无机电解质及聚合物对Mg-Al混合金属氢氧化物—高岭土分散体系触变性的影响

类水滑石;流变学;无机电解质及聚合物对Mg-Al混合金属氢氧化物—高岭土分散体系触变性的影响     

Thixotropic properties of aqueous suspensions containing cationic starch and aluminum magnesium hydrotalcite-like compound

The rheological properties of aqueous suspensions consisting of cationic starch (CS) and positively charged aluminum magnesium hydrotalcite-like compound (HTlc) were investigated. Special emphasis was placed on the thixotropic phenomena. With the increase of mass ratio (R) of HTlc to CS, the equilibrium viscosity (eta(eq)) and the consistency coefficient (m) values of the suspensions increase in the range of neutral and alkaline pH (higher than 6.5) while decrease in the range of acid pH (lower than 6.5). With the increase of pH value, the eta(eq) and m values of the suspensions in the R range of 0-0.08 studied increase initially and then decrease, appearing a maximum value at about pH 7.41+/-0.25. The CS/HTlc suspensions display viscid character and the yield point of the suspensions was not observed except the suspension with R=0.08 in the pH range of 7.66-9.70, which showed a yield point and viscoelasticity. The CS/HTlc suspensions may display different thixotropic types: negative, complex or positive thixotropy, depending on pH and R value. The thixotropic type of the CS/HTlc suspension may be transformed from negative (pure CS solution), through complex (R=0.02), into positive thixotropy (R=0.05 and 0.08) with the increase of R in the studied R range of 0-0.08, and the thixotropic strength of the suspensions increases initially and then decreases with pH value in the pH range studied. The mechanism of the thixotropic phenomenon is discussed.     

Fe-Al-Mg-MMH/钠质蒙脱土分散体系触变性研究

研究了Fe-Al-Mg型混合金属氢氧化物(简称MMH)/钠质蒙脱土(简称MT)分散体系的触变性,发现在不同MMH/MT质量比(R)条件下,分散体系可分别呈现正触变性和负触变性.在所研究的R范围(0～0.091)内,随R增大,体系的触变性发生正触变性-复合触变性-负触变性的转化.考察了高速剪切分散后,测定粘度变化前的静置时间(ts)和测定粘度时的剪切速率(DL)对触变性的影响.探讨了各种触变性产生的原因,提出了“分散粒子-空间连续网络结构-密实聚集体”和“分散粒子-密实聚集体-密实聚集体簇”机理,较合理地解释了观察到的复合触变现象.     

Mg-Fe-MMH-钠质蒙脱土分散体系的触变性研究

触变性是分散体系一种复杂的流变学性质,指流变性质随剪切时间而发生变化的现象。以往研究过程中,先后发现了切稀现象和切稠现象,即正触变性和负触变性。最近,我们又发现了复合触变性,即一个体系可先后呈现正触变性和负触变性特征。研究了Mg-Fe型混合金属氢氧化物(简称MMH)-钠质蒙脱土(简称MT)分散体系的触变性,发现在不同MMH/MT质量比条件下,可分别呈现正触变性、负触变性,另外双观察到了复合触变性。在所研究的MMH/MT质量比范围(0～0.5)内,随MMH/MT质量比增大,体系的触变性发生负触变性-正触变性-复合触变性-负触变性的转化。考察了电解质NaCl对触变性的影响,发现不改变触变性的类型。探讨了各种触变性产生的原因,提出了“分散粒子-空间连续网络结构-密实聚集体”机理,较合理地解释了观察到的复合触变现象。     

剪切速率对Fe-Al-Mg-MMH/钠质蒙脱土悬浮体触变性的影响

研究了测定条件对Fe-Al-Mg型混合金属氢氧化物（简称MMH）/钠质蒙脱土（简 称MT）混合悬浮体及纯MT体系触变性的影响，主要考察了高速剪切分散后，剪切速 率（D_L）对粘度（η）～时间（t）变化趋势的影响。发现纯的MT体系和MMH/MT质 量比（R）为0.013的Fe-Al-Mg-MMH/MT体系在所研究的D_L下（10，170，511和1 022 s~(-1)）都呈现为正触变性，D_L不影响触变性类型。R = 0.051的体系，低 D_L时（10和170 s~(-1)）呈现复合触变性，高D_L时（511和1 022 s~(-1)）呈现 正触变性；R = 0.091的体系在低D_L时（10和170 s~(-1)）呈现负触变性，在高 D_L时（511和1 022 s~(-1)）呈现复合触变性。D_L增加，各体系η逐渐降低。对 D_L影响触变性的机理进行了深入探讨。     

