基于氯化镁饱和溶液中固定化脂肪酶Lipozyme TL IM催化光皮树油脂合成生物柴油

基于氯化镁饱和溶液反应体系中,对采用固定化脂肪酶Lipozyme TL IM催化光皮树油脂转化为生物柴油的工艺进行了研究。考察了固定化脂肪酶Lipozyme TL IM催化光皮树油转酯化的工艺中甲醇的用量、固定化脂肪酶的添加量、摇床的转速和反应时间对生物柴油产率的影响。实验结果表明,采用氯化镁饱和溶液反应体系,在醇油摩尔比为3∶1,固定化酶Lipozyme TL IM用量为光皮树油质量的20%,摇床转速为150 r/min,反应8 h时,生物柴油产率最高,达到86.5%。与传统的三步甲醇醇解或者有机溶剂反应体系比较,采用的氯化镁饱和溶液体系的酶稳定性更好,反应效率更高,有效地解决了酶在甲醇中失活的问题,生产成本低,可成为生产生物柴油的新工艺。     

固定化扩展青霉脂肪酶的制备及其在玉米油转酯反应中的应用

采用吸附法对来源于扩展青霉Penicillium expansum的脂肪酶进行了固定化.从20种不同来源的树脂中筛选出固定化效率高且价格低廉的D4020树脂作为载体,系统研究了固定化条件对固定化效率及固定化酶转酯活力的影响.结果表明,最适加酶量、缓冲液pH和吸附时间分别为0.7 g/g、9.4和4 h.冻干时添加0.5%的半乳糖有助于提高固定化酶的转酯活力.在上述优化条件下,固定化酶的转酯活力为404.0 U/g,而所用的游离酶不能催化该转酯反应.利用该固定化酶催化玉米油转酯反应生产生物柴油时,叔戊醇为适宜的反应介质,其最适添加量为0.5 ml/g;适宜的酶量、加水量和反应温度分别为60.6 U/g、油重的1.2%和35℃.按醇/油摩尔比为1的比例分别在反应0、2和6 h时加入甲醇,在优化反应条件下,反应24 h后甲酯产率达85.0%;固定化脂肪酶具有较好的操作稳定性,反应10批次时,相对酶活力为62.8%.     

柴油溶剂中脂肪酶催化高酸值废油脂酯化制备生物柴油

采用0＃柴油作为反应溶剂,利用固定化脂肪酶催化高酸值废油脂与甲醇酯化反应制备生物柴油。来源于Candida antarctica的固定化脂肪酶Novozym435在0＃柴油溶剂中具有极高的催化活性。以酸价高达157×10-3的废油脂为原料,废油脂质量比10%的Novozym435,甲醇与废油脂初始摩尔比2∶1,0＃柴油与废油脂质量比5∶1,摇床摇速170r/min,50℃下反应2h甲酯化率可达95.10%。0＃柴油作为反应溶剂有效地溶解了高酸值废油脂和甲醇,降低了反应体系的黏度和消除了甲醇对Novozym435的负面影响,提高了Novozym435的稳定性。同时,0＃柴油溶剂对未脱胶废油脂中残留的对脂肪酶有害的磷脂等胶类物质具有一定的稀释作用。该工艺省却了溶剂蒸馏的繁琐工序,直接得到脂肪酸甲酯和石化柴油的混合燃料。     

固定化脂肪酶催化碳酸二甲酯制备生物柴油的研究

以介孔硅材料(MPS)为载体将脂肪酶固定化,以碳酸二甲酯为酰基受体,对固定化酶催化碳酸二甲酯进行了反应路径(原料油)、反应条件(反应温度、碳酸二甲酯的用量、加水量)的优化,在最佳的条件下对实验过程中所用的固定化酶进行重复使用性的考察.实验结果表明,不同种油与碳酸二甲酯反应在同定化酶的催化下制备生物柴油的产率以麻疯树油为最高,最佳反应条件是碳酸二甲酯的浓度为16mL/g、不加水,在50℃下反应24h,生物柴油得率达81.6％.     

