Indomethacin sustained-release suppositories containing sugar ester

We prepared indomethacin (IM) sustained-release suppositories using sugar ester (SE) as an additive. The suppositories were prepared by the fusion method with IM, SE, and Witepsol H-15 (H-15) and their availabilities in vitro and in vivo were evaluated mainly by the drug release test and the absorption test in rabbits, respectively. The softening point of the suppositories increased with increasing SE content. In the release test with the Muranishi method, slow-release profiles were obtained when the SE content was more than 52.5%. The absorption of IM from these suppositories, however, was very little. In the other release test, e.g. immersion method with gauze, all of the suppositories with SE showed slow-release profiles, and the drug release rates clearly depended on the SE content. The drug was released from the suppositories by the following leaching-type mechanism proposed by Higuchi. The suppository with a 30% SE content showed a sustained-plasma level of IM, but the other suppositories did not. It was concluded that an appropriate content of SE (i.e. 30%) in the suppository base was required to obtain sustained-release because it reasonably regulated the infiltration of rectal fluid into the suppository and the mechanical strength of the suppository against disintegration.     

Studies on sustained-release suppositories. III. Rectal absorption of morphine in rabbits and prolongation of its absorption by alginic acid addition

Rectal absorption of morphine from various kinds of suppository bases was investigated. The extent of bioavailability of morphine by rectal administration varied with the bases used (30.5-97.5%), but every value was higher than that in the case of oral administration (13.5%). Witepsol bases were preferable to macrogol base for the rectal absorption of morphine. In particular, Witepsol S-55 or W-35 gave a higher plasma peak level than H-15 or E-75, whereas the difference in the mean residence times obtained from these bases could not be regarded as significant. Sustained-release suppositories of morphine could be prepared simply by mixing alginic acid (Alg) with morphine in a suppository base. Further, prolonged rectal absorption could be obtained by using these sustained-release suppositories, and the absorption rate was controlled by the amount of Alg added. It seems likely that the sustained release was due to the binding of morphine to Alg from the results of partition coefficient and binding ratio measurements in aqueous solution. The rapid initial absorption and the subsequent prolonged absorption of morphine simultaneously obtained from the morphine-Alg suppository may be useful in the clinical context.     

Preparation and evaluation of eudragit gels. V. Rectal gel preparations for sustained release and avoidance of first-pass metabolism of lidocaine.

The release of lidocaine from hydrogel and xerogel preparations was remarkably suppressed compared with polyethylene glycol (PEG) 2000 suppository. The release rate of lidocaine from hydrogel and xerogel increased with the increase in the amount of sodium hydroxide incorporated within the range of 3 to 7 milliequivalent (meq). After an oral administration of lidocaine HCl solution, the plasma concentration of lidocaine was considerably lower than that after intravenous administration for all time periods. The absolute bioavailability (F(oral)) was 5.63%. For the Witepsol S-55 and PEG 2000 suppositories, the plasma levels of lidocaine were higher than those for the oral preparation, and Cmax and area under the concentration-time curve (AUC) values significantly improved (p < 0.01). The absolute bioavailabilities were 21.3 and 29.6%, respectively. On the other hand, Eudispert hv-hydrogel and xerogel preparations showed the characteristics of a sustained-release preparation, especially the xerogel preparation with 5 meq NaOH. Absolute bioavailability for hydrogel and xerogel preparations increased significantly (p < 0.05) by approximately 1.7-3.4 folds compared with those of Witepsol S-55 and PEG 2000 suppositories.     

Studies on sustained-release suppositories. II. Evaluation of polymer electrolyte containing acidic groups for prolonged rectal absorption of bacampicillin in rabbits

Rectal absorption of bacampicillin hydrochloride (BAPC) was found to show the best bioavailability with Witepsol H-15 as suppository base among various Witepsol bases. However, an effective plasma concentration of drug (above 0.5 micrograms/ml) was only maintained for 2 h, so sustained-release suppositories of BAPC were studied. Bacampicillin reacts with acidic polymer electrolytes such as pectic acid (Pc), chondroitin sulfate (Cd) and precipitates as its adduct with the polymer in an aqueous solution. The dissolution rate of BAPC from the adducts in a solution was slower than that of BAPC itself. The absorptions of BAPC from the suppositories containing the adducts were prolonged, but the bioavailabilities were decreased compared to that from the suppository containing BAPC alone. Similar prolonged absorption could be obtained simply by mixing Pc or Cd with BAPC in a base. Further, the absorption rate was found to be controlled by the amount of the polymer addition, and both a high plasma level and excellent bioavailability were obtained. This desirable outcome may be due to the simultaneous occurrence of rapid absorption of BAPC itself and formation of the adducts.     

Enhancement effect of lauric acid on the rectal absorption of propranolol from suppository in rats.

