激光限制结晶技术制备nc-Si/SiO2多层膜

在等离子体增强化学气相淀积系统中，采用aSi:H层淀积和原位等离子体氧化相结合的逐层生长技术制备了aSi:H/SiO_2多层膜.在激光诱导限制结晶原理基础上，使用KrF准分子脉冲激光为辐照源，对aSi:H/SiO_2多层膜进行辐照，使纳米级厚度的aSi:H子层晶化.Raman散射谱和电子衍射谱的结果表明，经过激光辐照后纳米Si颗粒在原始的aSi:H子层内形成，晶粒尺寸可以根据aSi:H层的厚度精确控制.还研究了样品的光致发光（PL）特性以及激光辐照能量密度对PL性质的影响. 关键词： 脉冲激光 多层膜 限制结晶     

纳米Si/SiO2多层膜的结构表征及发光特性

采用等离子体化学气相沉积系统生长非晶硅薄膜并用原位等离子体氧化的方法制备出具有不同子层厚度的非晶Si/SiO₂多层膜,然后利用限制性晶化原理使非晶硅层晶化生成纳米硅。利用Raman、TEM等手段对薄膜结构进行了系统表征,在室温下观测到了光致发光信号,其发光峰峰位在750nm附近。进而在样品上下表面蒸镀电极,构建了电致发光原型器件并观测到了室温下的电致发光谱,开启电压约为6V,有两个明显的发光带,分别位于在650nm和520nm处。初步探讨了纳米硅及纳米硅/二氧化硅界面态对发光特性的影响。     

The origin of blue photoluminescence from nc-Si/SiO2 multilayers

Intensive blue photoluminescence (PL) was observed at room temperature from the nanocrystalline-Si/SiO$_{2}$ (nc-Si/SiO$_{2})$ multilayers (MLs) obtained by thermal annealing of SiO/SiO$_{2}$\,MLs for the first time. By controlling the size of nc-Si formed in SiO sublayer from 3.5 to 1.5 nm, the PL peak blueshifts from 457 to 411 nm. Combining the analysis of TEM, Raman and absorption measurement, this paper attributes the blue PL to multiple luminescent centres at the interface of nc-Si and SiO$_{2}$.     

基于Si-rich SiNx/N-rich SiNy多层膜结构的量子点构筑及发光特性

利用等离子体增强化学气相沉积法制备Si-rich SiN_x/N-rich SiN_y多层膜,分别使用热退火和激光辐照技术对多层膜进行退火,以构筑三维限制、尺寸可控、有序的硅纳米晶.实验结果表明,经退火后,纳米硅晶粒在Si-rich SiN_x子层内形成,其尺寸可由Si-rich SiN_x子层厚度调控.实验还发现,激光辐照技术相比于热退火能更有效地改善多层膜的微结构,提高多层膜的晶化率,以激光技术诱导晶化的Si-rich SiN_x/N-rich SiN_y多层膜作为有源层构建电致发光器件,在室温下观察到了增强的电致可见发光,并且发光效率较退火前提高了40%以上. 关键词： 氮化硅 多层膜 限制结晶 纳米晶硅     

Electron beam evaporation deposition of cadmium sulphide and cadmium telluride thin films： Solar cell applications7

Cadmium sulphide （CdS） and cadmium telluride （CdTe） thin films are deposited by electron beam evaporation. Atomic force microscopy （AFM） reveals that the root mean square （RMS） roughness values of the CdS films increase as substrate temperature increases. The optical band gap values of CdS films increase slightly with the increase in the substrate temperature, in a range of 2.42-2.48 eV. The result of Hall effect measurement suggests that the carrier concentration decreases as the substrate temperature increases, making the resistivity of the CdS films increase. CdTe films annealed at 300 ℃ show that their lowest transmittances are due to their largest packing densities. The electrical characteristics of CdS/CdTe thin film solar cells are investigated in dark conditions and under illumination. Typical rectifying and photovoltaic properties are obtained.     

