直流磁控溅射制备氧化钒薄膜

讨论了在低温下以高纯金属钒作靶材,用直流磁控溅射的方法制备出了氧化钒薄膜。通过设计正交试验,分析了氩气和氧气的流量比,溅射功率,工作压强,基底温度对氧化钒薄膜沉积速率和电阻温度系数TCR的影响,采用RTP-500型快速热处理机对氧化钒薄膜样品进行了退火热处理,实验结果表明:当Ar与O2的比例为100:4,溅射功率为120W,工作压强为2Pa时,所获得薄膜TCR较大,都在-2%/K附近,最高的可达-3.6%/K。     

基片温度与氧分压对磁控溅射制备氧化钒薄膜的影响

采用磁控溅射工艺制备了V₂O₅薄膜.通过改变制备工艺中基片温度和氧分压两个条件，研究了薄膜的晶相组成、表观形貌以及氧化物中钒和氧元素的化合价态.当基片温度升高时，V₂O₅薄膜中颗粒结晶由细长针状转变为平行于基片的片状，V⁵⁺状态保持不变，但723 K时氧结合能向高键能态移动.氧分压较低时，薄膜表面有部分V⁴⁺态存在，但存在较多的高键能氧，此时薄膜中晶粒尺寸较小.随着氧分压的提 关键词： 氧化钒 磁控溅射 相变薄膜 X射线光电子能谱     

快速热处理制备相变氧化钒薄膜及其特性研究

采用直流对靶磁控溅射在Si<100>基底上沉积金属V薄膜, 然后分别在纯氧气环境和纯氮气环境下进行快速热处理制备具有 金属-半导体相变特性的氧化钒(VO_X)薄膜, 热处理条件分别为纯氧气环境下430℃/40 s, 450℃/40 s, 470℃/40 s, 450℃/30 s, 450℃/50 s, 纯氮气环境下500℃/15 s. 用X射线衍射仪、X射线光电子能谱、原子力显微镜 和扫描电子显微镜对薄膜的结晶结构、钒的价态和组分以及微观形貌进行分析. 利用四探针薄膜电阻测量方法和THz时域频谱技术分析薄膜的电学特性和光学特性. 结果表明: 金属V薄膜经过纯氧气环境450℃/40 s快速热处理 后形成了具有低相变特性的VO_X薄膜, 升温前后薄膜方块电阻变化幅度达到两个数量级, THz透射强度变化幅度较小. 为了提高薄膜的相变特性, 对制备的VO_X薄膜采用纯氮气环境500℃/15 s快速热处理, 薄膜的相变特性有了明显提升, 相变前后方块电阻变化达到3个数量级, THz透射强度变化达到56.33%.     

氧化钒薄膜微观结构的研究

采用直流磁控反应溅射在Si(100)衬底上溅射得到(001)取向的V₂O₅薄膜.x射线衍射(XRD)、扫描电镜(SEM)和傅里叶变换红外光谱(FTIR)的结果表明，氧分压影响薄膜的成分和生长取向，在氧分压0.4Pa时溅射得到(001)取向的纳米V₂O₅薄膜，即沿c轴垂直衬底方向取向生长的薄膜.V₂O₅薄膜经过真空退火得到(001)取向的VO₂薄膜，晶体颗 关键词： 微观结构 氧化钒薄膜 择优取向 直流磁控溅射     

二氧化钒薄膜的低温制备及其性能研究

针对VO₂薄膜在微测辐射热计上的应用，采用射频反应溅射法，在室温下制备氧化钒薄膜；研究了氧分压对薄膜沉积速率、电学性质及成分的影响.通过调节氧分压，先获得成分接近VO₂的非晶化薄膜，再在400℃空气中氧化退火，便可制得高电阻温度系数，低电阻率的VO₂薄膜，电阻温度系数约为-4%/℃，薄膜方块电阻为R_□为100—300kΩ；薄膜在室温下沉积，400℃下退火的制备方法与微机电加工(micro electromechanic 关键词： 二氧化钒 电阻温度系数 氧分压 射频反应溅射法     

射频磁控溅射法制备ZnS多晶薄膜及其性质

实验采用射频磁控溅射法在玻璃衬底上沉积了ZnS多晶薄膜,研究了沉积气压、退火温度和衬底温度对ZnS薄膜质量的影响.利用X射线衍射(XRD)分析了薄膜的微结构,并计算了内应力值.通过紫外-可见光分光光度计测量了薄膜的透过谱,计算了Urbach能量和禁带宽度.利用扫描电子显微镜(SEM)观察了薄膜的表面形貌.结果表明: 衬底温度为室温时沉积的ZnS薄膜具有较大的压应力,并且内应力值随着工作气压增大而增大,在300 ℃下进行退火处理后内应力松弛,衬底温度为350 ℃时制备的ZnS薄膜内应力小,透过率高,经300 ℃退火处理后结晶质量有所提高. 关键词： ZnS薄膜 射频磁控溅射 内应力     

