂SO₄) solutions. (see pages 1010–1018). (© 2011 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Study on rapid growth of KH2PO4 and its characterization

Large size crystals of KH₂PO₄ (KDP) were grown by adopting rapid growth technique from point seeds in a 1500‐liter crystallizer which is used to grow KDP crystals by conventional method. The grown KDP crystal size can reach to 310 × 310 × 320 mm³ and the average growth rate was 8mm/day. The optic properties of the rapidly grown KDP crystals were characterized comparing with the KDP crystals grown by the traditional temperature reduction method. We found it that the optical quality of the KDP crystals we grown rapidly are not significantly different from those of KDP crystals grown by traditional method. (© 2005 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Structural,optical and dielectric studies on K1‐x(NH4)xH2PO4 mixed crystals grown from z‐cut seeds

Mixed crystals of K_1‐x(NH₄)_xH₂PO₄(KADP) were grown from KDP (KH₂PO₄) dominated mixed solutions with varying molar proportion of ADP (NH₄H₂PO₄) addition. It was found that, as the increase of ADP molar concentration, the growth rate along z‐axis of KADP crystal decreased rapidly. The structure of KADP crystals was investigated by powder XRD and the lattice parameter was calculated. The results showed that the lattice parameter c of KADP crystal increased with the molar concentration of ADP. The optical homogeneity of grown KADP crystals was determined with a differential phase‐shifting interferometry. Frequency dependences of the dielectric constant and dielectric loss of KADP crystals were measured at room temperature (290 K). The dielectric constants of KADP crystals were almost invariant with the increase of frequency. In the region of 10²∼10⁴Hz, the values of the dielectric loss reduced with the increase of frequency. The piezo‐resonance coupling effect still exists in KADP crystals at room temperature, but shifted to low frequency band. (© 2010 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Physical Properties of K2ZnCl4

Large single crystals of orthorhombic K₂ZnCl₄ with optical quality have been grown by the Czochralski method. The elastic constants and their temperature and pressure derivatives have been determined from ultrasonic resonance frequencies of thick plates of different orientation and the shift of these frequencies induced by temperature and pressure changes, respectively. K₂ZnCl₄ shows a small elastic anisotropy. Measurement of the dielectric constant was made along the ferroelectric axis ε_a in the temperature from 303 K to 573 K. ε_a of K₂ZnCI₄ grown by the Czochralski-method shows a smaller thermal hysteresis at the incommensurate-commensurate transition point (403 K) than that of crystals grown from an aqueous solution. It explains that crystals grown by the Czochralski-method are more purified, the pinning effect is weakened. The thermal hysteresis occurs with the same width at 10 KHz, 100KHz, 1 MHz and 10 MHz.     

Growth rate of α-calcium sulfate hemihydrate in K–Ca–Mg–Cl–H2O systems at elevated temperature

Kinetics of calcium sulfate hemihydrate (HH) crystal growth plays an important role in mineralization of calcium sulfate phases in nature. HH crystal growth and the conversion of calcium sulfate phases form the basis for the production and application of gypsum based building material. α-HH crystals have been grown in 3.74 M CaCl₂ solutions at a fixed initial ratio of calcium to sulfate under atmospheric pressure. The variations of sulfate ions were determined to obtain the α-HH crystal growth kinetics information. Effects of Mg²⁺ and K⁺ ions on α-HH growth were investigated to find an optimal composition of solution for α-HH preparation. The orders of α-HH growing in the CaCl₂ solution were found, in most cases, to be near 2.0 in presence or in absence of Mg²⁺ and K⁺ ions. Mg²⁺ ions enhance the growth of α-HH in CaCl₂ solution mainly due to initial supersaturation enhancing effects. K⁺ ions also improve the growth rate, which has been attributed to the reduction of interfacial energy. In a Ca (3.74 M)–Mg (0.20 M)–K (0.09 M) chlorides solution, the growth rate of α-HH increases with temperature from 80 to 100 °C, and the activation energy was calculated to be 40 kJ/mol.     

Growth, structure, and properties of ferroelectric—ferroelastic— superionic K3Nb3B2O12 and K3−x NaxNb3B2O12 crystals

The potassium niobate-borate K₃Nb₃B₂O₁₂ (KNB) crystals and their solid solutions with partial substitution of potassium by sodium (KNB: Na) are grown from flux and their physical properties are studied. The specific feature of the crystals grown is a complicated polymorphism and the unique combination of ferroelectric and ferroelastic properties with superionic conductivity with respect to potassium ions.     