Strong Green Light Emission from Low-Temperature Grown a-SiNx:H Film after Different Oxidation Routes

Room-temperature deposited amorphous silicon nitride （a-SiNx ：H） films exhibit intense green light emission after post-treated by plasma oxidation, thermal oxidation and natural oxidation, respectively. All the photoluminescence （PL） spectra are peaked at around 500nm, independent of oxidation method and excitation wavelength. Compared with the PL results from oxidized a-Si：H and as-deposited a-SiNx：H samples, it is indicated that not only oxygen but also nitrogen is of an important role in enhancing light emission from the oxidized a-SiNx：H. Combining the PL results with the analyses of the bonding configurations as well as chemical compositions of the films, the strong green light emission is suggested to be from radiative recombination in luminescent centres related to N Si-O bonds.     

激光晶化形成纳米硅材料的场电子发射性质研究

利用KrF准分子激光退火超薄非晶硅膜,并结合热退火技术制备了单层纳米硅薄膜并研究了薄膜的场电子发射性质.在晶化形成的纳米硅薄膜中可以观测到稳定的场电子发射现象,其开启电场从原始淀积的非晶硅薄膜的17V/μm降低到8.5V/μm,而场发射电流密度可以达到0.1mA/cm².激光晶化后形成的纳米硅材料的场电子发射特性的改善可以从薄膜表面形貌的改变以及高密度纳米硅的形成所导致的内部电场增强作用来解释. 关键词： 纳米硅 场发射 激光晶化     

激光干涉结晶法制备一维周期结构的纳米硅阵列

利用激光干涉结晶方法,采用周期为400 nm的一维(1D)移相光栅掩模调制KrF准分子激光器的脉冲激光束斑的能量分布,在不同厚度的超薄氢化非晶硅(a-Si:H)膜内直接制备1D有序纳米硅(nc-Si)阵列.拉曼散射谱表明,样品上呈条状分布的受辐照区域发生晶化.原子力显微镜和透射电子显微镜测试结果表明：1D的nc-Si阵列的周期和移相光栅掩模一样.随着a-Si:H膜厚度从10nm降至4nm,通过控制激光的能量密度,每个周期中nc-Si条状分布区宽度可达到30nm.nc-Si条状分布区的高分辨电子显微镜照片显 关键词： 纳米硅 激光干涉结晶 移相光栅 定域晶化     

Discrete Charge Storage Nonvolatile Memory Based on Si Nanocrystals with Nitridation Treatment

A nonvolatile memory device with nitrided Si nanocrystals embedded in a floating gate was fabricated. The uniform Si nanocrystals with high density （3× 10^11 cm^-2 ） were deposited on ultra-thin tunnel oxide layer （- 3 nm） and followed by a nitridation treatment in ammonia to form a thin silicon nitride layer on the surface of nanocrystals. A memory window of 2.4 V was obtained and it would be larger than 1.3 V after ten years from the extrapolated retention data. The results can be explained by the nitrogen passivation of the surface traps of Si nanoerystals, which slows the charge loss rate.     

Structural evolution of a-Si:H/SiO2 multilayers upon step by step thermal annealing

a-Si:H/SiO_2 multilayers were prepared by alternatively changing plasma enhanced chemical vapour deposition of a-Si:H layers and in situ plasma oxidation process. Subsequently, as-grown samples were annealed at temperatures from 350℃ to 1100℃ in N_2 ambient with an increment of 100℃. The evolution of bonding configurations and structures with annealing treatments was systematically investigated by Fourier-transform infrared spectroscopy. The peak position of Si－O stretching vibration of SiO_2 layers shift to 1087cm^{-1} after annealing at 1100℃, which demonstrates that the SiO_2 films fabricated by plasma oxidation after high temperature annealing can have similar properties to the thermal grown ones. A Si－O vibration from interfacial SiO_x was identified: the value x was found to increase as increasing the annealing temperature, which is ascribed to the cooperation of hydrogen effusion and reordering of the oxygen bond in SiO_x networks. The H-related bonds were observed in the form of H－Si－O_3 and H－Si－Si_{3-n}O_n (n=1－2) configurations, which are supposed to be present in SiO_2 and interfacial SiO_x layers, respectively. The H atoms bonded in different bonding configurations effuse at different temperatures due to their different desorption energies.