Phase-field study of the second phase particle effect on texture evolution of polycrystalline material

The second phase particle effect on texture evolution of polycrystalline material is studied through phase-field method. A unique field variable is introduced into the phase-field model to represent the second phase particles. Elastic interaction between particles and grains is also considered. Results indicate that in the presence of second phase particles the average particle diameter turns smaller than in the absence of these particles and retards texture formation by pinning effect. The second phase particles change the strain energy profile, which tremendously influences the pinning effect.     

Dendrite to symmetry-broken dendrite transition in directional solidification of non-axially oriented crystals

In this paper, the morphological transition from dendrite to symmetry-broken dendrite is investigated in the directional ;olidification of non-axially-oriented crystals using a quantitative phase-field model. The effects of pulling velocity and zrystal orientation on the morphological transition are investigated. The results indicate the orientation dependence of the ;ymmetry-broken double dendrites. A dendrite to symmetry-broken dendrite transition is found by varying the pulling telocity at different crystal orientations and the symmetry-broken multiple dendrites emerge as a transition state for the ;ymmetry-broken double dendrites. The state region during the transition can be well characterized through the variations ff the characteristic angle and the average primary dendritic spacing.     

受迫流动下的枝晶生长相场法模拟研究

基于耦合流场和热噪声的相场模型及合理高效的三维动态求解域加速算法,定量模拟了在受迫流动下枝晶的非对称生长及流速对迎流、背流两侧的温度分布和层流层分布的影响.计算结果表明,受迫流动使迎流、背流两侧温度的分布与层流层分布呈现不对称状态,导致迎流侧与背流侧的过冷度不同,而熔体施加于枝晶界面前沿迎流侧的力还不足以抑制过冷度的作用,结果造成枝晶迎流方向优先生长,从而产生倾向于散热方向的倾斜,同时,由于迎流侧的实际过冷度大于背流侧,有利于促进迎流一侧枝晶生长速度以及稳定侧向分枝生长,从而导致了侧向分枝的非对称生长.随     

相场法模拟多元合金过冷熔体中的枝晶生长

在二元合金相场模型研究的基础上，进行扩展获得了多元合金相场模型.以Al-Si-Mg三元合金为例，采用该相场模型实现了逼真地模拟多元合金凝固过程的等轴枝晶生长，得到了二次或更高次晶臂生长等复杂的枝晶形貌.随着第三组元Mg含量的减少，枝晶的二次枝晶越发达，枝晶中溶质的偏析越严重，枝晶尖端的生长速率和半径越大，与丁二腈-丙酮体系中枝晶尖端生长速率、半径随溶质浓度变化关系的理论计算和实验结果相符合.另外，枝晶初生晶臂中心的溶质浓度最低，在被二次晶臂包围的界面区域的溶质浓度最高；固液界面区域具有较大的浓度梯度，其中枝晶尖端前沿的梯度最大. 关键词： 相场法 多元合金 凝固过程 枝晶生长     

相场法模拟弹性场对沉淀相变组织演化及相平衡成分的影响

采用相场法模拟沉淀组织在不均匀共格本征弹性场及外加约束弹性应变作用下的演化历程，探讨了不均匀共格本征弹性场及外加约束弹性应变对共格沉淀组织演化的影响规律，并分析了弹性场在沉淀相变中对基体与沉淀相的平衡成分的影响. 关键词： 相场法 沉淀组织 弹性场 相平衡成分     

Phase-field modeling of growth pattern selections in three-dimensional channels

In this paper, the anisotropic crystal growth in three-dimensional channels was studied using a thin-interface phase-field model. Different growth modes and dynamics behaviours, including planar front, stationary symmetrical single finger, oscillatory symmetrical single finger and multiple-finger structure, have been observed as the undercooling is increased. Lower boundary of undercooling for symmetrical single finger results from the tip-widening while the upper boundary results from the tip-splitting instability. Results show that the existence range of the symmetrical single finger depends on crystalline anisotropy, channel size and dimensionality. Moreover, an oscillatory instability, involving tip velocity and tip radius oscillations, was evidenced when the undercooling is close to but below the upper boundary. We found that the oscillatory symmetrical single finger strongly depends on the channel size and the crystalline anisotropy. Mechanism of the oscillatory mode has been discussed in details.     

