超高效液相色谱-四极杆/静电场轨道阱高分辨质谱快速精准测定粮食中多种真菌毒素

采用直接提取稀释的快速前处理方法,结合稳定同位素稀释技术,利用超高效液相色谱-四极杆/静电场轨道阱高分辨质谱,建立了粮食中16种真菌毒素的快速精准分析方法。样品采用乙腈-水-乙酸溶液(70∶29∶1,体积比)提取,以C18色谱柱进行色谱分离,通过全扫描模式进行定量检测,并采用稳定同位素稀释以减少基质效应对定量分析的影响。结果表明,16种真菌毒素在一定浓度范围内均具有良好的线性关系,相关系数(r2)均大于0.999,4种常见粮食基质(小麦、玉米、大米、大麦)的限量浓度水平的加标回收率(n=6)为75.3%~123.5%,相对标准偏差为0.41%~14.7%。该方法简单、准确,适用于粮食中真菌毒素的检测,可满足日常监测工作的需要。     

Evaluation of matrix solid-phase dispersion (MSPD) extraction for multi-mycotoxin determination in different flours using LC-MS/MS

An existing matrix solid-phase dispersion (MSPD) method for aflatoxins (AFs) and ochratoxin A (OTA) extraction was extended by further 14 mycotoxins. After it careful optimization, this method was applied to determine the occurrence of these mycotoxins on commercial flour samples (with different cereals composition) collected from local markets. In a total of 49 samples investigated, 9 mycotoxins were identified. Nivalenol (NIV) and Beauvericin (BEA) were the mycotoxins found most frequently. The samples that presented major contamination were wheat flours and bakery preparations. Despite of the great number of positives finding, only one wheat flour sample exceeded the maximum limits (ML) for OTA established by the European Union (EU). However, it would be interesting to calculate the total ingest of these mycotoxins along the years.     

Detection of zearalenone in cereal extracts using high-performance liquid chromatography with post-column derivatization.

Post-column derivatization has been used to enhance the fluorescence response of the Fusarium mycotoxins zearalenone and zearalenol when determined by reversed-phase high-performance liquid chromatography. Derivatization is based on reaction with aluminum chloride and this results in a more selective response for these toxins. The method was tested on a number of cereals and animal feeds.     

Multiplex dipstick immunoassay for semi-quantitative determination of Fusarium mycotoxins in cereals

A multiplex dipstick immunoassay based method for the simultaneous determination of major Fusarium toxins, namely zearalenone, T-2 and HT-2 toxins, deoxynivalenol and fumonisins in wheat, oats and maize has been developed. The dipstick format was based on an indirect competitive approach. Four test lines (mycotoxin–BSA conjugates) and one control line were located on the strip membrane. Labelled antibodies were freeze-dried within the microwell. Two matrix-related sample preparation protocols have been developed for wheat/oats (not containing fumonisins) and maize (containing fumonisins) respectively. The use of a methanol/water mixture for sample preparation allowed recoveries in the range 73–109% for all mycotoxins in all tested cereals, with relative standard deviation less than 10%. The optimized immunoassay was able to detect target mycotoxins at cut off levels equal to 80% of EU maximum permitted levels, i.e. 280, 400, 1400 and 3200 μg kg⁻¹, respectively, for zearalenone, T-2/HT-2 toxins, deoxynivalenol and fumonisins in maize, and 80, 400 and 1400 μg kg⁻¹, respectively, for zearalenone, T-2/HT-2 toxins and deoxynivalenol in wheat and oats. Analysis of naturally contaminated samples resulted in a good agreement between multiplex dipstick and validated confirmatory LC–MS/MS. The percentage of false positive results was less than or equal to 13%, whereas no false negative results were obtained. Data on the presence/absence of 6 mycotoxins at levels close to EU regulatory levels were obtained within 30 min. The proposed immunoassay protocol is rapid, inexpensive, easy-to-use and fit for purpose of rapid screening of mycotoxins in cereals.     