In a previous paper, we have demonstrated that medium chain fatty acids significantly enhance the in vitro rectal absorption of propranolol (PL) and that the enhancement may be partly due to the formation of a complex with a fatty acid at a 1:1 molar ratio. To confirm in vivo the enhancement effect of lauric acid on PL absorption, PL suppositories with lauric acid at various molar ratios were administered to rat rectum. PL absorption from Witepsol and macrogol suppositories with lauric acid at a 1:1 molar ratio was much larger than that after PL alone and the 1:2 or 1:3 molar ratio ones. The bioavailability (BA) after administration of the 1:1 molar ratio suppository (PL, 4 mg/kg) was 1.6- and 2.1-fold for the Witepsol and macrogol formulations respectively, compared with that after PL alone. A similar result was obtained with the PL solid dispersion suppository with lauric acid at a 1:1 molar ratio, showing a 1.7-fold higher BA compared with PL alone. The release of PL from the macrogol suppository was significantly faster at a 1:1 molar ratio than that of other preparations, but not so in the solid dispersion suppository. There was not good agreement between the release rates of PL from the suppositories and the plasma levels after dosing. These results supported the concept that a portion of PL, by forming a 1:1 complex with lauric acid, would penetrate across the rectal mucosa more easily than PL alone.     

Studies on sustained-release suppositories. I. Effect of alginic acid addition on rectal absorption of bacampicillin in rabbits

Sustained-release suppositories of bacampicillin (BAPC) were prepared by the use of the adduct which was precipitated from an aqueous solution containing BAPC and alginic acid (Alg). As the suppository base, Witepsol H-15 and macrogol were used. Absorptions of BAPC from the suppositories were prolonged in rabbits, but the bioavailabilities were decreased compared to that after administration of BAPC alone. However, these absorptions were improved enormously by the addition of surface-active agents, that is, an excellent prolonged absorption and high bioavailability were obtained. Interestingly, similar prolonged absorption could be obtained only by mixing Alg with BAPC in a suppository base. Further, this absorption rate was found to be controlled by the amount of Alg addition. The absorption profiles from a suppository containing the mixture differed from that containing the adduct in exhibiting both high plasma level and prolonged absorption. This may be due to simultaneous fast absorption of BAPC itself and formation of the adducts. Thus, it seemed that BAPC preparations containing Alg may be practically useful as a rectal preparation with prolonged action and giving a high plasma level.     

Sustained-Release Solid Dispersion of High-Melting-Point and Insoluble Resveratrol Prepared through Hot Melt Extrusion to Improve Its Solubility and Bioavailability

This study aimed to prepare a sustained-release solid dispersion of poorly water-soluble resveratrol (RES) with high melting point in a single hot melt extrusion step. A hydrophobic–hydrophilic polymeric blend (Eudragit RS and PEG6000) was used to control the release of RES. With the dispersive mixing and high shear forces of hot melt extrusion, the thermodynamic properties and dispersion of RES were changed to improve its solubility. The effects of the formulation were investigated through univariate analysis to optimize the preparation of the sustained-release solid dispersion. In vitro and in vivo studies were performed to evaluate the prepared RES/RS/PEG6000 sustained-release solid dispersion. The physical state of the solid dispersion was characterized using differential scanning calorimetry and X-ray diffraction. Surface properties of the dispersion were visualized using scanning electron microscopy, and the chemical interaction between RES and excipients was detected through Fourier-transform infrared spectroscopy. Results suggested that the optimized sustained-release solid dispersion was obtained when the mass ratio of RES-polymeric blend was 1:5, the ratio of PEG6000 was 35%, the barrel temperature was 170 °C, and the screw speed was 80 rpm. In vitro studies demonstrated that the solid dispersion showed a good sustained release effect. The cumulative release of RES reached 82.42% until 12 h and was fit by the Weibull model. In addition, the saturated solubility was 2.28 times higher than that of the bulk RES. In vitro studies demonstrated that the half-life increased from 3.78 to 7.09 h, and the bioavailability improved to 140.38%. The crystalline RES was transformed into the amorphous one, and RES was highly dispersed in the polymeric blend matrix.     

Cisplatin suppository: preparation, release characteristics and clinical evaluation

Cisplatin (CDDP) has attracted attention as a chemotherapeutic agent for the treatment of uterine endometrial carcinoma but causes serious side effects, including renal toxicity. CDDP suppositories containing NaCl at different concentrations were prepared to enhance the efficacy and to reduce the side effects of CDDP. The release characteristics, melting point and viscosity of the suppositories were first studied. The rate of CDDP release increased as the NaCl concentration increased: it was 12% 12 h after administration of suppositories containing no NaCl, but 32% with 0.2% NaCl. The melting point was raised by addition of NaCl: 35.5 degrees C without NaCl and 36.5 degrees C with 0.2% NaCl. Addition of 0.2% NaCl doubled the viscosity. Clinically, the suppository containing 0.06% NaCl was given to 3 patients with endometrial carcinoma twice a week for 3 weeks to examine serum CDDP levels and endometrial absorption. Patients with endometrial carcinoma showed different peak plasma platinum (Pt) levels which were as low as 0.12, 0.06 and 0.22 micrograms Pt/ml with similar patterns of change in the level. Radiographic analysis revealed many Pt particles in sections of necrosed endometria after 21d of the treatment. No side effects of CDDP were found in biochemical testing or subjective symptoms.     

