Efficient purification of high‐purity compounds from the stem of Lonicera japonica Thunb using two‐dimensional preparative chromatography

Purification of high‐purity compounds from traditional Chinese medicines (TCMs) plays an important role in investigating their bioactivity. Nevertheless, it is often quite difficult to isolate compounds with high purity because of the complexity of TCMs in chemical composition. In this work, a two‐dimensional preparation method was successfully developed for the preparation of high‐purity compounds from the stem of Lonicera japonica Thunb, based on two novel polar copolymerized RP stationary phases, XAqua C3 and XAqua C18. An XAqua C3 prep column was used to separate the sample in the first‐dimensional preparation, and 14 g of sample was fractionated into eight fractions with a recovery of 82%. An XAqua C18 prep column was selected to prepare high‐purity compounds in the second‐dimensional preparation for its good orthogonality with the XAqua C3 stationary phase. As a result, major compounds in the sample were isolated with more than 99% purity. This method is a potent method to realize the efficient purification of compounds with high purity from the stem of L. japonica Thunb and it shows great potential in the separation of high‐purity compounds from complex samples.     

Two‐dimensional hydrophilic interaction chromatography × reversed‐phase liquid chromatography for the preparative isolation of potential anti‐hepatitis phenylpropanoids from Salvia prattii

Traditional Tibetan medicine is important for discovery of drug precursors. However, knowledge of the chemical composition of traditional Tibetan medicines is very limited due to the lack of appropriate chromatographic purification methods. In the present work, Salvia prattii was taken as an example, and an off‐line hydrophilic interaction liquid chromatography/reversed‐phase liquid chromatography preparative method was developed for the purification of phenylpropanoids with high purity from a crude sample of Salvia prattii. Based on the separation results of four different chromatographic stationary phases, the first‐dimensional preparation was performed on an XAmide preparative column with the crude sample concentration of 62.0 mg/mL, and five main fractions were obtained from the 12.4 g crude sample with a recovery of 54.8%. An XCharge C₁₈ preparative column was applied in the second‐dimensional preparation to further isolate the phenylpropanoids from the redissolved first‐dimensional fractions with concentration of approximately 50.0 mg/mL. The purities of the phenylpropanoids isolated from the crude sample of Salvia prattii were higher than 98%, indicating that the method was efficient for the purification of phenylpropanoids with high purity from Salvia prattii. Additionally, this method showed great potential in the preparation of phenylpropanoids and can serve as a good example for the purification of phenylpropanoids from other plant materials.     

A novel two‐dimensional preparative chromatography method designed for the separation of traditional animal Tibetan medicine Osteon Myospalacem Baileyi

Animal medicine is an important part in traditional Tibetan medicine. However, information about the chemical composition of animal medicine is very limited, and there is a lack of comprehensive chromatographic purification methods. In the present work, animal medicine Osteon Myospalacem Baileyi was taken as an example and a novel two‐dimensional preparative chromatographic method was established for the preparation of single compounds with high purity from the extract of Osteon Myospalacem Baileyi. The first‐dimension preparation was carried on a DAISO Silica prep column, and ten fractions were obtained from the 112.3 g crude sample within 12 injections. A diol prep column used in nonaqueous mobile phase was selected for the second‐dimension preparation. The purity of the compounds isolated from the crude extract was >98%, which indicated that the method built in this work was efficient to manufacture single compounds of high purity from the extract of Osteon Myospalacem Baileyi. Additionally, this method showed great potential in the purification of weakly polar chemicals and it could act as a good example in the purification of other traditional animal medicines.     

Preparative isolation of flavonoid glycosides from Sphaerophysa salsula using hydrophilic interaction solid‐phase extraction coupled with two‐dimensional preparative liquid chromatography

An offline preparative two‐dimensional reversed‐phase liquid chromatography/hydrophilic interaction liquid chromatography coupled with hydrophilic interaction solid‐phase extraction method was developed for the preparative isolation of flavonoid glycosides from a crude sample of Sphaerophysa salsula . First, the non‐flavonoids were removed using an XAmide solid‐phase extraction cartridge. Based on the separation results of three different chromatographic stationary phases, the first‐dimensional preparation was performed on an XAqua C18 prep column, and 15 fractions were obtained from the 5.2 g target sample. Then, three representative fractions were selected for additional purification on an XAmide preparative column to further isolate the flavonoid glycosides. In all, eight flavonoid glycosides were isolated in purities over 97%. The results demonstrated that the two‐dimensional liquid chromatography method used in this study was effective for the preparative separation of flavonoid glycosides from Sphaerophysa salsula . Additionally, this method showed great potential for the separation of flavonoid glycosides from other plant materials.     