Determination of zearalenone and ochratoxin A in soil

Mycotoxins are secondary metabolites, formed by the action of fungi on agricultural crops in the field or during storage. These metabolites are highly toxic to animals and humans and high levels have been measured in agricultural crops. In order to evaluate human risks due to ingestion of mycotoxin-contaminated food different methods have been developed for analysis of mycotoxins in cereals and maize. In this project the focus was on mycotoxins in agricultural soil and the fate of these toxins in the soil-water-plant system. Two different mycotoxins were selected in the study: zearalenone (ZON) produced by species of Fusariumor Aspergillusand ochratoxin A (OTA) produced by species of Penicillium. We developed a method for analysis of these toxins in soil. Soil samples were extracted with methanol-water (9:1) and purified by solid-phase extraction (SPE, C8-columns). The final extract was analysed using high-pressure liquid chromatography (HPLC) with fluorescence detection. A Phenyl Hexyl column was used to separate the toxins. The detection limits obtained were 0.1 and 1.0 microg kg(-1) dry weight (dw) for OTA and ZON, respectively. The developed method has been used for analysis of different soils in connection with growth chamber experiments. The soil types used in the growth chamber experiments were a sandy soil, a sandy clay soil, and a soil with high content of organic matter. The recovery was determined as 85.8 and 93.4% and the repeatability to 5.1 and 12.8% for OTA and ZON, respectively. The reproducibility obtained was 8.5 and 15.0% for soil samples, representing concentration levels from 0.2-30 microg kg(-1) dw (OTA) and from 1.0-100 microg kg(-1) dw (ZON).     

Determination of type A trichothecenes by high-performance liquid chromatography with coumarin-3-carbonyl chloride derivatisation and fluorescence detection

A method for the analysis of type A trichothecenes T-2 toxin, HT-2 toxin, neosolaniol and diacetoxyscirpenol by high-performance liquid chromatography with fluorescence detection using coumarin-3-carbonyl chloride has been developed. Different parameters concerning the analytical procedure such as stability of both the reagent and derivatised analytes, time and temperature of the derivatisation reaction, were studied and optimised. Three different clean-up procedures (solid-phase extraction with silica gel or C-18 cartridges, and liquid–liquid partition between toluene and dihydrogen phosphate buffer) were tested in order to remove the excess reagent peaks. The last procedure gave the best results when the buffer pH was 3–5.5, and is therefore recommended. Separations were performed on a stainless steel LiChrospher 100 C-18 reversed-phase column with pre-column of the same phase. The mobile phase was acetonitrile/water (65:35, v/v) containing 0.75% acetic acid at a flow-rate of 1.0 ml/min. The proposed method provides good separation between the four trichothecenes and good reproducibility (RSD of calibration standards <5%). The limits of detection of the studied trichothecenes at a signal-to-noise ratio of 3:1, with an injection volume of 20 μl were 10 ng/g sample for T-2 toxin and about 15 ng/g sample for the remaining mycotoxins. The calibration curve was linear between 10 and 2000 ng for the four trichothecenes assayed. The method was applied to the analysis of these mycotoxins in fungal cultures (corn and rice) of Fusarium sporotrichioides, and is also perfectly suitable for the quantification of type A trichothecenes in contaminated cereals.     

Use of a multifunctional column for the determination of deoxynivalenol in grains, grain products, and processed foods

Deoxynivalenol (DON), also known as vomitoxin, belongs to a class of naturally occurring mycotoxins produced by Fusarium spp. DON, 12, 13-epoxy-3,7 trihydroxytrichothec-9-en-8-one, is one of the most frequently detected mycotoxins in agricultural commodities worldwide. A method consisting of extraction, filtration, column cleanup, and RP-HPLC-UV separation and quantitation was validated for the determination of DON in grains (rice and barley), grain products (whole wheat flour, white flour, wheat germ, and wheat bran), and processed foods (bread, breakfast cereals, and pretzels). A 25 g test portion was extracted with 100 mL acetonitrile-water (84 + 16, v/v). After blending for 3 min, the supernatant was applied to a multifunctional column (MycoSep 225). The purified filtrate (2 mL) was evaporated to dryness and redissolved in the mobile phase. The toxins were then subjected to RP-HPLC-UV analysis. The accuracy and repeatability characteristics of the method were determined. Recoveries of DON added at levels ranging from 0.5 to 1.5 microg/g for all test matrixes were from 75 to 98%. SD and RSD(r) ranged from 0.7 to 11.6% and 0.9 to 12.7%, respectively. Within-laboratory HorRat values were from 0.1 to 0.7 for all matrixes analyzed. The method was found to meet AOAC method performance criteria for grains, grain products, and processed foods. The identity of DON in naturally contaminated test sample extracts was confirmed by HPLC/MS/MS analysis.     