Compositional variation in 0.65 PbMg2/3Nb1/3O3 ‐0.35 PbTiO3 single crystals grown by high temperature solution growth technique

Single crystals of lead magnesium niobate titanate, 0.65 PbMg_2/3Nb_1/3O₃ (PMN) ‐0.35PbTiO₃ (PT) were grown using flux method near morphotropic phase boundary (MPB) composition. The crystals grown at the centre of the platinum crucible were found to PT deficient compared to those grown near the walls of the crucibles. A variation of ∼3.8 mol% in PT concentration was found in the crystals grown at the wall and at the centre of the crucible. The difference in the chemical composition of crystals grown at the centre and the near the wall of the crucible was observed by X‐ray diffraction, EDXRF, dielectric and thermal measurements. The presence of PT rich and deficient crystals is explained in terms of the segregation coefficient of PT in PMN. (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Effect of Pb on the properties of Sr2YRu1‐xCuxO6 crystals grown from PbO‐PbF2 solutions at high temperatures

Single crystals of Sr₂YRu_1‐xCu_xO₆ with x=0 and x=0.1 were grown using PbO‐PbF₂ based solutions at different temperatures in the range 1150–1350°C. The influence of Pb from the solutions and the Cu from the solid solutions of Sr₂YRu_1‐xCu_xO₆ on the resulting crystals was studied using microstructure and magnetic property measurements. The peaks in the powder X‐ray diffraction patterns and Raman spectra do not change in the case of x=0 crystals but shift in the presence of Cu. A diamagnetic transition indicative of superconductivity was observed in the presence of Cu and an antiferromagnetic behavior with x=0. Based on these results it is concluded that Pb may not be incorporated in the crystals and even if it does the influence is not observed. (© 2007 WILEY‐VCH Verlag GmbH & Co. KGaA, Weinheim)     

Effect of Mn(II) ions on the growth of ammonium oxalate monohydrate crystals from aqueous solutions: I. Growth habit and surface morphology

The effect of concentration of Mn(II) ions on the growth habit and the surface micromorphology of different as‐grown faces of ammonium oxalate monohydrate (AO) single crystals grown from aqueous solutions was studied at a constant temperature of 30 °C and predefined supersaturations up to 20%. It was observed that the growth habit and the surface morphology of the crystals strongly depend on the supersaturation used for growth and the impurity concentration in the solution. The experimental results were analysed in terms of connected nets determined from different projections of the structure of AO crystals. Analysis of the observations revealed that: (1) the directions of connected nets corresponding to basic growth units composed of single (NH₄)₂C₂O₄ · H₂O molecules are in excellent agreement with the low‐index crystallographic directions of the orientations of growth layers, (2) all faces appearing in the growth morphology of AO crystals are F faces, and (3) the {001} face growing from pure aqueous solutions is essentially a kinetically rough face but the presence of Mn(II) impurity leads to their appearance in the morphology due to increase in the strength of bonds of the connected nets composing the surface graph.     

Growth and properties of mixed K2Ni x Co1−x (SO4)2 · 6H2O crystals

Optically homogeneous mixed K₂Ni _x Co_{(1 ? x)}(SO₄)₂ · 6H₂O crystals are grown from solutions of different compositions by the temperature-reduction technique in static and dynamic regimes. The optical characteristics of the grown crystals are measured: transmittance reaches 80% in the wavelength range of 240–290 nm and no more than 9% in the visible spectral range. The thermal stability of the crystals is studied. It is established that the thermal stability of mixed K₂Ni _x Co_{1 ? x} (SO₄)₂ · 6H₂O crystals is higher than that of K₂Co(SO₄)₂ · 6H₂O crystal. The defects of the mixed crystals grown in static and dynamic regimes are investigated by X-ray topography.     

The defect structure of ammonium sulphate single crystals

The defect structure of larger ammonium sulphate crystals, grown from aqueous solutions, has been studied by means of X-ray diffraction topography after Lang's method. Several types of dislocations were identified. Moreover it was found that no relationship exists between growth rate and dislocation density, which implies that crystal growth proceeds via two-dimensional nucleation. No difference was found in the defect structure of crystals grown from pure water solutions and from aqueous solutions with 10 – 20% glycerine as additive: In both cases neither growth bands nor sector boundaries were found. On the other hand, crystals grown in aqueous solutions contaminated with Mn²⁺ and Fe³⁺ revealed growth bands and for Fe³⁺ a mosaic-like structure.