Purification of lignans from Fructus Arctii using off‐line two‐dimensional supercritical fluid chromatography/reversed‐phase liquid chromatography

As a common traditional Chinese medicine, Fructus Arctii has important clinical medical values. Its main components are lignans, which are difficult to separate and analyze because of the complex composition, similar chemical structures, and close properties. In this study, an off‐line two‐dimensional supercritical fluid chromatography/reversed‐phase liquid chromatography method, as well as an effective sample pretreatment method based on hydrophilic interaction chromatography material, was developed to enrich the minor lignan fractions and obtain high‐purity compounds. In total, 12 high‐purity compounds were isolated from Fructus Arctii . Their structures were identified by using high‐resolution mass spectrometry and nuclear magnetic resonance spectroscopy, which showed that all were lignans and that most of them were isomers. The results demonstrated the effective off‐line two‐dimensional supercritical fluid chromatography/reversed‐phase liquid chromatography method for the purification of lignans from Fructus Arctii . The separation protocol established here will be beneficial for the separation of complex samples from other kinds of natural products.     

Separation of three phenolic high‐molecular‐weight compounds from the crude extract of Terminalia Chebula Retz. by ultrasound‐assisted extraction and high‐speed counter‐current chromatography

This study presents an efficient strategy for separation of three phenolic compounds with high molecular weight from the crude extract of Terminalia chebula Retz. by ultrasound‐assisted extraction and high‐speed counter‐current chromatography. The ultrasound‐assisted extraction conditions were optimized by response surface methodology and the results showed the target compounds could be well enriched under the optimized extraction conditions. Then the crude extract was directly separated by high‐speed counter‐current chromatography without any pretreatment using n‐hexane/ethyl acetate/methanol/water (1:7:0.5:3, v/v/v/v) as the solvent system. In 180 min, 13 mg of A, 18 mg of B, and 9 mg of C were obtained from 200 mg of crude sample. Their structures were identified as Chebulagic acid (A, 954 Da), Chebulinic acid (B, 956 Da), and Ellagic acid (C) by ¹H NMR spectroscopy.     

Preparative isolation and purification of harpagoside and angroside C from the root of Scrophularia ningpoensis Hemsley by high‐speed counter‐current chromatography

In this study, the bioactive component harpagoside and angroside C in the root of Scrophularia ningpoensis Hemsley was simultaneously separated by high‐speed counter‐current chromatography (HSCCC). A two‐phase solvent system containing chloroform/n‐butanol/methanol/water (4:1:3:2, v/v/v/v) was selected following consideration of the partition coefficient of the target compound. The crude extract (200 mg) was loaded onto a 280‐mL HSCCC column and yielded 22 mg harpagoside and 31 mg angroside C with the purity of higher than 98 and 98.5%, respectively. It is feasible to isolate active compounds harpagoside and angroside C from S. ningpoensis using HSCCC.     

Application of high‐speed counter‐current chromatography and HPLC to separate and purify of three polyacetylenes from Platycodon grandiflorum

Three polyacetylenes were isolated and purified from Platycodon grandiflorum A. DC for the first time by high‐speed counter‐current chromatography using a two‐phase solvent system composed of hexane/ethyl acetate/methanol/water (1:31:1:31, v/v/v/v) and high‐performance liquid chromatography with an Agilent ZORBAX® SB‐C18 column (4.6 mm × 150 mm, 5 μm). After separation by high‐speed counter‐current chromatography and high‐performance liquid chromatography, we obtained 3.5 mg of platetyolin A, 4.1 mg of platetyolin B, and 18.1 mg of lobetyolin with purities of 97.2, 96.7, and 96.9%, respectively. The purity of each compound was assessed by high‐performance liquid chromatography and the chemical structures were evaluated by high‐resolution electrospray ionization time‐of‐flight mass spectrometry and one‐ and two‐dimensional NMR spectroscopy. Among the isolated compounds, platetyolin A and platetyolin B are newly reported compounds.     