Optimization of Matrix Solid-Phase Dispersion method for simultaneous extraction of aflatoxins and OTA in cereals and its application to commercial samples

A method based on Matrix Solid-Phase Dispersion (MSPD) has been developed for the determination of 5 mycotoxins (ochratoxin A and aflatoxins B and G) in different cereals. Several dispersants, eluents and ratios were tested during the optimization of the process in order to obtain the best results. Finally, samples were blended with C₁₈ and the mycotoxins were extracted with acetonitrile. Regarding to matrix effects, the results clearly demonstrated the necessity to use a matrix-matched calibration to validate the method. Analyses were performed by liquid chromatography-triple quadrupole-tandem mass spectrometry (LC-QqQ-MS/MS). The recoveries of the extraction process ranged from 64% to 91% with relative standard deviation lower than 19% in all cases, when samples were fortified at two different concentrations levels. Limits of detection ranged from 0.3 ng g⁻¹ for aflatoxins to 0.8 ng g⁻¹ for OTA and the limits of quantification ranged from 1 ng g⁻¹ for aflatoxins to 2 ng g⁻¹ for OTA, which were below the limits of mycotoxins set by European Union in the matrices evaluated. Application of the method to the analysis of several samples purchased in local supermarkets revealed aflatoxins and OTA levels.     

The state-of-the-art in the analysis of type-A and -B trichothecene mycotoxins in cereals

The aim of this review is to describe the state-of-the-art in the analysis of A- and B-trichothecene mycotoxins in cereals and to support knowledge and experience exchange between laboratories in the field of Fusarium mycotoxin analysis. Current screening tests and quantitative methods for the most prevalent type-A and -B trichothecenes, HT-2 and T-2-toxin, and deoxynivalenol (DON) are reviewed. This includes the extraction and clean-up procedures and chromatographic methods (TLC, HPLC, GC) applied and the immunochemical methods, especially enzyme-linked immunosorbent assay (ELISA), employed for the determination of these mycotoxins. Results from recent intercomparison studies of the determination of DON are also discussed. Experience gained during these intercomparisons clearly shows the need for further improvement in the determination of trichothecenes, to obtain more accurate and comparable results. This also indicates there is a strong need for the development of further certified reference materials (CRM) which would enable comparison of measurement results between different European laboratories for several A- and B-trichothecenes. For both A- and B-trichothecenes there is still a lack of simple and reliable screening methods enabling the rapid detection of these mycotoxins at low cost.     

Enzyme-linked immunosorbent assay for the determination of T-2 toxin in cereals and feedstuff

A reliable enzyme-linked immunosorbent assay method was developed for the assay of T-2 toxin in cereals and feedstuff. A hapten of the T-2 toxin was synthesized, and a polyclonal antibody with high affinity and specificity was obtained after immunization of rabbits. Compared to the other ELISA methods, the assay is simple, rapid and affordable. The concentration of T-2 causing 15% inhibition is 0.01?±?0.001 ng mL^?1, which makes the method more sensitive than others. The cross-reactivity against other mycotoxins is low, except for the HT-2 toxin. Sample extraction was achieved within 3 min. The recoveries from samples including barley, wheat, corn, oat, rice and feedstuff were between 75% and 102%, and the detection limit for T-2 toxin was lower than 4 ng g^?1. The method was validated by high-performance liquid chromatography with tandem mass spectrometry detection.     

粮食中玉米赤霉烯酮和镰刀菌氧萘满酮高效液相色谱分析方法的研究

建立了粮食样品中镰刀菌氧萘满酮（ＴＤＰ－１）和玉米赤霉烯酮（ＺＥＡ）的高效液相色谱－荧光检测分析方法。粮食样品在碱性和中性条件下用乙腈－水（３：１,Ｖ／Ｖ）提取,经正己烷脱脂,过Ｆｌｏｒｉｓｉｌ柱净化,最后用反相高效液相色谱－荧光检测法测定。该法的最低检出灵敏度：玉米赤霉烯酮为５×１０＾－９ｇ,镰刀菌氧萘满酮为１×１０＾－９ｇ。玉米中镰刀菌氧萘满酮和玉米赤霉烯酮的回收率分别为１００．２％和９２．４     

Development of sensitive and rapid analytical methodology for food analysis of 18 mycotoxins included in a total diet study