无溶剂系统中固定化脂肪酶催化废油脂转酯生产生物柴油

 探讨了无溶剂系统中固定化脂肪酶Novozym 435催化餐饮业废油脂转酯生产生物柴油. 反应副产物甘油可吸附在固定化酶载体表面,采用丙酮洗涤除去甘油可提高酶的稳定性. 适宜的醇/油摩尔比、酶用量、反应温度和摇床转速分别为1, 6.6 U/g, 35～40 ℃和150 r/min,不宜加水到反应体系中. 采用分步加入甲醇的方式可减轻甲醇对酶的毒害作用. 分别在反应进行到6和14 h时用丙酮除去酶表面的甘油,然后按醇/油摩尔比为1的比例加入甲醇继续反应,反应30 h后产物中的脂肪酸甲酯含量为88.6%. 连续反应300 h后,酶活性基本没有下降.     

甲壳胺-硅胶复合载体的制备及其在脂肪酶固定化中的应用

固定化脂肪酶;甲壳胺-硅胶复合载体的制备及其在脂肪酶固定化中的应用     

微乳液凝胶固定化脂肪酶催化α-单硬脂酸甘油酯水解反应活性

微乳液凝胶固定化脂肪酶催化α-单硬脂酸甘油酯水解反应活性;微乳液凝胶;固定化脂肪酶;催化活性;水解反应;α-单硬脂酸甘油酯     

交联烯丙基葡聚精凝胶固定化脂肪酸的研究

本文研究了烯丙基葡聚糖和N、N＇－亚甲基双丙烯酰胺经反相悬浮聚合包埋固定化脂肪酶的方法。考察了悬浮介质、交联度对固定化酶的影响，得出了包埋固定化脂肪酶的最佳条件；并测定了固定化脂肪酶的催化性能，确定了该固定化酶催化橄榄油水解的最适条件。     

一种新的酶载体的制备及其在脂肪酶固定化中的应用

将３－（２,３－环氧丙基氧）丙基三甲氧基硅烷与经酸处理过的硅胶反应,制得３－（２,３－环氧丙基氧）丙基硅胶,每克硅胶上含３－（２,３－环氧丙基氧）丙基１．３２ｍｍｏｌ。以－（２,３－环氧丙基氧）硅胶为载体进行了脂肪酶的固定化,在固定化反应中,反应液中的酶仍保持着较高的活性,能回收循环使用。     

猪胰脂肪酶的固定化及其在有机相中催化丁酸甲酯和正丁…

考察了大孔苯乙烯－二乙烯苯交联共聚物的交联度、致孔剂理及胺化试剂对载体固定化猪胰脂肪酶的影响。选择出一种最佳载体对猪胰脂肪酶进行固定化，对比了自由酶和固定化酶在有机相中催化丁酸甲酯和正丁醇的酯交换反应。结果表明，酶经固定化后催化反应活力比自由酶提高近１倍。     

Dichroism of absorption and polarization of phosphorescence of molecules of the closed form of nitrobenzospirothiopyran

The spectral-polarization characteristics of absorption and phosphorescence of molecules of the initial form of nitro-substituted indolinospirobenzothiopyran were studied in oriented polyethylene films and in solutions with different polarity. An oscillator model of the electron transitions responsible for the formation of absorption and luminescence spectra was suggested. It was established that the principal differences in the spectral and photophysical properties of the compound studied and its oxygen-containing analog are associated with the fact that the electronegativity of the S atom is lower than that of the O atom. Translated fromIzvestiya Akademii Nauk. Seriya Khimicheskaya, No. 6, pp. 1143–1146, June, 1997.     

Acid hydrolysis of carboxymethylcellulose of low degree of substitution

Cotton cellulose was swollen in a sodium hydroxide solution and carboxymethylated by a two-bath method for different periods of time for each process. The kinetics of acid hydrolysis and the crystallinity of the swollen and carboxymethylated samples were measured. The proportion of broken bonds, rate constants for hydrolysis, and permeability of cellulose to hydrolyzing agents were calculated. The susceptibility of glycosidic linkages to acid hydrolysis was improved by carboxymethylation more than by swelling in alkali. The increased accessibility of carboxymethylcellulose to acid was regarded as a consequence of increased intra-and intercrystalline swelling and of the glycosidic bonds' weakness caused by the electron-attracting carboxymethyl group on the C-6 position.     

Estimation of Kinetic Parameters of Thermal Oxidation of Ilmenite

The aim of the presented work was the investigation of thermal oxidation of ilmenite in static air atmosphere. The investigations were carried out by use of a derivatograph (MOM, Hungary). The changes of crystallographic structure of investigated samples were identified by X-ray diffractometry on Philips PW-1710 diffractometer. In temperature above 500°C appears structure of hematite Fe₂O₃. On the basis of the thermogravimetric measurements, the contracting area and contracting volume models were found as the best fitting experimental data. This revised version was published online in August 2006 with corrections to the Cover Date.     