Mg-Al-MMH-高岭土分散体系触变性研究

触变性是分散体系流变学研究的重要内容之一,在外切力作用下,若体系的粘度随时间下降,静止后又恢复,即具有时间因素的切稀现象,称为正触变性（positive thixotropy);反之,若体系的粘度或切力上升,静止后又恢复,即具有时间因素的切稠现象,称之为负触变性（Negative thixotropy)^[1],若在外切力作用下,某个特定体系的粘度或切力随时间先后呈现出正触变性和负触变性特征,则称之为复合触变性（Complex thixotropy)^[2,3],目前,对各种触变性机理的认识尚不统一。     

羧甲基纤维素钠/蒙脱土悬浮体系的流变性能及其影响因素

考察了蒙脱土(MT)质量分数(w)、羧甲基纤维素钠(CMC)/MT质量比(R)、电解质(NaCl、MgCl2和AlCl3)、pH值和温度对MT或CMC/MT悬浮体系流变性能和触变性的影响。 结果表明,随w增加,纯MT悬浮体系的流体类型由近牛顿流体向塑型流体变化,触变类型则由无触变、正触变向复合触变性转变;而CMC/MT悬浮体系仍保持MT体系的正触变塑型流体特征,但屈服值τ0和稠度指数K增加,滞后环面积S和电动电势|ζ|先增加后减小,表现出同步变化。 电解质和实验温度均不改变CMC/MT悬浮体系的正触变性塑型流体特征,但电解质使τ0和K增加,而温度增加使τ0和K减小。 随介质pH值的增加,CMC/MT体系由负触变性变为正触变性,|ζ|增大,S先增加后减小,且在pH=8.46时达到最大。     

Influence of Electrolytes on the Thixotropy of Ferric Aluminum Magnesium Hydroxide‐Montmorillonite Suspensions

Abstract

The thixotropy of suspensions consisting of ferric aluminum magnesium hydroxide (Fe‐Al‐Mg‐MMH) and Na‐montmorillonite (MT) is examined with special emphasis on the influence of electrolytes. When NaCl or MgCl₂ is added into the Fe‐Al‐Mg‐MMH/MT suspension, the thixotropy of the suspension may change (if positive) from positive and complex into negative, but NaCl or MgCl₂ can't alter the thixotropic type of a negatively thixotropic suspension. When AlCl₃ was added to positive thixotropic system can be transformed to a complex one, whereas a complex and negative thixotropic suspension remains unchanged, for additions less than 0.01 mol/L; when the addition level of AlCl₃ increases, all types of thixotropic systems are changed to non‐thixotropic. In addition, NaCl and MgCl₂ make the initial viscosity measured after cessation of intensive shearing increase, but the value of the viscosity decreased rapidly with time. The equilibrium viscosity of the suspension decreased gradually with increasing concentrations of NaCl and MgCl₂ in the suspension. With increasing concentration of AlCl₃, the equilibrium viscosities of the positive thixotropic suspension and the complex thixotropic suspension increase at first, but decrease later, and the equilibrium viscosity of negative thixotropic suspensions decrease gradually.     

Effect of Electrolytes and Polymers on the Thixotropy of Mg‐Al‐Layered Double Hydroxides/Kaolinite Dispersions

The effect of electrolytes (NaCl and CaCl₂) and polymers (CPAM and HPAM) on the thixotropy of Mg‐Al‐layered double hydroxide (LDHs)/kaolinite dispersions has been investigated. It was observed that the type of thixotropy in LDH/kaolinite dispersions may be affected by NaCl, but not by CaCl₂ in range of concentration of interest. The type of thixotropy in LDH/kaolinite dispersion with R=0 transformed from positive thixotropy to complex thixotropy and at last positive thixotropy again with the concentration of NaCl in range of 0.00–0.10 mol·L⁻¹; the type of thixotropy in LDHs/kaolinite dispersions with R=0.25 transformed from complex thixotropy to positive thixotropy and then complex thixotropy again with the concentration of NaCl in range of 0.00–0.10 mol·L⁻¹. The type of thixotropy in LDH/kaolinite dispersion with R=0 may be not affected by cationic polyacrylamide (CPAM) and hydrolyzed polyacrylamide (HPAM); but the LDHs/kaolinite dispersions with R=0.25 transformed from complex thixotropy to positive thixotropy with the both polymers concentration in range of interest, which indicated that the microstructure of the dispersion changed from weak folc sediments structure to steric network structure.     

