PREPARATION AND THEIR ANTIBACTERIAL ACTIVITY OF ACTIVATED CARBON FIBER CONTAINING SILVER

Several kinds of activated carbon fiber(ACF),Granule Activated carbon(AC) containing silver ion or fine silver particle(Ag-ACF/AC) have been prepared by soaking ACF or AC in the salt solution of silver.Ag,AgCl and AgI compounds have been loaded onto the fibers:The stucture of the fibers was measured by scanning electron microscopy(SEM) and power X-ray diffraction(XRD),THe Ag content in the fiber was obtained by an Atomic absorption spectroscopy(AAS),The Ag^+ content in water after the antibacterial test was measured by an Inductively Coupled plasma(ICP) emission spectroscopy.Antibacterial test was carried out against Escherichia coli(E.coli) and Staphylococcus aureus(S.aureus).The results show that Ag-ACF/AC have strong antibacterial activity against E.Coli and S.aureus.After dealt with ACF/AC loading Ag,AgCl,AgI,no E.coli and S.aureus alive in solution can be detected.The analysis of Agcontent in water after antibacterial test showed that the content of Ag meet the quality requirement of the National Potable Water Standrd,It is indicated that ACF/AC-Ag in this experiment would be a safe antibacterial agent.     

载银磷酸活化剑麻基活性炭纤维的抗菌性能研究

本文利用磷酸化方法，制备各种剑麻基活性炭纤维，并利用活性炭纤维的氧化还原特性及吸附性能，在其上负载金属银，研究并比较了这些载银活性炭纤维对大肠杆菌和金黄色葡萄球菌的杀灭作用，结果表明，磷酸浓度，活化方法，活化时间，纤维的比表面积等因素的均对材料的抗菌性能有一定的影响，磷酸活化的活性炭纤维表现出强的抗菌杀菌能力，高浓度磷酸活化后的纤维抗菌能力有所提高，并且抗菌能力随活化时间的延长而增加，抗菌前后纤维上负载的银未曾大量脱落，经5次抗菌试验后材料仍显示出很强的抗菌能力。     

通过柠檬酸改性提高载银活性炭的抗菌性能

通过负载柠檬酸对活性炭进行改性,用N2吸附法测定活性炭的比表面积,用AAS、SEM、XRD测试技术分析了银在活性炭上的吸附和分布,并研究了载银活性炭的抗菌性能。结果表明,负载柠檬酸使活性炭的比表面积下降约24%,但载银后活性炭的比表面积增大。柠檬酸改性为[Ag(NH3)2] 的还原吸附提供更多的活性点,使银的吸附速率加快,吸附量提高约25%,表面的银颗粒变得非常密集,粒径减小,且颗粒均匀,因此抗菌性能显著增强,其中对金黄色葡萄球菌的杀灭效果明显优于对大肠杆菌的,同时对于高分散Ag/C催化剂的制备及银的回收也具有重要的价值。     

Antibacterial behavior of transition-metals-decorated activated carbon fibers

The antibacterial behavior of transition metals (Cu or Ag)-plated activated carbon fibers (ACFs) was investigated. The pore structure of the ACFs before and after metal electroplating was studied by N(2)/77 K isothermal adsorption. The antibacterial behavior against Staphylococcus aureus and Klebsiella pneumoniae was tested by a modified dilution method. As experimental results, the ACFs showed a decrease in specific surface area and micro- and total pore volume with increasing metal content. The antibacterial behavior of the ACFs was predominantly increased and showed over 99% against S. aureus as well as K. pneumoniae, attributed to the presence of metal nanoparticles in this system.     

STUDIES ON THE PREPARATION OF ZINC-CONTAINING ACTIVATED CARBON FIBERS AND THEIR ANTIBACTERIAL ACTIVITY

1. INTRODUCTION Microbial pollution will bring about various problems in industry and other vital fields, such as causing decomposing of materials, harming people抯 health. In order to reduce these problems, new antibacterial materials have been demanded. Recently, much attention has been paid to inorganic materials including zinc oxide [1~4]. These inorganic antibacterial materials are now substituting for organic materials to avoid releasing noxious organic molecules harmful to humans;…     

Antibacterial activity of silver bionanocomposites synthesized by chemical reduction route