Purification of flavonoids from licorice using an off‐line preparative two‐dimensional normal‐phase liquid chromatography/reversed‐phase liquid chromatography method

An orthogonal (71.9%) off‐line preparative two‐dimensional normal‐phase liquid chromatography/reversed‐phase liquid chromatography method coupled with effective sample pretreatment was developed for separation and purification of flavonoids from licorice. Most of the nonflavonoids were firstly removed using a self‐made Click TE‐Cys (60 μm) solid‐phase extraction. In the first dimension, an industrial grade preparative chromatography was employed to purify the crude flavonoids. Click TE‐Cys (10 μm) was selected as the stationary phase that provided an excellent separation with high reproducibility. Ethyl acetate/ethanol was selected as the mobile phase owing to their excellent solubility for flavonoids. Flavonoids co‐eluted in the first dimension were selected for further purification using reversed‐phase liquid chromatography. Multiple compounds could be isolated from one normal‐phase fraction and some compounds with bad resolution in one‐dimensional liquid chromatography could be prepared in this two‐dimensional system owing to the orthogonal separation. Moreover, this two‐dimensional liquid chromatography method was beneficial for the preparation of relatively trace flavonoid compounds, which were enriched in the first dimension and further purified in the second dimension. Totally, 24 flavonoid compounds with high purity were obtained. The results demonstrated that the off‐line two‐dimensional liquid chromatography method was effective for the preparative separation and purification of flavonoids from licorice.     

Ionic‐liquid‐based ultrasound‐assisted extraction of isoflavones from Belamcanda chinensis and subsequent screening and isolation of potential α‐glucosidase inhibitors by ultrafiltration and semipreparative high‐performance liquid chromatography

The separation of a compound of interest from its structurally similar homologues to produce high‐purity natural products is a challenging problem. This work proposes a novel method for the separation of iristectorigenin A from its structurally similar homologues by ionic‐liquid‐based ultrasound‐assisted extraction and the subsequent screening and isolation of potential α‐glucosidase inhibitors via ultrafiltration and semipreparative high‐performance liquid chromatography. Ionic‐liquid‐based ultrasound‐assisted extraction was successfully applied to the extraction of tectorigenin, iristectorigenin A, irigenin, and irisflorentin from Belamcanda chinensis . The optimum conditions for the efficient extraction of isoflavones were determined as 1.0 M 1‐ethyl‐3‐methylimidazolium tetrafluoroborate with extraction time of 30 min and a solvent to solid ratio of 30 mL/g. Ultrafiltration with liquid chromatography and mass spectrometry was applied to screen and identify α‐glucosidase inhibitors from B. chinensis , followed by the application of semipreparative high‐performance liquid chromatography to separate and isolate the active constituents. Four major compounds including tectorigenin, iristectorigenin A, irigenin, and irisflorentin were screened and identified as α‐glucosidase inhibitors, and then the four active compounds abovementioned were subsequently isolated by semipreparative high‐performance liquid chromatography (99.89, 88.97, 99.79, and 99.97% purity, respectively). The results demonstrate that ionic liquid extraction can be successfully applied to the extraction of isoflavones from B. chinensis .     