射频磁控溅射法制备ZnO薄膜的发光特性

利用射频磁控溅射法在硅衬底上制备出具有（002）择优取向的氧化锌薄膜，用波长为300nm的光激发，观察到在446nm处有一强的光致发光峰，它来自于氧空位浅施主能级上的电子到价带上的跃迁。并讨论了发光峰与氧压的关系以及退火对它的影响，且给出了解释。     

磁控溅射法制备二氧化钒薄膜最佳参量的研究

用X射线电子能谱仪(XPS)对不同条件下用磁控溅射法制备的VO₂薄膜进行测试,得到VO₂薄膜内部组成成份的信息.研究了获得高含量VO₂薄膜的最佳制备参量.同时还观察到V₂O₃、VO₂、V₂O₅以接近含量共存的现象,这与以前研究所给出的薄膜几乎只由V₂O₃、VO₂、V₂O₅中的两种组成的结论有所不同.     

氧化钒薄膜的微结构及阻变特性研究

采用射频反应溅射法于室温下在Cu/Ti/SiO₂/Si基底上制备了氧化钒薄膜. X-射线衍射、X射线光电子能谱分析仪及原子力显微镜结果表明, 室温下制备的氧化钒薄膜除微弱的V₂O₅ (101)和V₂O₃ (110)峰外, 没有明显的结晶取向, 是VO₂, V₂O₅, V₂O₃及VO的混合相薄膜, 且薄膜表面颗粒大小均匀, 表面均方根粗糙度约为1 nm. 采用半导体参数分析仪对薄膜的电开关特性进行测试. 结果表明薄膜具有较低的开关电压(V_Set<1 V, V_Reset<-0.5 V), 并且具有稳定的可逆开关特性. 薄膜从低阻态转变为高阻态的电流(I_Reset)随限流的增大而增大.通过高低阻态时I-V对数曲线的拟合(高阻态斜率>1, 低阻态斜率=1), 认为Cu离子在薄膜中扩散形成的导电细丝是该体系发生电阻转变的主要机制. 关键词： 氧化钒薄膜 电阻开关 电阻式非挥发存储器 导电细丝     

Characteristics of ZnO:In thin films prepared by RF magnetron sputtering

In-doped ZnO (ZnO:In) transparent conductive thin films were deposited on glass substrates by RF magnetron sputtering. The effect of substrate temperature on the structural, electrical and optical properties of the ZnO:In thin films was investigated. It was found that higher temperature improves the crystallinity of the films and promotes In substitution easily. ZnO:In thin films with the best crystal quality were fabricated at 300 °C, which exhibit a larger grain size of 29 nm and small tensile strain of 0.9%. The transmittance of all the films was revealed to be over 85% in the visible range independence of the substrate temperatures and the lowest resistivity of ZnO:In thin films is 2.4×10⁻³ Ω cm.     

Surface oxidation of vanadium dioxide films prepared by radio frequency magnetron sputtering

This paper reports that the thermochromic vanadium dioxide films were deposited on various transparent substrates by radio frequency magnetron sputtering, and then aged under circumstance for years. Samples were characterized with several different techniques such as x-ray diffraction, x-ray photoelectron spectroscopy, and Raman, when they were fresh from sputter chamber and aged after years, respectively, in order to determine their structure and composition. It finds that a small amount of sodium occurred on the surface of vanadium dioxide films, which was probably due to sodium ion diffusion from soda-lime glass when sputtering was performed at high substrate temperature. It also finds that aging for years significantly affected the nonstoichiometry of vanadium dioxide films, thus inducing much change in Raman modes.     

外加磁场对射频磁控溅射制备铝掺杂氧化锌薄膜影响的研究

利用射频磁控溅射法制备了铝掺杂氧化锌(AZO)透明导电薄膜,在传统的磁控溅射系统中引入外加磁场,研究了外加磁场对AZO薄膜沉积速率、形貌结构及光电特性的影响.研究结果表明,外加磁场后薄膜的沉积速率从不加磁场的13.04 nm/min提高到了19.93 nm/min;外加磁场后薄膜表面平整致密、颗粒大小均匀,结晶质量较高,而不加磁场薄膜表面形貌呈蠕虫状,薄膜质量较差.溅射时间为90 min时,外加磁场前后AZO薄膜方阻分别为30.74?/和12.88?/.外加磁场对薄膜可见光透过率影响不大,但使薄膜的吸收边蓝移现象更明显.运用ansys软件对磁控溅射二维磁场分布模拟后发现,外加磁场提高了靶上方横向磁场强度,改善了磁场分布的均匀性,加强了磁场对电子的磁控作用,提高了靶电流,是AZO薄膜的溅射速率、光电性能和形貌结构得到提高和优化的原因.     