ABSTRACT: BACKGROUND: The aim of this study is to investigate the functions of polymers and size of nanoparticles on the antibacterial activity of silver bionanocomposites (Ag BNCs). In this research, silver nanoparticles (Ag NPs) were incorporated into biodegradable polymers that are chitosan, gelatin and both polymers via chemical reduction method in solvent in order to produce Ag BNCs. Silver nitrate and sodium borohydride were employed as a metal precursor and reducing agent respectively. On the other hand, chitosan and gelatin were added as a polymeric matrix and stabilizer. The antibacterial activity of different sizes of silver nanoparticles was investigated against Gram-positive and Gram-negative bacteria by the disk diffusion method using Mueller-Hinton Agar. RESULTS: The properties of Ag BNCs were studied as a function of the polymer weight ratio in relation to the use of chitosan and gelatin. The morphology of the Ag BNCs films and the distribution of the Ag NPs were also characterized. The diameters of the Ag NPs were measured and their size is less than 20 nm. The antibacterial trait of silver/chitosan/gelatin bionanocomposites was investigated. The silver ions released from the Ag BNCs and their antibacterial activities were scrutinized. The antibacterial activities of the Ag BNC films were examined against Gram-negative bacteria (E. coli and P. aeruginosa) and Gram-positive (S. aureus and M. luteus) by diffusion method using Muller-Hinton agar. CONCLUSIONS: The antibacterial activity of Ag NPs with size less than 20 nm was demonstrated and showed positive results against Gram-negative and Gram-positive bacteria. The Ag NPs stabilized well in the polymers matrix.     

通过氧化改性提高载银活性炭的抗菌性能

使用浓HNO3和浓H2O2对活性炭进行常温氧化改性,用FTIR和N2吸附法对活性炭进行表面分析,用AAS、SEM、XRD研究银在活性炭表面的吸附和分布特征,并研究了载银活性炭的抗茵性能.结果表明,活性炭经浓HNO3常温改性后,比表面积提高,而经浓H2O2常温改性后,比表面积略有下降,但都使活性炭表面含氧基团增加.改性后,活性炭表面增加的含氧基团为[Ag(NH3)2] 的还原吸附提供更多的活性点,使银的吸附量增大5倍多,银颗粒更加密集,大小更加均一.研究表明,载银活性炭具有明显的抗茵作用,其中对金黄色葡萄球菌的杀灭效果优于对大肠杆菌的杀灭效果,氧化改性使载银活性炭抗茵作用显著增强,其中硝酸改性现象更加明显.     

A study on NO removal of activated carbon fibers with deposited silver nanoparticles

In this study, activated carbon fibers (ACFs), onto which silver (Ag) nanoparticles have been introduced by an electroplating technique, were used to remove NO. Surface properties of the ACFs were determined by X-ray diffraction and scanning electron microscopy. N2 adsorption isotherms at 77 K were investigated by BET and t-plot methods to characterize the specific surface areas and pore volumes, and NO removal efficiency was confirmed by a gas chromatographic technique. As for the experimental results, Ag content on the ACFs increased with plating time. However, adsorption properties such as the BET specific surface area and the total pore volume were somewhat decreased in the presence of Ag nanoparticles. NO removal efficiency of all Ag-ACFs was higher than that of untreated ACFs and increased with Ag content. However, a decrease in the extent of NO removal was shown in the excessively plated ACFs, which might be associated with the blocking of the micropores in the carbon; therefore, an optimal Ag content needs to exist in the presence of initially well-developed micropores to lead to an increase in the efficient NO removal ability of the ACF.     

STUDY ON THE FACTORS AFFECTING REDUCTION CAPACITIES OF ACTIVATED CARBON FIBERS

1. INTRODUCTION The discharge of effluent containing precious metal ions, which comes from electroplating, mining, smelting, and other industries, not only contaminate the environment where people live, but also cause the waste of natural resources. From…     

Preparation and Characterization of Antibacterial Polyacrylonitrile-based Activated Carbon Fiber Supporting Nano-ZnO

Polyacrylonitrile(PAN)-based activated carbon fiber(PACF) supporting nano-ZnO(PACF /nano-ZnO) was prepared by spin, pretreatment, carbonization, and KOH chemical activation at an activation temperature of 950 ℃ for 40 min. Nano-ZnO content, distribution and antibacterial properties of the PACF/nano-ZnO were studied. The pore structure and surface properties of the PACF/nano-ZnO were studied by Brunauer-Emmett-Teller(BET), N₂/77 K isothermal adsorption. The specific surface area increased markedly after the activation process and it was several hundred times greater than that before the process. The PACF/nano-ZnO shows a strong adsorption for Staphylococcus aureus(S. aureus) and Escherichia coli(E. coli) and antibacterial activity against them. As an experimental result, antibacterial properties of PACF/nano-ZnO increased with increasing the concentration of nano-ZnO particles, which suggests it is a promising antibacterial material.     

