Sample clean-up by sol-gel immunoaffinity chromatography for determination of chloramphenicol in shrimp

The paper describes the characterisation and application of sol-gel columns prepared by entrapping anti-chloramphenicol (CAP) antibodies. Retention of CAP in the column was caused by specific interactions with the anti-CAP antibodies and not by non-specific adsorption to the sol-gel glass. After optimising important operation conditions, e.g. feeding medium, feeding flow-rate, elution medium, elution flow-rate and elution volume, the sol-gel columns were included in a clean-up procedure developed to determine CAP in shrimp. The selectivity of the columns was high enough to efficiently remove interfering matrix compounds. Due to the chromatographic conditions applied retention of cross-reacting substances in the immunoaffinity column did not pose a problem. CAP recovery of the analytical method was 68% with a relative standard deviation of 4% (n=4). In spite of applying highly complex shrimp extracts the columns could be used for clean-up of at least 12 samples. However, when detection of CAP is carried out with an UV detector the analytical method has a relatively poor sensitivity (LOD=1.8 ng/g, S/N=3). The most obvious way is to replace the UV detector by a detector based on an inherently more sensitive and selective detection principle, like a mass spectrometer.     

Analysis of ochratoxin A in milk after direct immunoaffinity column clean-up by high-performance liquid chromatography with fluorescence detection

The present work describes a new analytical method for direct immunoaffinity column clean-up of ochratoxin A (OTA) in milk samples followed by determination of the toxin using high-performance liquid chromatography with fluorescence detection (HPLC-FD). Two different immunoaffinity cartridges (IAC) were investigated, and Ochraprep columns were chosen because they showed the best results. An average recovery of 89.8% and a mean RSD of 5.8% for artificially contaminated cow's milk in the range of 5-100 ng/L were attained. The calculated limit of detection (LOD) and limit of quantitation (LOQ) were as low as 0.5 and 5 ng/L, respectively. This new easy and fast method avoids a previous liquid-liquid extraction step and therefore the use of toxic chlorinated solvents. Chromatograms of the final extracts were clean and OTA could be easily detected at a retention time of 8.4 min without interferences. To assess the presence of the toxin in cow's milk eight samples of skimmed and four samples of whole milk were analysed and OTA was not detected over the established detection limit.     

Immunoaffinity column cleanup with liquid chromatography using post-column bromination for aflatoxins in medicinal herbs and plant extracts

A new and accurate method to quantitate aflatoxins in medicinal herbs is developed. This method consists of extraction of the sample with MeOH-H2O (70:30) followed by clean-up of the extracts with immunoaffinity columns and, finally, high-performance liquid chromatographic determination with fluorescence detection. Aflatoxins B1 and G1 are determined as their bromine derivatives, produced in an online post-column derivatization system. The overall average recoveries for three different medicinal herbs spiked at levels of 1.3 and 2.6 ng/g of total aflatoxins range from 93% to 97%. The detection limit is 0.15 ng/g for both G2 and B2 and 0.20 ng/g for both G1 and B1, based on a signal-to-noise ratio of 3:1 and a precision (within-laboratory relative standard deviation) ranging from 0.8% to 1.4%. The use of immunoaffinity columns provides excellent clean-up of these particular extracts, which are generally difficult to analyze. The method is applied successfully to 96 samples of natural drugs.     

Immunoaffinity column cleanup with liquid chromatography for determination of aflatoxin M1 in liquid milk: collaborative study

A collaborative study was conducted to evaluate the effectiveness of an immunoaffinity column cleanup liquid chromatographic method for determination of aflatoxin M1 in milk at proposed European regulatory limits. The test portion of liquid milk was centrifuged, filtered, and applied to an immunoaffinity column. The column was washed with water, and aflatoxin was eluted with pure acetonitrile. Aflatoxin M1 was separated by reversed-phase liquid chromatography (LC) with fluorescence detection. Frozen liquid milk samples both naturally contaminated with aflatoxin M1 and blank samples for spiking, were sent to 12 collaborators in 12 different European countries. Test portions of samples were spiked at 0.05 ng aflatoxin M1 per mL. After removal of 2 noncompliant sets of results, the mean recovery of aflatoxin M1 was 74%. Based on results for spiked samples (blind pairs at 1 level) and naturally contaminated samples (blind pairs at 3 levels) the relative standard deviation for repeatability (RSDr) ranged from 8 to 18%. The relative standard deviation for reproducibility (RSDR) ranged from 21 to 31%. The method showed acceptable within- and between-laboratory precision data for liquid milk, as evidenced by HORRAT values at the low level of aflatoxin M1 contamination.     