Preparative separation of bioactive compounds from essential oil of Flaveria bidentis (L.) Kuntze using steam distillation extraction and one step high‐speed counter‐current chromatography

In order to utilize and control the invasive weed, bioactive compounds from essential oil of Flaveria bidentis (L.) Kuntze were studied. Steam distillation extraction and one step high‐speed counter‐current chromatography were applied to separate and purify the caryophyllene oxide, 7,11‐dimethyl‐3‐methylene‐1,6,10‐dodecatriene, and caryophyllene from essential oil of Flaveria bidentis (L.) Kuntze. The two‐phase solvent system containing n‐hexane/acetonitrile/ethanol (5:4:3, v/v/v) was selected for the one step separation mode according to the partition coefficient values (K) of the target compounds and the separation factor (α). The purity of each isolated fraction after a single high‐speed counter‐current chromatography run was determined by high performance liquid chromatography. A 3.2 mg of caryophyllene oxide at a purity of 92.6%, 10.4 mg of 7,11‐dimethyl‐3‐methylene‐1,6,10‐dodecatriene at a purity of 99.1% and 5.7 mg of caryophyllene at a purity of 98.8% were obtained from 200 mg essential oil of Flaveria bidentis (L.) Kuntze. The chemical structures of these components were identified by GC‐MS, ¹H‐NMR, and ¹³C‐NMR.     

Separation of five compounds from leaves of Andrographis paniculata (Burm. f.) Nees by off‐line two‐dimensional high‐speed counter‐current chromatography combined with gradient and recycling elution

An off‐line two‐dimensional high‐speed counter‐current chromatography method combined with gradient and recycling elution mode was established to isolate terpenoids and flavones from the leaves of Andrographis paniculata (Burm. f.) Nees. By using the solvent systems composed of n‐hexane/ethyl acetate/methanol/water with different volume ratios, five compounds including roseooside, 5,4′‐dihydroxyflavonoid‐7‐O‐β‐d ‐pyranglucuronatebutylester, 7,8‐dimethoxy‐2′‐hydroxy‐5‐O‐β‐d ‐glucopyranosyloxyflavon, 14‐deoxyandrographiside, and andrographolide were successfully isolated. Purities of these isolated compounds were all over 95% as determined by high‐performance liquid chromatography. Their structures were identified by UV, mass spectrometry, and ¹H NMR spectroscopy. It has been demonstrated that the combination of off‐line two‐dimensional high‐speed counter‐current chromatography with different elution modes is an efficient technique to isolate compounds from complex natural product extracts.     

Purification of compounds from Lignum Dalbergia Odorifera using two-dimensional preparative chromatography with Click oligo (ethylene glycol) and C18 column

Purification of compounds from traditional Chinese medicines (TCMs) is an important task for understanding the chemical composition of TCMs. However, it is difficult to obtain compounds with high enough purity for identification by NMR due to the complexity of TCMs in chemical composition. In this study, a two‐dimensional purification method based on a Click oligo (ethylene glycol) column and a C18 column was developed to realize an orthogonal separation in preparative level for purifying compounds efficiently. The first dimensional preparation was performed on a Click oligo (ethylene glycol) column to simplify the sample into the fractions with good separation repeatability. On the first dimension, 7.2 g sample was separated into 11 fractions with a recovery of 86% within 6 h. A C18 column was taken as the second dimension to realize the high‐performance separation and rapid preparation from the fractions collected from the first dimension. Eight compounds in fraction 6 and 2 compounds in fraction 8 were isolated and identified after optimizing the separation and collection parameters. This method is a high‐efficient and orthogonal preparation method to improve the separation of a complex sample and increase the purity of the compounds, which benefits from the application of novel materials in the preparation and purification.     

Isolation and purification of macrocyclic components from Penicillium fermentation broth by high‐speed counter‐current chromatography

In this paper, high‐speed counter‐current chromatography (HSCCC), assisted with ESI‐MS, was first successfully applied to the preparative separation of three macrolide antibiotics, brefeldin A (12.6 mg, 99.0%), 7′‐O‐formylbrefeldin A (6.5 mg, 95.0%) and 7′‐O‐acetylbrefeldin A (5.0 mg, 92.3%) from the crude extract of the microbe Penicillium SHZK‐15. Considering the chemical nature and partition coefficient (K) values of the three target compounds, a two‐step HSCCC isolation protocol was developed in order to obtain products with high purity. In the two‐step method, the crude ethyl acetate extract was first fractionated and resulted in two peak fractions by HSCCC using solvent system n‐hexane/ethyl acetate/methanol/water (HEMWat) (3:7:5:5 v/v/v/v), then purified using solvent systems HEMWat (3:5:3:5 v/v/v/v) and HEMWat (7:3:5:5 v/v/v/v) for each fraction. The purities and structures of the isolated compounds were determined by HPLC, X‐ray crystallography, ESI‐MS and NMR. The results demonstrated that HSCCC is a fast and efficient technique for systematic isolation of bioactive compounds from the microbes.     