Violet and blue-green luminescence from Ti-doped ZnO films deposited by RF reactive magnetron sputtering

Pure and Ti-doped zinc oxide (TZO) films are deposited using radio frequency (RF) reactive magnetron sputtering at different RF powers. Micro-structural and optical properties in doped ZnO films are systematically investigated by X-ray diffraction (XRD), atomic force microscopy (AFM), scanning electronic microscopy (SEM), and a fluorescence spectrophotometer. The results indicate that ZnO films show stronger preferred orientation toward the c$c$-axis and smoother surface roughness after Ti doping. As for TZO films, the full width at half maxima (FWHM) of (002) diffraction peaks decreased first and then increased, reaching a minimum of about 0.92° at 150 W, while the residual compressive stress of the TZO film prepared at 150 W became the largest. The photoluminescent (PL) spectra measured at room temperature reveal a violet, a blue and two green emissions. Intense violet and blue-green luminescence is obtained for the sample deposited at higher RF power. The origin of these emissions is discussed.     

Structural and electrical properties of fluorine-doped zinc tin oxide thin films prepared by radio-frequency magnetron sputtering

Transparent and conductive thin films of fluorine doped zinc tin oxide (FZTO) were deposited on glass substrates by radio-frequency (RF) magnetron sputtering using a 30 wt% ZnO with 70 wt% SnO₂ ceramic targets. The F-doping was carried out by introducing a mixed gas of pure Ar, CF₄, and O₂ forming gas into the sputtering chamber while sputtering ZTO target. The effect of annealing temperature on the structural, electrical and optical performances of FZTO thin films has been studied. FZTO thin film annealed at 600 °C shows the decrease in resistivity 5.47 × 10⁻³ Ω cm, carrier concentration ∼10¹⁹ cm⁻³, mobility ∼20 cm² V⁻¹ s⁻¹ and an increase in optical band gap from 3.41 to 3.60 eV with increasing the annealing temperatures which is well explained by Burstein–Moss effect. The optical transmittance of FZTO films was higher than 80% in all specimens. Work function (ϕ) of the FZTO films increase from 3.80 eV to 4.10 eV through annealing and are largely dependent on the amounts of incorporated F. FZTO is a possible potential transparent conducting oxide (TCO) alternative for application in optoelectronics.     

非平衡磁控溅射法类金刚石薄膜的制备及分析

利用非平衡磁控溅射物理气相沉积技术制备了光滑、致密、均匀的类金刚石薄膜.分析沉积工艺参数对所得类金刚石薄膜的电学特性的影响以及溅射粒子的大小、能量、碰撞及沉积过程中的相变机理后认为：溅射粒子越小、与环境气体分子的碰撞次数越多、与衬底相互作用时具有适当动量等，能够有效提高薄膜中sp^３杂化碳原子的含量.利用拉曼光谱 、纳米力学探针、红外光谱、扫描电镜等分析了所得类金刚石膜的结构、力学及光学性能、 表面形貌等特征.结果表明，类金刚石膜中sp^３杂化碳原子的含量较高，显微硬 度大于11GPa，薄膜光学透过率达到89.4％，折射系数为1.952，沉积速率为0.724μm/h，表 面光滑、致密、均匀，不存在明显的晶粒特征. 关键词： 非平衡磁控溅射 类金刚石膜 拉曼光谱 红外光谱     

磁控溅镀法制备Al掺杂ZnO薄膜的特性分析

以射频磁控溅镀法在柔性聚碳酸酯基板上成长Al掺杂ZnO薄膜,利用XRD、AES、霍尔效应测试仪及单色分光计测量分析Al靶功率对薄膜光电特性的影响. XRD分析表明所有薄膜的衍射峰皆以(002)面为主,Al靶功率为25 W时(002)面衍射峰强度最大,此时薄膜结晶性最佳; AES分析表明随着Al靶功率的增大,Al含量由0 at.%增至18.01 at.%,Zn含量则由72.51 at.%降至38.39 at.%,而O含量没有太大变化,这说明Al可以取代ZnO中Zn的位置;霍尔效应测量表明Al靶功率为25 W时电阻率最小,约为7.75×10~(-4)Ω·cm,而载子浓度及其迁移率则达到最大,分别约为9.35×10~(20) cm~(-3)与8.64 cm~2/(V·s);分光计测量表明薄膜在可见光区的平均透射率可约达90%以上,说明本研究制备的Al掺杂ZnO薄膜是具有高透射率的透明导电薄膜.     

Study of nanocrystalline V02 thin films prepared by magnetron sputtering and post-oxidation

Nanocrystalline VO2 thin films were deposited onto glass slides by direct current magnetron sputtering and postoxidation. These films undergo semiconductor-metal transition at 70 ℃, accompanied by a resistance drop of two magnitude orders. The crystal structures and surface morphologies of the VO2 films were characterized by x-ray diffraction （XRD） and atomic force microscope （AFM）, respectively. Results reveal that the average grain size of VO2 nanograins measured by XRD is smaller than those measured by AFM. In addition, Raman characterization indicates that stoichiometric VO2 and oxygen-rich VO2 phases coexist in the films, which is supported by x-ray photoelectron spectroscopy （XPS） results. Finally, the optical properties of the VO2 films in UV-visible range were also evaluated. The optical band gap corresponding to 2p-3d inter-band transition was deduced according to the transmission and reflection spectra. And the deduced value, Eopt2p-3d ： 1.81 eV, is in good agreement with that previously obtained by theoretical calculation.