Analysis of T-2 and HT-2 toxins in cereal grains by immunoaffinity clean-up and liquid chromatography with fluorescence detection

A sensitive, precise and accurate method has been developed for the simultaneous determination of T-2 and HT-2 toxins in cereal grains at ppb levels using high-performance liquid chromatography (HPLC) with fluorescence detection and 1-antroylnitrile (1-AN) as labeling reagent after immunoaffinity clean-up. Cereal samples were extracted with methanol/water (90:10, v/v), and the extracts were cleaned-up through commercially available immunoaffinity columns containing monoclonal anti-T-2 antibodies (T-2 test HPLC, Vicam). T-2 and HT-2 toxins were quantified by reversed-phase HPLC with fluorometric detection (excitation wavelength 381 nm, emission wavelength 470 nm) after derivatization with 1-AN. The monoclonal antibody showed 100% cross-reactivity with both T-2 and HT-2 toxin, and the immunoaffinity column clean-up was effective up to 1.4 microg of both toxins. The method was successfully applied to the analysis of T-2 and HT-2 toxins in wheat, maize and barley. Recoveries from spiked samples with toxin levels from 25 to 500 microg/kg ranged from 70% to 100%, with relative standard deviation generally lower than 8%. The limit of detection of the method was 5 microg/kg for T-2 toxin and 3 microg/kg for HT-2 toxin, based on a signal-to-noise ratio 3:1. HT-2 toxin was detected in ten naturally contaminated wheat samples out of 14 samples analyzed, with toxin levels ranging from 10 to 71 microg/kg; three of them contained also T-2 toxin up to 12 microg/kg.     

Automated aflatoxin analysis of foods and animal feeds using immunoaffinity column clean-up and high-performance liquid chromatographic determination

A commercially available system is described for the fully automated clean-up and high-performance liquid chromatographic (HPLC) analysis of aflatoxins in foods and animal feeds. The system marketed primarily for handling solid-phase extraction columns has modified software to facilitate use with immunoaffinity columns. Sample extract clean-up followed by injection onto an HPLC column with post-column iodination and fluorescence detection is carried out completely unattended. A coefficient of variation of 5.1% for aflatoxin B1 analysis was obtained, and the accuracy of the system was demonstrated by the analysis of peanut butter certified reference material.     

Rapid and simple determination of aflatoxin M1 in milk in the low parts per 10(12) range

A method for extracting aflatoxin M1 from milk is proposed in which the use of disposable Extrelut clean-up columns simplifies the analysis considerably in comparison with existing methods. The quantitative determination is based on one-dimensional thin-layer chromatography and fluorescence densitometric measurement. The detection limit is 5 ppt (parts per 10(12)) in milk and the recovery is 78 +/- 4% at a level of 50 ppt.     

Comparison of Different Clean-Up Procedures for the Analysis of Deoxynivalenol in Cereal-Based Food and Validation of a Reliable HPLC Method

Three different clean-up methods for the analysis of deoxynivalenol in cereals and cereal-based foods are described and compared. DON was extracted with water or acetonitrile/water (84/16, v/v) and the extracts were cleaned-up by passing either through two different immunoaffinity columns (DONtest, Vicam; DONPrep, Rhone) or a charcoal/alumina column (MycoSep, Romer Labs). Determinative analysis was performed by high performance liquid chromatography (HPLC) with diode array detection (DAD) and fluorescenic detection (FLD) after post-column derivatisation. Different parameters were optimised and possible reasons for diverse results are discussed. The final method was validated and adopted to different matrices. Best results were obtained using immunoaffinity columns for clean-up in combination with HPLC-FLD detection of the DON-derivative.     