Thixotropy of Aqueous Suspensions Containing Mg‐Al Hydrotalcite‐like Compound and Low‐substituted Cationic Starch: Comparison between Oscillatory Shear and Thixotropic Loop Measurements

The rheological properties of aqueous suspensions consisting of positively charged aluminum magnesium hydrotalcite‐like compound (HTlc) and low‐substituted cationic starch (LCS) were investigated. Special emphasis was placed on the thixotropic phenomenon. Thixotropic behavior was investigated by two thixotropic methods: thixotropic loop and oscillatory shear measurements. LCS molecules could be adsorbed onto HTlc particles due to the hydrogen bonding between ether groups or hydroxyl groups of LCS and hydroxyl groups of HTlc. The elastic dynamic response of the HTlc/LCS suspension increased with increasing mass ratio (R) of HTlc and a three‐dimensional network structure could be formed in the suspension with higher R value. The thixotropic type of the HTlc/LCS suspension transformed from negative to positive and then to complex thixotropy when R changed from 0 to 0.5. By comparing between the thixotropic results obtained by thixotropic loop and oscillatory shear measurements, it was validated that the thixotropic loop for the suspension showing complex thixotropy had a crossover point.     

Thixotropic Behavior of Hydrotalcite-Like Compound/Cationic Starch Suspensions: Effects of Mass Ratio of Hydrotalcite-Like Compound to Cationic Starch,Electrolyte, and Temperature

The thixotropic behavior of Mg-Al hydrotalcite-like compound (HTlc)/cationic starch (CS) suspensions was investigated as a function of the mass ratio (> 0.08) of HTlc to CS, the electrolyte and the temperature, respectively. The thixotropy was studied by monitoring viscosity (η) change during the recovery process as a function of time (t) after the cessation of intensive shear. The results showed that the strength of negative thixotropy of the CS solution decreased with the increasing of electrolyte (NaCl, CaCl₂, or AlCl₃) concentration and the temperature. The thixotropic type of the HTlc/CS suspensions could transform from negative to complex, positive, complex, and then to negative thixotropy with the increasing of HTlc content if CS was the main component of the suspensions. In addition, the thixotropic type of the HTlc/CS suspensions transformed from original type to positive thixotropy with the increasing of electrolyte concentration and the temperature.     

盐酸胍/Ⅰ型胶原分散体系的流变性

采用胃蛋白酶降解法从猪皮中提取了胶原蛋白,用十二烷基硫酸钠-聚丙烯酰胺凝胶电泳(SDSPAGE)确定为Ⅰ型胶原;红外及紫外光谱表明胶原分子中存在三螺旋结构.分别采用小幅振荡剪切法、恒定剪切速率法及滞后环法研究了盐酸胍浓度及作用时间对Ⅰ型胶原蛋白体系流变性的影响.研究表明,随盐酸胍浓度的增大及作用时间的延长,盐酸胍/胶原分散体系由假塑性流体逐渐接近于牛顿流体.在所研究的盐酸胍浓度范围(0~6.0 mol/L)内,盐酸胍/胶原分散体系的触变性类型随盐酸胍浓度的增大发生正触变性-复合触变性-负触变性的转变;随盐酸胍作用时间的延长(6~48 h),盐酸胍浓度为1.0 mol/L的胶原分散体系的触变性类型发生复合触变性-负触变性的转变.本文的研究结果有助于加深对触变性产生机理的认识.     

Study on the thixotropy of aluminum magnesium hydroxide– Na-montmorillonite suspension

 In this paper, the thixotropy of the aqueous suspension consisting of aluminum magnesium hydroxide (AMH) possessing permanent positive charges and Na-montmorillonite possessing permanent negative charges was studied. Besides positive thixotropy and negative thixotropy, a novel thixotropic phenomenon was found, i.e., a given system studied may display, early and late, positive M28.8nthixotropic character and negative thixotropic character, we describe it as “complex thixotropy”. The content of the suspension and electrolyte may influence the forms of thixotropy of the suspension studied. Received: 4 February 1997 Accepted: 15 October 1997     

pH值对Fe-Al-Mg-MMH/钠质蒙脱土悬浮体触变性的影响

研究了pH值对Fe-Al-Mg型混合金属氢氧化物／钠质蒙脱土（简称MMH／MT）悬浮体触变性的影响。发现pH值能影响其触变性类型：m(MMH)/m(MT)(下文中以R表示）较低时（0，0．013和0．051），随着pH增高，体系有由负触变性－复合触变性－正触谱性转变的趋势；而R较高的体系（R＝0．091），随pH的增高，体系由复合触变性向负触变性转化。探讨了各种触变性产生的原因和pH的影响机理。     