Mechanism of action of base-catalyzed oxygenation of phenol derivatives

Cyclopropyl derivative of 2,6-di-tert-butylphenol is synthesized as a probe to investigate the mechanism of base-catalyzed autooxidation of phenol derivatives. Our study indicates that one electron reduction of molecular oxygen from phenolate gives phenoxyl radical 3, a key intermediate of autooxidation. The coupling of phenoxyl radical and superoxide radical gives peroxylate anion 4 and produces the final epoxy alcohol adduct 6.     

非那雄胺合成工艺改进

非那雄胺能抑制5α-还原酶的活性,明显降低二氢睾酮水平,是一种治疗良性前列腺增生的有效药品。该合成工艺以甾烯酮酸为原料,将其与氯化亚砜反应,无须分离即与叔丁胺反应得17β-酰胺化合物,再氧化开环,环合,氢化,脱氢合成了非那雄胺。经元素分析、IR、1HNMR、13CNMR、MS分析表征了其结构。该法无须使用昂贵的2,2-二吡啶二硫化物和剧毒药品苯亚硒酸酐,且以乙酸铵代替氨气,降低了对设备的要求和腐蚀,更适用于工业生产。     

化学计量中不确定度评定研究进展

测量不确定度是表征合理地赋予被测量之值的分散性的参数。本文针对化学计量不确定度评定基础模型仅适用于线性模型、概率分布为正态分布或缩放位移t分布等局限,介绍了近年来不确定度评定的研究热点:蒙特卡罗方法(Monte Carlo Method,MCM),不确定度评定的来源、评定概念、评估方法及其发展过程,扩大了测量不确定度评定与表示的适用范围。     

Determination of heats of detonation and influence of components of composite explosives on heats of detonation of high explosives

The heats of detonation of 20 simple high explosives and explosive mixtures were determined by means of an adiabatic detonation calorimeter designed by the authors. The results indicated that the performance of the instrument was reliable and the experimental data were very accurate. For explosive mixtures, there was a linear accumulative relationship between the heats of detonation of the explosive mixture and its components. Accordingly, the heats of detonation of explosive mixtures could be calculated directly from the heats of detonation of simple explosives and the characteristic heats of other components. The experiments showed that the gold or brass shell of the cylindrical charge could be substituted by a thick-walled porcelain shell, which had the advantage of cheapness.

     

微量钙的测定方法研究进展

介绍了1995-2006年期间测定微量和痕量钙的方法,如电感耦合等离子体-原子发射光谱法、原子吸收光谱法以及离子色谱法等的工作原理和特点,并说明了其测定微量钙的应用领域。并对微量钙的测定技术进行了展望(引用文献55篇)。     

Stages of thermal decomposition of sodium oxo-salts of sulphur

Thermal behaviour of sodium oxo-salts of sulphur: Na₂SO₄, Na₂S₂O₇, Na₂S₂O₆, Na₂SO₃, Na₂S₂O₅, Na₂S₂O₄, Na₂S₂O₃, Na₂S₃O₆ and of sulphides Na₂S and Na₂S₂ was studied on heating up to 1000°C. The experiments were performed with anhydrous compounds obtained from commercial products by recrystallisation and dehydration. The stage mechanisms of decomposition of anionic sub-lattices of the salts have been proposed basing on the Górski’s morphological classification of simple species. The thermal stability and the stage decomposition mechanisms were correlated with the structure and the potential chemical properties of the salt anions. The thermal decomposition processes were studied by means of thermal analysis, and the decomposition products were identified by means of X-ray phase analysis.     

Synthesis of phenolic components of Grains of Paradise

Two vanilloids, (5E)-8-(4-hydroxy-3-methoxyphenyl)oct-5-en-4-one (1) and 4-[3-hydroxydecyl]-2-methoxyphenol (2), isolated from the dried seeds of Grains of Paradise (Aframomum melegueta), were synthesized; the latter compound was made as the S-enantiomer and the material derived from the seeds was found to be a 1:1.7 mixture of the R and S isomers. The synthetic route used should allow the preparation of analogs having extended alkyl chains and consequently different lipophilicity, and 3, a homolog of 2, was also prepared.