Multiclass Compatible Sample Preparation for UHPLC–MS/MS Determination of Aflatoxin M1 in Raw Milk

A sample preparation method for aflatoxin M1 (AFM1) determination in raw milk was optimized following the quick, easy, cheap, effective, rugged and safe (QuEChERS) strategy, as an alternative to the classic immunoaffinity column clean-up (IAC). The method was adapted to address the complexity of the milk matrix, and to be suitable for final determination by ultra-high performance liquid chromatography coupled to tandem mass spectrometry (UHPLC–MS/MS). This approach proved also to be compatible with the simultaneous extraction of pesticide residues and other contaminants (mycotoxins). Regarding AFM1, satisfactory linearity was achieved and appropriate sensitivity was maintained, using matrix-matched calibration to compensate for the heavy ion suppression. The accuracy and precision, which were determined through recovery studies, were 70–95 %, with the relative standard deviation below 15 % in all of the cases. The limit of detection (LOD, 0.002 μg L⁻¹) and limit of quantification (0.007 μg L⁻¹) are compatible with current worldwide regulations (maximum levels of 0.5 and 0.05 μg L⁻¹). The procedure was applied to samples that were naturally contaminated with a range of AFM1 at LOQ–0.187 μg L⁻¹, with comparable results to IAC clean-up, which was employed as a reference method. Therefore, AFM1 determination in raw milk by UHPLC–MS/MS detection through the present QuEChERS extraction constitutes a reliable alternative to IAC clean-up and exhibits advantages related to cost, accessibility of materials and simplicity of operation.

     

Optimization of solid-phase clean-up prior to liquid chromatographic analysis of ochratoxin A in roasted coffee

An extraction and clean-up method for ochratoxin A (OA) in roasted coffee has been developed and the HPLC method optimized. An interfering compound with a similar retention time as OA was adsorbed by the aminopropyl (NH2) material at < or = 5% NaHCO3. Residual OA on the column was recovered by washing with the extraction solution followed with methanol. Fractions were mixed together for further clean-up with Ochratest immunoaffinity columns (IACs). Analysis by HPLC resulted in a well resolved OA peak and reduction in matrix interferences. Recoveries ranged from 72 to 84% and the detection limit was 1 ng/g.     

Development of a selective sample clean-up method based on immuno-ultrafiltration for the determination of deoxynivalenol in maize

This paper describes the development of a highly selective analytical method for the determination of deoxynivalenol (DON) in maize. The developed method is based on immuno-ultrafiltration (IUF) and is the first application of IUF as a clean-up strategy in food analysis. Quantification of DON was carried out by high-performance liquid chromatography with ultraviolet detection. In contrast to immunoaffinity chromatography, in IUF the antibodies are not bound to a solid support material but used in free form, thus making it possible to avoid the critical immobilisation step. Sample clean-up by IUF proved to be as selective as clean-up using commercially available immunoaffinity columns. The limit of detection (S/N=3) of the analytical method was found to be 74 ng DON/g maize. Repeated analysis of a certified maize reference material on four different days resulted in a mean recovery of 93% with a standard deviation of 10%.     

Determination of aflatoxin B1 in cereals by homogeneous liquid-liquid extraction coupled to high performance liquid chromatography-fluorescence detection

A simple and rapid method based on homogeneous liquid-liquid extraction coupled to HPLC with fluorescence detection was developed for the determination of aflatoxin B1 (AFB1) in the rice and grain samples after post-column derivatization. The proposed method eliminated the use of immunoaffinity columns for clean-up in the determination of AFB1. The parameters affecting recovery and preconcentration such as type and volume of organic solvent, volume ratio of water/methanol, concentration of phase separator reagent and extraction time were optimized. Under the optimized conditions, the calibration graph was linear in the concentration range of 0.01-1.0 ng/g with the detection limit of 0.003 ng/g. This method was successfully applied for the analysis of AFB1 in different cereal samples.     

Reversed-phase liquid chromatographic method for the determination of ochratoxin A in wine

In this paper, we propose a new, rapid, highly sensitive and reproducible RP-HPLC-FLD method for the detection of ochratoxin A (OTA) in wine, by directly injecting the liquid in the chromatographic system without any extraction or clean-up. An alkaline mobile phase (NH4Cl:CH-CN 85:15 (v/v), 20 mM, pH 9.8) was used to obtain a distinct fluorescence enhancement. This improvement allows to reach, without an immunoaffinity clean-up or concentration, a detection limit of 0.05 ng/ml, which is similar to those commonly obtained after immunoaffinity purification and acidic elution. The method was statistically validated and directly applied to a series of wine samples.     