盐酸胍/Ⅰ型胶原分散体系的流变性

采用胃蛋白酶降解法从猪皮中提取了胶原蛋白, 用十二烷基硫酸钠-聚丙烯酰胺凝胶电泳(SDS-PAGE)确定为Ⅰ型胶原; 红外及紫外光谱表明胶原分子中存在三螺旋结构. 分别采用小幅振荡剪切法、 恒定剪切速率法及滞后环法研究了盐酸胍浓度及作用时间对Ⅰ型胶原蛋白体系流变性的影响. 研究表明, 随盐酸胍浓度的增大及作用时间的延长, 盐酸胍/胶原分散体系由假塑性流体逐渐接近于牛顿流体. 在所研究的盐酸胍浓度范围(0~6.0 mol/L)内, 盐酸胍/胶原分散体系的触变性类型随盐酸胍浓度的增大发生正触变性-复合触变性-负触变性的转变; 随盐酸胍作用时间的延长(6~48 h), 盐酸胍浓度为1.0 mol/L的胶原分散体系的触变性类型发生复合触变性-负触变性的转变. 本文的研究结果有助于加深对触变性产生机理的认识.     

超细改性碳酸钙浓悬浮体的正负触变性

以超细改性碳酸钙、氧化钙、邻苯二甲酸二辛脂组成的浓悬浮体为对象,用触变性和屈服应力来探测悬浮体的内部结构,结合悬浮体的分散稳定性能,讨论了正负触变性的形成、稳定性和可逆转变及触变性结构的强度,并考察了游离脂肪酸对悬浮体正负触变性转化的影响.     

Influence of Mg2+ Contents on the Thixotropy of HTlc/MT Suspensions

In this article, we found that the variation of Mg²⁺ content in the Fe-Al-Mg hydrotalcite-like compounds (HTlc) and the change of R values (R_defined = W_HTlc /W_MT) will influence the thixotropic and viscoelastic properties of HTlc/sodium montmorillonite (MT) suspensions. With increasing the content of Mg²⁺ in the HTlc samples, the storage modulus (G′) and the loss modulus (G″) of the HTlc/MT suspensions will increase gradually, which means the structure strength of the HTlc/MT suspension increases with increasing of Mg²⁺ content in the HTlc samples. In addition, the structure strength of the suspensions will increase with increasing of R values. Special emphasis has been laid on the phenomenon of thixotropy. As the gradual increase of the structure strength in the HTlc/MT suspension, the thixotropic types will change accordingly. The mechanism has been discussed emphatically.     

钠型蒙脱土悬浮体和水解聚丙烯酰胺体系的负触变现象

由钠型蒙脱土悬 浮体和水解聚丙烯酰胺组成的体系有负触变现象, 对负触变性的形成条件和影响因素作了初步探讨. 并对微观结构作了一些推测.     

十二烷基磺酸插层类水滑石的制备及其对烟嘧磺隆油悬浮剂流变性的影响

以Mg-Al类水滑石为前体,制备了疏水的十二烷基磺酸插层类水滑石（DSO-LDHs）,对其结构进行了光学显微镜、XRD和红外光谱表征。 结果表明,十二烷基磺酸钠成功插入到Mg-Al类水滑石层间。 DSO-LDHs作为触变材料应用于4%烟嘧磺隆油悬浮剂时,流变学研究结果表明,农药颗粒通过静电作用附着在DSO-LDHs特殊的薄片层结构中。 随着DSO-LDHs添加量的增加,油悬浮体系呈正触变性,且体系的屈服值增大,而析油率下降。     

Particle interactions in kaolinite suspensions and corresponding aggregate structures

The surface charge densities of the silica face surface and the alumina face surface of kaolinite particles, recently determined from surface force measurements using atomic force microscopy, show a distinct dependence on the pH of the system. The silica face was found to be negatively charged at pH>4, whereas the alumina face surface was found to be positively charged at pH<6, and negatively charged at pH>8. The surface charge densities of the silica face and the alumina face were utilized in this study to determine the interaction energies between different surfaces of kaolinite particles. Results indicate that the silica face-alumina face interaction is dominant for kaolinite particle aggregation at low pH. This face-face association increases the stacking of kaolinite layers, and thereby promotes the edge-face (edge-silica face and edge-alumina face) and face-face (silica face-alumina face) associations with increasing pH, and hence the maximum shear-yield stress at pH 5-5.5. With further increase in pH, the face-face and edge-face association decreases due to increasing surface charge density on the silica face and the edge surfaces, and decreasing surface charge density on the alumina face. At high pH, all kaolinite surfaces become negatively charged, kaolinite particles are dispersed, and the suspension is stabilized. The face-face association at low pH has been confirmed from cryo-SEM images of kaolinite aggregates taken from suspension which show that the particles are mostly organized in a face-face and edge-face manner. At higher pH conditions, the cryo-SEM images of the kaolinite aggregates reveal a lower degree of consolidation and the edge-edge association is evident.