首页 | 本学科首页   官方微博 | 高级检索  
     检索      

多匹配层空气耦合压电超声换能器*
引用本文:卞加聪,胡文祥,周八妹.多匹配层空气耦合压电超声换能器*[J].应用声学,2018,37(1):96-100.
作者姓名:卞加聪  胡文祥  周八妹
作者单位:同济大学声学研究所 上海 200092,同济大学声学研究所 上海 200092,同济大学声学研究所
基金项目:国家自然科学基金项目 (11374230, 11774264)
摘    要:该文针对超声无损检测与成像功能空气耦合换能器开展了分析计算和研制。为解决压电材料与空气间巨大的阻抗失配问题,进行了多匹配层设计,并基于有限元技术仿真设计了1-3压电复合材料参数。借助复数压电方程,导出考虑损耗的多匹配层压电复合材料换能器厚度振动等效电路,获得其等效导纳,以此计算电导谱,同时基于有限元技术数值计算相应电导谱,二者有较好的一致性。在此基础上分别设计制作复合压电材料,多匹配层材料以及由此构成的空气耦合超声换能器。换能器的实测电导谱与数值仿真结果一致。进一步的换能器回波信号测试及其谱分析结果表明,所研制的160 k Hz中心频率空气耦合换能器样品有较好灵敏度和带宽。这些结果说明,该文研制的空气耦合超声换能器的初样是成功的。

关 键 词:空气耦合超声换能器  多匹配层  压电复合材料
收稿时间:2017/11/1 0:00:00
修稿时间:2017/12/26 0:00:00

Multi-matching layer air-coupled piezocomposite ultrasonic transducer
Bian Jiacong,Hu WenXiang and Zhou BaMei.Multi-matching layer air-coupled piezocomposite ultrasonic transducer[J].Applied Acoustics,2018,37(1):96-100.
Authors:Bian Jiacong  Hu WenXiang and Zhou BaMei
Institution:Institute of Acoustics,Tongji University,Institute of Acoustics,Tongji University,Institute of Acoustics,Tongji University
Abstract:This paper describes our work on the numerical analysis, design, fabrication for air-coupled piezocomposite ultrasonic transducer employed in the NDT and imaging or materials characterization. The parameters of multi-matching layer and 1-3 connectivity composite are designed through numerical simulation technique in order to overcome the enormous impedance mismatch between air and piezoelectric element. Using complex piezoelectric equation, the thickness vibration equivalent circuit with an introducing attenuation for multi-matching layer air-coupled piezocomposite ultrasonic transducer is deduced, its equivalent admittance is then obtained to calculate the conductivity spectrum of this kind transducer. This spectrum is also calculated by finite element method. Both results are in good agreement. Based on these numerical results and parameters, the piezocomposite, multi-matching layer, and the air-coupled ultrasonic transducer are designed and fabricated. The experimental testing result of the conductivity spectrum for the transducer is agreed with the numerical results. The echo signal of the transducer and its frequency spectrum are further tested and analyzed. These results show that the transducer with a central frequency 160kHz have fairly good sensitivity and frequency bandwidth, and the success on this development is also demonstrated by these results.
Keywords:Air-coupled  ultrasonic transducer  multi-matching  layer  piezocomposite
本文献已被 CNKI 等数据库收录!
点击此处可从《应用声学》浏览原始摘要信息
点击此处可从《应用声学》下载免费的PDF全文
设为首页 | 免责声明 | 关于勤云 | 加入收藏

Copyright©北京勤云科技发展有限公司  京ICP备09084417号