Determination of ochratoxin A in domestic and imported beers in italy by immunoaffinity clean-up and liquid chromatography

A method first developed to quantify ochratoxin A in wine has been applied to the analysis of domestic and imported beers in Italy. The method uses commercial immunoaffinity columns for clean-up and high-performance liquid chromatography for quantification of the toxin. Beer was degassed, then diluted with a polyethylene glycol-sodium hydrogencarbonate solution and applied to an OchraTest immunoaffinity column. Ochratoxin A was eluted from the immunoaffinity column with methanol and quantified by reversed-phase HPLC with fluorometric detector. Average recoveries of ochratoxin A from blank beer spiked at levels from 0.04 to 1.0 ng/ml ranged from 93.8% to 100.4%, with relative standard deviations between 3.3% and 5.7%. The detection limit was 0.01 ng/ml based on a signal-to-noise ratio of 3:1. The analysis of 61 samples of domestic (10) and imported (51) beers showed ochratoxin A levels ranging from <0.01 to 0.135 ng/ml with an incidence of contamination of 50% and no substantial difference between strong and pale beers.     

Measurement of aflatoxin M1 in milk by ultra-high-performance liquid chromatography/tandem mass spectrometry

A sensitive method was developed using ultra-high-performance liquid chromatography (UHPLC)/MS/MS with positive electrospray ionization for determining aflatoxin M1 (AFM1) in milk and milk powder. A 50 mL quantity of low-fat liquid milk containing 100 ng/L AFM1, was prepared using immunoaffinity columns with a mean recovery rate of 79% (n = 3). UHPLC columns (BEH C18, BEH HILIC, and HSS T3) greatly reduced the chromatographic time and lowered the instrumental detection limits (IDLs) 16 to 58 times compared to an HPLC column (Betabasic C18). The HSS T3 column was chosen because it provided a low IDL (0.11 pg) and the lowest ion suppression of signal intensity (63.4%) among the tested columns. Matrix-fortified calibration curves were used for quantification and showed good linearity (r > 0.997) at 0.05-500 ng/mL. The LOD was 0.18 ng/kg for milk and 2.08 nglkg for milk powder, based on the signal intensity of the confirmatory product ion (m/z 259.1), which was less abundant than the quantitative product ion (m/z 273.1). Certified reference materials of milk powder at three levels (<0.05, 0.111 +/- 0.018, and 0.44 +/- 0.06 microg/kg) were measured within a day and between days; the results were all close to the certified levels with low variations (RSDs < 15%), showing good precision and accuracy.     

Detection of incurred dihydrostreptomycin residues in milk by liquid chromatography and preliminary confirmation methods.

An LC method for the determination of the aminoglycosides streptomycin (STR) and dihydrostreptomycin (DHS) in milk was developed/modified on the basis of published papers. Mean recoveries were 87 and 95% for STR and DHS, respectively. Recoveries are dependent on the concentration level and batch of solid-phase extraction columns used, and independent of fat content and homogenization. The relative standard deviations are 15.6 and 9.6% for STR and DHS, respectively, at a level of 100 micrograms kg-1. Limits of detection (8 and 12 micrograms kg-1, respectively) and quantification (12 and 18 micrograms kg-1, respectively) are far below the EU maximum residue limit of 200 micrograms kg-1. Lyophilized DHS samples can be used for internal control of the analysis as the DHS concentration is not influenced by the lyophilization process and subsequent storage at 6 degrees C. In incurred milk samples no false negative results of preliminary confirmation tests (Charm II Aminoglycoside test, Ridascreen Streptomycin ELISA) with respect to DHS concentrations > or = 20 micrograms kg-1 as determined by the LC method are observed. DHS concentrations of incurred samples determined by ELISA are higher than those obtained by the LC method. These differences were more pronounced with incurred than with spiked milk samples, thus leading to the conclusion that in incurred samples substances are present which co-react in the ELISA and which are not detected by the LC method.     

