首页 | 本学科首页   官方微博 | 高级检索  
     检索      

神府煤煤岩显微组分的浮选分离及富集物的低温热解产物特性研究
引用本文:赵 伟,张晓欠,周安宁,杨志远.神府煤煤岩显微组分的浮选分离及富集物的低温热解产物特性研究[J].燃料化学学报,2014,42(5):527-533.
作者姓名:赵 伟  张晓欠  周安宁  杨志远
作者单位:College of Chemistry & Chemical Engineering, Xi'an University of Science and Technology, Xi'an 710054, China
基金项目:国家自然科学基金(51174279);国家科技重大专项(2011ZX05037-003);陕西省“13115”科技创新工程重大科技专项(2008ZDKG-53)
摘    要:研究了神府煤煤岩显微组分的浮选法分离及富集物的低温热解产物特性,考察了矿浆pH值对浮选分离效果的影响,探讨了显微组分富集率对低温热解产物收率的影响,对比分析了显微组分富集物低温热解产物特性,为煤岩显微组分的分级利用提供理论指导。结果表明,调节矿浆pH值可控制煤岩显微组分的分离效果;煤样中镜质组含量越高,低温热解的焦油收率越高,而惰质组含量越高,焦油收率越低,半焦收率越高;镜质组富集物低温热解后半焦表面出现明显的大孔和裂隙,惰质组富集物低温热解后半焦的结构更加疏散、易碎,小颗粒增多;神府煤及各显微组分富集物低温热解焦油中酚类物质的相对含量较高,镜质组富集物热解焦油中的酚类、萘类和链烃类物质含量高于惰质组,而惰质组富集物焦油中多环芳烃类及苯类相对含量较高;神府煤及各显微组分富集物低温热解气的主要成分为CH4、H2、CO、CO2及少量C2~5碳氢物,镜质组富集物热解气中CH4、H2及C2~5的相对累积产率高于惰质组,而CO和CO2产率低于惰质组,原煤热解气中CH4和H2的相对累积产率高于镜质组和惰质组。

关 键 词:煤岩显微组分  浮选分离  低温热解  产物特性  
收稿时间:2013-10-12

Flotation separation of Shenfu coal macerals and low temperature pyrolysis characteristics of different maceral concentrate
ZHAO Wei,ZHANG Xiao-qian,ZHOU An-ning,YANG Zhi-yuan.Flotation separation of Shenfu coal macerals and low temperature pyrolysis characteristics of different maceral concentrate[J].Journal of Fuel Chemistry and Technology,2014,42(5):527-533.
Authors:ZHAO Wei  ZHANG Xiao-qian  ZHOU An-ning  YANG Zhi-yuan
Abstract:The flotation separation of Shenfu coal macerals and the low temperature pyrolysis characteristics of its concentrates were carried out. The effect of pulp pH value on flotation separation and the impact of maceral enrichment ratio on low temperature pyrolysis were studied. A contrastive analysis was conducted on the characteristics of maceral concentrates in low temperature pyrolysis, providing theory guidance for classifying utilization of coal macerals. The results show that the separation effect of macerals can be manipulated through adjustment of pulp pH value. The more vitrinite exists in the coal sample, the higher the tar yield in low temperature pyrolysis is. But the more inertinite existing in the coal sample highers the semicoke yield. The surface of semicoke from vitrinite concentrates shows clear holes and cracks, and the semicoke structure of inertinite concentrates becomes more dispersive and fragile and an increase in small particles is found. Shenfu coal and its various macerals concentrates show a relative high content of phenols in its tar from low temperature pyrolysis. More phenols, naphthalenes and hydrocarbons exist in the tar from vitrinite concentrates, whereas more cyclophanes and benzenes are found in inertinite tar. The gas compositions of Shenfu coal and its concentrates in low temperature pyrolysis are CH4, H2, CO2 and a bit of C2~5. The relative cumulative yield of CH4, H2, and C2~5 in low temperature pyrolysis gas from vitrinite concentrates is higher than those from inertinite, but the CO and CO2 is lower than that from inertinite. The relative cumulative yield of CH4 and H2 is higher in pyrolysis gas of Shenfu raw coal than that from vitrinite and inertinite.
Keywords:coal maceral  flotation separation  low temperature pyrolysis  characteristic of fractions  
本文献已被 CNKI 等数据库收录!
点击此处可从《燃料化学学报》浏览原始摘要信息
点击此处可从《燃料化学学报》下载免费的PDF全文
设为首页 | 免责声明 | 关于勤云 | 加入收藏

Copyright©北京勤云科技发展有限公司  京ICP备09084417号