Separation of α‐amylase inhibitors from Abelmoschus esculentus (L).Moench by on‐line two‐dimensional high‐speed counter‐current chromatography target‐guided by ultrafiltration‐HPLC

In this study, an on‐line two‐dimensional high‐speed counter‐current chromatography system based on a six‐port valve was developed. Target‐guided by ultrafiltration with high‐performance liquid chromatography, the one‐step isolation of three potential α‐amylase inhibitors from Abelmoschus esculentus (L).Moench was achieved by employing the developed orthogonal system and extrusion elution mode. The purities of three potential α‐amylase inhibitors were all over 95% as determined by high‐performance liquid chromatography. Furthermore, UV, mass spectrometry and ¹H NMR spectroscopy were applied to the structural identification of the isolated three target compounds, their structures were assigned as quercetin‐3‐O‐sophoroside (i), 5,7,3′,4′‐tetrahydroxy flavonol‐3‐O‐[β‐d ‐rhamnopyranosil‐(1→2)]‐β‐d ‐glucopyranoside (ii ) and isoquercitrin (iii), respectively. The Results demonstrated that the proposed method was highly efficient to screen and isolate enzyme inhibitors from complex natural products extracts, and on‐line two‐dimensional high‐speed counter‐current chromatography can effectively increase the peak resolution of target compounds.     

Separation of five oligostilbenes from Vitis amurensis by flow‐rate gradient high‐performance counter‐current chromatography

A rapid and efficient high‐performance counter‐current chromatography (HPCCC) method was developed to separate five oligostilbenes from the roots of Vitis amurensis. An n‐hexane/ethyl acetate/methanol/water system (4:8:4:10, v/v/v/v) was selected as an optimal two‐phase solvent system of which the upper phase was used as the stationary phase and the lower phase was used as the mobile one. Partition coefficient values for the target compounds under these optimized conditions were 0.28 ( 1 , ampleosin A), 7.12 ( 2 , (+)‐g‐viniferin), 2.26 ( 3 , vitisin A), 5.38 ( 4 , wilsonol C), and 11.23 ( 5 , vitisin B). Flow‐rate gradient HPCCC (4 mL/min in 0–70 min, 8 mL/min in 70–250 min) was applied to isolate the target compounds in as high purity as possible within the shortest possible run time. Under these conditions, ampelopsin A (12.1 mg), (+)‐g‐viniferin (10.4 mg), vitisin A (2.8 mg), wilsonol C (3.2 mg), and vitisin B (37 mg) were isolated with >95% purity from 150 mg of enriched oligostilbene extract. Although the K_D of the last eluted compound, vitisin B (K_D = 11.23), was relatively large, it was eluted in 115–145 min using the two‐phase solvent system. This study shows that HPCCC is an efficient tool for the isolation and purification of natural products.     

Preparative isolation of arylbutanoid‐type phenol [(‐)‐rhododendrin] with peak tailing on conventional C18 column using middle chromatogram isolated gel column coupled with reversed‐phase liquid chromatography

Reversed‐phase liquid chromatography coupled with middle chromatogram isolated gel column was employed for the efficient preparative separation of the arylbutanoid‐type phenol [(‐)‐rhododendrin] from Saxifraga tangutica. Universal C18 (XTerra C18) and XCharge C18 columns were compared for (‐)‐rhododendrin fraction analysis and preparation. Although tailing and overloading occurred on the XTerra C18 column, the positively charged reversed‐phase C18 column (XCharge C18) overcame these drawbacks, allowing for favorable separation resolution, even when loading at a on a preparative scale (3.69 mg per injection). The general separation process was as follows. First, 365.0 mg of crude (‐)‐rhododendrin was enriched from 165 g Saxifraga tangutica extract via a middle chromatogram isolated gel column. Second, separation was performed on an XTerra C18 preparative column, from which 73.8 mg of the target fraction was easily obtained. Finally, the 24.0 mg tailing peak of (‐)‐rhododendrin on XTerra C18 column was selectively purified on the XCharge C18 analytical column. These results demonstrate that the tailing nonalkaloid peaks can be effectively used for preparative isolation on XCharge C18 columns.     