免疫亲和柱净化/柱前衍生化-高效液相色谱荧光检测法测定粮谷中的T-2毒素

建立了免疫亲和柱净化/柱前衍生化-高效液相色谱荧光检测器测定粮谷中T-2毒素含量的方法。样品经甲醇-水(体积比为80∶20)混合溶剂提取,通过免疫亲和柱(IAC)净化,以氰酸蒽(1-AN)为衍生化试剂、4-二甲基氨基吡啶(DMAP)为催化剂进行衍生,以ZORBAX Eclipse XDB-C18 柱为分离柱,乙腈-水(体积比为80∶20)为流动相进行高效液相色谱分离及荧光检测，荧光检测的激发波长为381 nm，发射波长为470 nm。T-2毒素的质量浓度为0.01~1.5 mg/L时与峰高呈良好的线性,相关系数为0.9985。在0.01~1.5 μg/g添加水平下，回收率为79.7%~94.5%,相对标准偏差小于7%；检出限（S/N＝3）为0.01 μg/g。该方法净化效果好,灵敏度高,操作简便快速。     

Determination of zearalenone content in cereals and feedstuffs by immunoaffinity column coupled with liquid chromatography

The zearalenone content of maize, wheat, barley, swine feed, and poultry feed samples was determined by immunoaffinity column cleanup followed by liquid chromatography (IAC-LC). Samples were extracted in methanol-water (8 + 2, v/v) solution. The filtered extract was diluted with distilled water and applied to immunoaffinity columns. Zearalenone was eluted with methanol, dried by evaporation, and dissolved in acetonitrile-water (3 + 7, v/v). Zearalenone was separated by isocratic elution of acetonitrile-water (50 + 50, v/v) on reversed-phase C18 column. The quantitative analysis was performed by fluorescence detector and confirmation was based on the UV spectrum obtained by a diode array detector. The mean recovery rate of zearalenone was 82-97% (RSD, 1.4-4.1%) on the original (single-use) immunoaffinity columns. The limit of detection of zearalenone by fluorescence was 10 ng/g at a signal-to-noise ratio of 10:1 and 30 ng/g by spectral confirmation in UV. A good correlation was found (R2 = 0.89) between the results obtained by IAC-LC and by the official AOAC-LC method. The specificity of the method was increased by using fluorescence detection in parallel with UV detection. This method was applicable to the determination of zearalenone content in cereals and other kinds of feedstuffs. Reusability of immunoaffinity columns was examined by washing with water after sample elution and allowing columns to stand for 24 h at room temperature. The zearalenone recovery rate of the regenerated columns varied between 79 and 95% (RSD, 3.2-6.3%). Columns can be regenerated at least 3 times without altering their performance and without affecting the results of repeated determinations.     

Sol-gel immunoaffinity chromatography for the clean up of ochratoxin A contaminated grains

This paper describes the application of sol-gel immunoaffinity columns for clean up of ochratoxin A contaminated cereal crops. Monoclonal antibodies selective for OTA have been entrapped into the pores of a sol-gel matrix in order to prepare immunoaffinity columns. Different parameters such as amount of entrapped antibodies and loading conditions were optimized to obtain highest possible recoveries of OTA. The method has been found to be a suitable tool in sample preparation prior to HPLC-FLD determination and as selective as conventional commercially available immunoaffinity columns. In the clean up of different cereals mean recoveries of 82±5%, 90±6% and 91±3%, were obtained for wheat, barley and rye, respectively, with sol-gel columns containing 1mg of anti-OTA antibodies. The detection limit (signal-to-noise ratio, 3) was 0.5 μg/kg and the limit of quantification (signal-to-noise ratio, 10) determined to be 1 μg/kg. Sol-gel columns can be reused 7 times without significant loss of recovery. After 10 applications the recovery decreased to approx. 50%.     

分子印迹基质固相分散-液相色谱法测定牛奶中的氯霉素残留

以对模板分子具有较强识别特性的分子印迹聚合物为基质固相分散吸附剂, 提取牛奶中痕量氯霉素, 最后用HPLC法测定. 研究了氯霉素分子印迹聚合物对样品中氯霉素的提取和净化效果, 在优化条件下, 方法的检出限为0.15 ng/mL, 定量限为0.50 ng/mL. 不同氯霉素添加量的回收率大于93.2%, RSD＜5.9%. 方法适用于牛奶中氯霉素残留的测定.