Antibacterial thermoplastic polyurethane electrospun fiber mats prepared by 3-aminopropyltriethoxysilane-assisted adsorption of Ag nanoparticles

Antibacterial thermoplastic polyurethane(TPU) electrospun fiber mats were prepared by adsorption of Ag nanoparticles(Ag NPs) onto TPU/3-aminopropyltriethoxysilane(APS) co-electrospun fiber mats from silver sol. The use of APS can functionalize TPU fibers with amino groups, facilitating the adsorption of Ag NPs. The effects of p H of silver sol and APS content on Ag NP adsorption and antibacterial activity were investigated. Ag NP adsorption was evidenced by TEM, XPS and TGA. Significant Ag NP adsorption occurred at p H = 3-5. The main driving force for Ag NP adsorption is electrostatic interaction between ―NH3~+ of the fibers and ―COO-derived from the ―COOH group capped on the surfaces of Ag NPs. The antibacterial activity of the Ag NP-decorated TPU/APS fiber mats was investigated using both gram-negative Escherichia coli and gram-positive Bacillus subtilis. The antibacterial rate increases with increasing APS content up to 5% where the antibacterial rates against both types of bacteria are over 99.9%.     

STUDY ON THE FACTORS AFFECTING REDUCTION CAPACITIES OF ACTIVATED CARBON FIBERS

The reduction adsorption of silver diamminonitrate on different kinds of activated carbonfibers (ACF) has been studied in this paper. The effect of different parameters, including adsorptiontemperature, concentrations of activation agents, and activation time on the silver adsorptioncapacities of activated carbon fibers has been investigated The results show that higher temperaturein which the silver complex interacts with ACF. or higher concentration of activation agent, will makehigher reduction adsorption capacities of ACFs. More over, ACFs activated with phosphoric acidhave higher reduction capacities than those activated with zinc chloride or steam.     

静电纺丝法制备抑菌性聚酰亚胺纳米纤维

采用静电纺丝技术,以联苯四甲酸二酐(BPDA)和4,4'-二氨基二苯醚(ODA)为单体,硝酸银为银源,通过两步法制备含银聚酰亚胺(PI/Ag)纳米纤维.通过X射线衍射(XRD)、透射电子显微镜(TEM)及扫描电子显微镜(SEM)表征了PI/Ag纳米纤维的结构和微观形貌;通过浸渍培养法研究了聚酰亚胺(PI)及PI/Ag纳米纤维的抑菌性能.结果表明,聚酰亚胺基体中存在单质银的立方晶体结构,银粒子在聚酰亚胺基体表面均匀分散,平均粒径为10 nm;PI/Ag纳米纤维对大肠杆菌(E.coli)、金黄色葡萄球菌(S.aureus)和枯草芽孢杆菌(B.subtilis)表现出良好的抑菌效果,最大抑菌率可达99.1%,为聚酰亚胺在耐高温抑菌生物医用材料等领域的应用提供了新的方向.     

Synthesis and characterization of silver nanoparticle and graphene oxide nanosheet composites as a bactericidal agent for water disinfection

Graphene oxide (GO) nanosheets impregnated with silver nanoparticles (Ag NPs) were fabricated by the in situ reduction of adsorbed Ag(+) by hydroquinone (HQ) in a citrate buffer solution. Paper-like Ag NP/GO composite materials were fabricated owing to convenient structure characterization and antibacterial tests. The Ag NP/GO composites were characterized by UV-vis spectra, transmission electron microscope, electron diffraction, Raman spectroscopy, and field emission scanning electron microscope coupled with Energy Dispersive Spectrometer. Antibacterial activity was tested using Escherichia coli and Staphylococcus aureus as model strains of Gram negative and Gram positive bacteria, respectively. The as-prepared composites exhibit stronger antibacterial activity against both. The Ag NP/GO composites performed efficiently in bringing down the count of E. coli from 10(6) cfu/mL to zero with 45 mg/L GO in water. The micron-scale GO nanosheets (lateral size) enable them to be easily deposited on porous ceramic membranes during water filtration; making them a promising biocidal material for water disinfection.     

Photo induced silver on nano titanium dioxide as an enhanced antimicrobial agent for wool

In this study an effective nanocomposite antimicrobial agent for wool fabric was introduced. The silver loaded nano TiO(2) as a nanocomposite was prepared through UV irradiation in an ultrasonic bath. The nanocomposite was stabilized on the wool fabric surface by using citric acid as a friendly cross-linking agent. The treated wool fabrics indicated an antimicrobial activity against both Staphylococcus aureus and Escherichia coli bacteria. Increasing the concentration of Ag/TiO(2) nanocomposite led to an improvement in antibacterial activities of the treated fabrics. Also increasing the amount of citric acid improved the adsorption of Ag/TiO(2) on the wool fabric surface leading to enhance antibacterial activity. The EDS spectrum, SEM images, and XRD patterns was studied to confirm the presence of existence of nanocomposite on the fabric surface. The role of both cross-linking agent and nanocomposite concentrations on the results was investigated using response surface methodology (RSM).     