A rapid and sensitive method for the determination of 18 mycotoxins in 24 different food matrices has been developed and validated. With the exception of beverages and oil samples, a simple extraction with acetonitrile:water 80:20 (0.1% formic acid) was applied. Fruit juice, wine and beer samples were simply diluted with water containing 0.1% formic acid. Oil samples were partitioned with acetonitrile/hexane in order to remove fats. Analyses were made by ultra-high performance liquid chromatography (UHPLC) coupled to tandem mass spectrometry with triple quadrupole. Validation was carried out in all selected matrices using blank samples spiked at two analyte concentrations. Extraction recoveries between 70 and 120% and relative standard deviations lower than 20% were obtained for the wide majority of analyte–matrix combinations. Matrix-matched calibration was used for a correct quantification in order to compensate for matrix effects. Limits of quantification were lower than maximum permitted levels for every regulated mycotoxin–matrix combination. The acquisition of three SRM transitions per compound allowed the unequivocal confirmation of positive samples, supported by the accomplishment of ion intensity ratios and retention time when compared with reference standards. The developed methodology was applied to the analysis of 240 samples within a total diet study performed at Comunidad Valenciana (Spain). The most frequently found mycotoxins were deoxynivalenol, fumonisin B1, ochratoxin A and zearalenone at low μg kg⁻¹ levels, mainly in bread, breakfast cereals and beer.     

The state-of-the-art in the analysis of estrogenic mycotoxins in cereals

The increasing public awareness of chemicals that mimic or otherwise interfere with the activity of natural hormones - so-called endocrine disrupters - has also led to greater study of mycotoxins with estrogenic potential. The purpose of this paper is to introduce the topic of estrogenic mycotoxins and to discuss the state-of-the-art in the analysis of these substances in cereals, with special emphasis on zearalenone (ZON) as its most relevant representative. Because the use of immunoaffinity columns (IAC) followed by high-performance liquid chromatography with fluorescence detection (HPLC-FLD) and immunoassays are currently the most frequently used methods for the determination of ZON and its metabolites, these techniques are discussed in more detail. Recent papers, which have revealed the great potential of HPLC-MS(MS) for the simultaneous detection and identification of several estrogenic mycotoxins, are discussed. The performances of the state-of-the-art methods are finally compared by study of the results obtained in recent international intercomparison studies. On the one hand, these studies revealed the good performance of both chromatographic and antibody-based methods. On the other hand, the need for better means of external quality assurance measures, especially the availability of certified reference materials and certified standards, has clearly been demonstrated.     

Analytical methods for determination of mycotoxins: An update (2009–2014)

Mycotoxins are a problematic and toxic group of small organic molecules that are produced as secondary metabolites by several fungal species that colonise crops. They lead to contamination at both the field and postharvest stages of food production with a considerable range of foodstuffs affected, from coffee and cereals, to dried fruit and spices. With wide ranging structural diversity of mycotoxins, severe toxic effects caused by these molecules and their high chemical stability the requirement for robust and effective detection methods is clear.     

应用超高效液相色谱-四极杆-飞行时间质谱法建立谷物中18种真菌毒素非靶向筛查数据库及确证方法

建立了基于超高效液相色谱-四极杆-飞行时间质谱(UPLC-Q-TOF/MS)的18种真菌毒素非靶向筛查方法。真菌毒素标准物质用HSS T3色谱柱进行色谱分离后在UPLC-Q-TOF/MS MS^E模式下分别用正、负离子模式采集,获取MS和MS/MS的信息,记录对应保留时间、加合物离子、碎片离子精确质量数等信息,设置保留时间偏移为0.3 min,加合物离子和碎片离子的精确质量匹配容差为5×10^-6,在UNIFI中建立18种真菌毒素的数据库。在稻谷、小麦基质中,以筛查检出限(SDL)作为主要参数对筛查方法进行了验证。18种真菌毒素分为有最大限量和无最大限量两种类型,结果有最大限量的真菌毒素均能在其限量水平被准确筛查,无最大限量的真菌毒素其SDL的范围为2～800μg/kg。基质效应考察表明,稻谷中有14种真菌毒素有中等基质效应,小麦中有11种真菌毒素有中等基质效应。样品经乙腈提取后用QuEChERS萃取盐包和HLB净化柱净化,用建立的方法对25批稻谷、小麦进行筛查,结果2批稻谷中检出4种真菌毒素,2批小麦中检出2种真菌毒素。该方法能准确筛查SDL水...     