BCC枝晶生长原子堆垛过程的晶体相场研究

通过在自由能泛函中引入各向异性参数得到了一个基于高斯内核的改进晶体相场模型, 并采用该模型研究了体心立方结构(BCC)枝晶生长的原子堆垛过程. 结果表明, 在BCC由正十二面体平衡形貌演化为枝晶组织过程中, 形核位置经历了由面心({110}面)到尖端(<100>取向)的转移, 进而发生界面失稳形成枝晶组织; 枝晶生长过程中, 新的固相原子首先在枝晶尖端附近形核, 并快速向尖端及根部生长, 枝晶尖端被新原子完全包覆后将再次诱发液相原子附着形核及生长; 随初始液相密度的增加, 固-液界面移动速率增加, 速率系数的各向异性也增强.     

镁基合金自由枝晶生长的相场模拟研究

利用定量相场模型, 以Mg-0.5 wt.%Al合金为例模拟了基面((0001)面)内镁基合金的等温自由枝晶生长过程. 通过研究该合金体系数值模拟的收敛性, 获得了最优化值耦合参数λ = 5.5及网格宽度Δx/W₀ = 0.4, 并在该参数下系统研究了各向异性强度和过饱和度对枝晶尖端生长速度、尖端曲率半径、Péclet数及稳定性常数σ^* 的影响. 结果表明, 由微观可解性理论得到的稳定性系数σ^* 与ε₆ 拟合值σ^*≅ ε₆ ^1.81905, 更接近理想值σ ^* (ε₆) ≅ε₆ ^1.75. 此外, 当过饱和度Ω < 0.6时, 稳定性系数σ ^* 不随ε₆ 的变化而变化, 而当Ω > 0.6时, 稳定性系数σ ^* 随着ε₆ 的增加而减小. 这反映了枝晶的生长由扩散控制向动力学控制的转变. 随着过饱和度的增加, 枝晶形貌由雪花状枝晶向圆状枝晶转变.     

力和扩散机理下外延形貌的演化分析

本文提出了一个新的基于扩散界面的相场模型来描述外延生长中岛的形核、生长及熟化过程. 该模型同时考虑了弹性场、表面能、沉积、扩散、解吸和能量势垒等热力学及动力学过程对表面纳米形貌的影响. 采用经典的BCF模型来描述生长中的扩散形核过程, 而采用一个新的包含弹性应变能的自由能函数, 通过变分得到一个描述多层岛生长的相场方程, 该方法可以有效地描述外延生长中复杂的外延形貌. 采用有限差分格式对非线性耦合方程组进行求解. 数值结果显示, 该模型可以真实地再现外延生长中多层岛结构(即山丘状形貌)的演化过程, 模拟结果与已有实验结果一致. 同时模拟了生长过程中随外延形貌演化而形成的复杂生长应力, 研究表明, 在生长过程中, 岛中存在着复杂的应力分布, 且在岛边界处应力达到局部最大, 这与实验结果定性一致. 此外, 本文的重要发现是, 外延生长中的应力演化明显地影响原子的扩散过程, 当应力存在时, 外延结构变化较无弹性场时变快. 该项研究对理解外延生长中各物理机理的协同作用有重要的指导意义.     

Diffuse-Interface Treatment of the Anisotropic Mean-Curvature Flow

We investigate the motion by mean curvature in relative geometry by means of the modified Allen-Cahn equation, where the anisotropy is incorporated. We obtain the existence result for the solution as well as a result concerning the asymptotical behaviour with respect to the thickness parameter. By means of a numerical scheme, we can approximate the original law, as shown in several computational examples.