A novel Ag/Ag3PO4-IRMOF-1 nanocomposite for antibacterial application in the dark and under visible light irradiation

MOF-5 that sometimes called IRMOF-1 has been intensively studied in recent years to develop efficient photocatalyst to degrade refractory organics and inactivate bacteria for wastewater treatment. In the present work, Ag/Ag₃PO₄ nanoparticles incorporated in IRMOF-1 was successfully prepared via hydrothermal approach. The antibacterial activity of synthesized materials (IRMOF-1, Ag/Ag₃PO₄ nanoparticles and Ag/Ag₃PO₄-IRMOF-1 nanocomposite was compared against two types of bacteria (Escherichia coli (E. coil) as Gram negative and Staphylococcus aureus (S. aureus) as Gram-positive bacteria). The deactivation of the bacteria by the prepared material was measured in the dark and under visible light irradiation. The antibacterial activity of synthesized samples was investigated by determining the minimal inhibitory concentration (MIC), minimal bactericidal concentration (MBC), growth inhibition assay and inhibition zone. The Ag/Ag₃PO₄-IRMOF-1 nanocomposite exhibited stronger antibacterial activities than the Ag/Ag₃PO₄ nanoparticles and IRMOF-1 at all tested bacteria types. Based on inhibition zone, without any light irradiation, Ag/Ag₃PO₄-IRMOF-1 nanocomposite showed activity toward E. coil, but in presence of light nanocomposite depicted activity toward S. aureus. The results demonstrated that antibacterial activity of all synthesized samples in the dark and light against S. aureus bacteria was more than E. coil bacteria. The antibacterial activity mechanism was due to sustained-release of silver ions in the dark and reactive oxygen species (ROS) under visible light. The bioactivity of IRMOF-1 was related to the degradation of the its structure and the release of Zn²⁺ ions into the culture medium that bind to the cell wall and deactivation bacteria.     

茶皂素―金属复合抗菌剂的制备及抗菌性能研究

通过抑菌环法探讨了茶皂素、金属离子、茶皂素―金属复合抗菌剂对大肠杆菌和金黄色葡萄球菌的抗菌活性,考察了茶皂素纯度、浓度、金属离子种类等因素对抗菌剂抗菌活性的影响。结果表明,茶皂素的抗菌活性与单一的金属离子的抗菌活性相当,茶皂素对大肠杆菌的最低抑制浓度为5 mg/mL,对金黄色葡萄球菌的最低抑制浓度是10 mg/mL;茶皂素与金属离子复配抗菌活性具有协同效应,尤其茶皂素―锌复合抗菌剂对大肠杆菌的抑制效果大大加强。     

STUDIES ON THE PREPARATION OF ZINC-CONTAINING ACTIVATED CARBON FIBERS AND THEIR ANTIBACTERIAL ACTIVITY

Several kinds of activated carbon fibers, using sisal fiber as precursors, were preparedwith steam activation or with ZnCl2 activation. Zinc or its compounds were dispersed in them. Theantibacterial activities of these activated carbon fibers were determined and compared. The researchresults showed that these sisal based activated carbon fibers supporting zinc have strongerantibacterial activity against Escherichia coli and S. aureus. The antibacterial activity is related tothe precursors, the pyrolysis temperature, and the zinc content. In addition, small quantity of silversupported on zinc-containing ACFs will greatly enhance the antibacterial activity of ACFs.     

Ag@AgI, core@shell structure in agarose matrix as hybrid: synthesis, characterization, and antimicrobial activity

A novel in situ core@shell structure consisting of nanoparticles of Ag (Ag Nps) and AgI in agarose matrix (Ag@AgI/agarose) has been synthesized as a hybrid, in order to have an efficient antibacterial agent for repetitive usage with no toxicity. The synthesized core@shell structure is very well characterized by XRD, UV-visible, photoluminescence, and TEM. A detailed antibacterial studies including repetitive cycles are carried out on Gram-negative Escherichia coli (E. coli) and Gram-positive Staphylococcus aureus (S. aureus) bacteria in saline water, both in dark and on exposure to visible light. The hybrid could be recycled for the antibacterial activity and is nontoxic toward human cervical cancer cells (HeLa cells). The water insoluble Ag@AgI in agarose matrix forms a good coating on quartz, having good mechanical strength. EPR and TEM studies are carried out on the Ag@AgI/agarose and the bacteria, respectively, to elucidate a possible mechanism for killing of the bacteria.     

Cryochemical synthesis and antibacterial activity of a hybrid composition based on Ag nanoparticles and dioxidine

Hybrid nanocomposites based on an dioxidine antimicrobial substance modified with silver were produced by means of cryochemical synthesis. TEM, UV-absorption spectroscopy, X-ray diffraction, and surface analysis based on low-temperature argon adsorption showed the formation of hybrid nanosystems consisting of drug substance particles with a size of 50–300 nm including internal small Ag nanoparticles with a size of 2–40 nm. The obtained hybrid nanosystems showed higher antibacterial activity against E. coli 52, S. aureus 144, and M. cyaneum 98 than did the original dioxidine.