复合免疫亲和柱-高效液相色谱法同时测定谷物及其制品中9种真菌毒素

建立了复合免疫亲和柱-在线光化学衍生-高效液相色谱同时测定谷物及其制品中9种真菌毒素的检测方法。以乙腈-水（80：20,v/v）混合溶液提取样品中9种真菌毒素,提取液经自制真菌毒素复合免疫亲和柱净化,采用高效液相色谱进行分离,在线光化学衍生后进入荧光检测器测定,外标法定量。结果表明,9种真菌毒素在相应浓度范围内线性关系良好,相关系数均大于0.999;在低、中、高3个不同加标浓度下,9种真菌毒素的回收率均大于80%,相对标准偏差（RSD）为1.0%~5.6%;方法的检出限（LOD）为0.02~5.00 μg/kg,定量限（LOQ）为0.07~16.70 μg/kg。该方法具有重现性好、灵敏度高、结果准确的特点,适用于谷物及其制品中9种真菌毒素残留的分析检测。     

加速溶剂萃取-QuEChERS-超高效液相色谱-串联质谱法测定药食同源性食品中16种真菌毒素

建立了加速溶剂萃取-QuEChERS-超高效液相色谱-串联质谱测定药食同源性食品中16种真菌毒素的方法。样品经过加速溶剂萃取后用QuEChERS方法净化,液相色谱分离,在正、负离子同时扫描和多反应离子监测模式下检测,黄曲霉毒素B1和伏马毒素B1采用内标法定量,其余毒素采用基质外标法定量。在较宽的线性范围内,16种目标化合物的线性相关系数(r²)均大于0.99。该方法的检出限为0.008～0.3μg/kg,定量限为0.03～1.0μg/kg,在3个不同添加水平下的加标回收率为70.8%～118%, RSD为2.5%～10.2%。采用建立的方法分别对市面上销售的30个批次的山银花、葛根和沙棘产品进行检测,部分产品检出不同含量的真菌毒素。该方法快速、灵敏,适用于药食同源性食品中多种真菌毒素的同时检测。     

Screening of Wood/Forest and Vine By-Products as Sources of New Drugs for Sustainable Strategies to Control Fusarium graminearum and the Production of Mycotoxins

Fusarium graminearum is a fungal pathogen that can colonize small-grain cereals and maize and secrete type B trichothecene (TCTB) mycotoxins. The development of environmental-friendly strategies guaranteeing the safety of food and feed is a key challenge facing agriculture today. One of these strategies lies on the promising capacity of products issued from natural sources to counteract crop pests. In this work, the in vitro efficiency of sixteen extracts obtained from eight natural sources using subcritical water extraction at two temperatures was assessed against fungal growth and TCTB production by F. graminearum. Maritime pine sawdust extract was shown to be extremely efficient, leading to a significant inhibition of up to 89% of the fungal growth and up to 65% reduction of the mycotoxin production by F. graminearum. Liquid chromatography/mass spectrometry analysis of this active extract revealed the presence of three families of phenolics with a predominance of methylated compounds and suggested that the abundance of methylated structures, and therefore of hydrophobic compounds, could be a primary factor underpinning the activity of the maritime pine sawdust extract. Altogether, our data support that wood/forest by-products could be promising sources of bioactive compounds for controlling F. graminearum and its production of mycotoxins.     

Rapid and sensitive double‐label based immunochromatographic assay for zearalenone detection in cereals

A double‐label immunochromatographic based assay (DL‐ICA) was developed to monitor zearalenone (ZEN) levels in cereals, based on Eu³⁺ nanoparticles (EuNP). The DL‐ICA exhibited excellent sensitivity, reliability and selectivity in real samples. It showed low limits of detection (0.21–0.25 μg/kg) and broad analytical ranges (up to 120 μg/kg). The total analytical time, including sample preparation and DL‐ICA execution, was reduced by 15 min compared with HPLC. The recovery rates ranged from 95.0–118.4%, with relative standard deviations (RSD) <11.6%. Inter‐ and intra‐day validations were assessed, recovery rates of 89.3–106.9% and RSD of 2.3–9.7% were obtained, suggesting considerable stability and reliability for the assay. An excellent correlation was observed between DL‐ICA and a reference HPLC method (R² = 0.9899). Compared to current immunoassays, the current DL‐ICA is inexpensive, highly sensitive, and rapid. Therefore, DL‐ICA constitutes a novel tool for monitoring mycotoxins in food and feed to ensure safety.