Target‐guided isolation of polar antioxidants from Abelmoschus esculentus (L). Moench by high‐speed counter‐current chromatography method coupled with wavelength switching and extrusion elution mode

An off‐line two‐dimensional high‐speed counter‐current chromatography strategy combined with the wavelength switching technique and extrusion elution mode was successfully developed and applied to the isolation of polar antioxidants from Abelmoschus esculentus (L).Moench. Target‐guided by the result of 2,2‐diphenyl‐1‐picrylhydrazyl screening assay, four antioxidants were obtained with purities over 90% through orthogonal high‐speed counter‐current chromatography separation. UV spectroscopy, mass spectrometry and ¹H NMR spectroscopy were employed to identify their structures, which were assigned as l ‐tryptophan, quercetin‐3‐O‐sophoroside, 5,7,3′,4′‐tetrahydroxyflavonol‐3‐O‐[β‐d ‐rhamnopyranosil‐(1→2)]‐β‐d ‐glucopyranoside, and quercetin‐3‐O‐glucoside. Each monomer exhibited significant antioxidant activity. The results demonstrated that proposed method could be an effective approach to isolate bioactive compounds from complex natural products.     

Off‐line comprehensive two‐dimensional reversed‐phase countercurrent chromatography with high‐performance liquid chromatography: Orthogonality in separation of Polygonum cuspidatum Sieb. et Zucc

Off‐line comprehensive two‐dimensional reversed‐phase countercurrent chromatography with high‐performance liquid chromatography was investigated in separation of crude ethanol extract from traditional Chinese medicinal herb Polygonum cuspidatum Sieb. et Zucc. Two‐dimensional contour plots for countercurrent chromatography with high‐performance liquid chromatography was obtained after comprehensive separation was completed. Total peak capacity was evaluated and approximately 810 peaks were obtained through a comprehensive two‐dimensional separation. A highly orthogonality of 52.23% and a large separation space occupancy of 88.86% were achieved. Meanwhile, it was found that several components could be well separated by countercurrent chromatography while they could not be separated by high‐performance liquid chromatography, and vice versa, which further indicated the orthogonality of the two separation methods. The off‐line comprehensive two‐dimensional countercurrent chromatography with high‐performance liquid chromatography provided a promising and powerful method for separation of complex natural products.     

An effective method based on medium‐pressure liquid chromatography and recycling high‐speed counter‐current chromatography for enrichment and separation of three minor components with similar polarity from Dracocephalum tanguticum

The separation of minor compounds, especially those with similar polarities from a complex sample, remains challenging. In the proposed study, an effective method based on medium‐pressure liquid chromatography and recycling high‐speed counter‐current chromatography was developed for the enrichment and separation of three minor components from Dracocephalum tanguticum. The crude extract was directly introduced to medium‐pressure liquid chromatography for the enrichment of the three minor components. Based on high‐performance liquid chromatography analysis, the total content of these three compounds increased from 0.48% in the crude extract to 85.3% in the medium‐pressure liquid chromatography fraction. In addition, high‐speed counter‐current chromatography was employed to separate the enriched compounds using the solvent system hexane/ethyl acetate/methanol/water (1.18:8.82:1.18:8.82, v/v/v/v). As a result, compound 3 and a mixture of compounds 1 and 2 were obtained. In order to improve the resolution of compounds 1 and 2 while saving separation time, a recycling and heart‐cut mode was used. Finally, compounds 1 and 2 were obtained after five cycles. These compounds were identified as 3‐phenylethyl β‐d ‐glucopyranoside ( 1 ), tazettoside E ( 2 ), and cirsiliol‐4′‐glucoside ( 3 ). Compounds 1 and 2 were primarily separated from D. tanguticum. Moreover, the developed method provided a reference for the separation of minor components from the complex sample.