Enhanced rectal absorption of insulin in rabbits from hollow-type suppositories containing insulin and glyceryl-1-monooctanoate.

The absorption of two kinds of insulin (from porcine or bovine pancreas) from the rectum of rabbits after the administration of hollow-type suppositories containing insulin and glyceryl-1-monooctanoate (GMO) as an absorption-enhancing agent was investigated. Two types of suppositories were employed: type I containing insulin in an aqueous solution (approx. 25 IU/mg/100 microliters citric buffer solution at pH 3.0) in the cavity of the suppository and GMO mixed with a base material (Witepsol H-15), and type II containing insulin in a crystalline form in the same amount as in type I. Without GMO, the insulin and glucose levels in plasma were unchanged, whereas a marked increase in the plasma levels of insulin and a decrease of glucose concentrations were found following coadministration of insulin and GMO by the type I suppository. Similar enhancement of rectal absorption of insulin was obtained from porcine and bovine sources. In the case of the crystalline insulin, despite the use of the same amount of GMO, porcine insulin was more efficiently absorbed than bovine insulin by the type II suppository. GMO enhances the absorption of insulin in an aqueous solution or a crystalline form, and the dissolution rate of insulin may be an important factor in the rectal absorption of insulin.     

Bioavailability of morphine in rabbits after rectal administration of suppository containing controlled release morphine tablet.

Two kinds of sustained release morphine suppositories have been prepared; one is an oleaginous base suppository (MSC) containing a controlled release morphine tablet (MST: MS Contin), and the other is a hollow-type suppository (MSCH) containing MST and morphine powder packed in its hollow space. In vitro release tests and in vivo rectal absorption experiments in rabbits were performed. The profiles of morphine release from MST and MSC in vitro were similar, and revealed that suppository bases had no effect on the release profile of morphine from the preparation. Morphine release from MSCH was rapid in the early phase, and then enclosed morphine was slowly and continuously released from MST. Phamacokinetics of morphine from the suppository were compared with the orally administered MST, and it was found that there was no difference in the maximum plasma concentration (Cmax) and the peak time (Tmax) between MSC and MST, but the mean residence time (MRT) of MSC was approximately three times longer than that of MST, and the extent of bioavailability (BA) of MSC was significantly larger than that of MST (71.6 +/- 14.2% and 11.9 +/- 4.0%, respectively). Cmax can be altered arbitrarily by changing the morphine content in the hollow space of MSCH. As in the case of MSC, the plasma concentration of morphine from MSCH was maintained. It is concluded from the above results that MSC is a satisfactory sustained release morphine suppository for the treatment of cancer pain, administering it twice a day, and that MSCH is effective due to its fast analgesic effect and sustained release nature not only for cancer pain but also for surgical operations.     

Absorption enhancement of polypeptide drugs by cyclodextrins. I. Enhanced rectal absorption of insulin from hollow-type suppositories containing insulin and cyclodextrins in rabbits.

The absorption of insulin (from porcine pancreas) from the rectum of rabbits after the administration of hollow-type suppositories containing insulin and five kinds of cyclodextrins (CyDs) was investigated. Three types of suppositories were employed: suppository I containing insulin (approximately 26 IU/mg) and various amounts of each CyD in citric buffer solution at pH 3.0 or powder in its cavity, suppository II containing CyD without insulin, and suppository III containing insulin without CyD. Without CyD, the insulin and glucose levels in plasma were unchanged, whereas a significant increase in the plasma insulin concentration and a marked decrease in the glucose levels were found following simultaneous administration of insulin and CyDs by suppository I. The enhancing effect of CyD on rectal insulin absorption (absorption-enhancing effect) by chemically modified CyDs (heptakis(2,6-di-O-methyl)-beta-CyD (DM-beta-CyD) and 2-hydroxypropyl-beta-CyD (HP-beta-CyD)) was higher than those by natural CyDs (alpha-, beta-, and gamma-CyD). The area under the plasma concentration-time curve (AUC) and Cmax of insulin significantly decreased with the preadministration (administration of CyD 6, 24 and 48 h before rectal insulin administration) of DM-beta-CyD. The absorption-enhancing effect disappeared 24 h after preadministration. These results suggest that CyDs enhance insulin absorption from the rectum, and that attenuation of the membrane transport barrier function in the rectum recovers at a maximum of 24 h after administration of CyDs.     

Enhancing effect of glyceryl-1-monooctanoate on the rectal absorption of gentamicin from hollow-type suppositories in rabbits

A hollow-type suppository containing gentamicin (GM) in its cavity was prepared using Witepsol H-15 (H-15) mixed with glyceryl-1-monooctanoate (MO) or MO alone in the body of the suppository (type I) and a suppository (type II) containing GM and MO in the cavity was constructed using H-15 in the body of the suppository. Without MO, GM (60 mg) was not absorbed (plasma GM levels less than 1 microgram/ml). However, the absorption of GM from the rectum of rabbits was enhanced by coadministered MO in types I and II. Even when the amount of GM was decreased to 6 mg (1/10), GM was observed in the plasma (Cmax, 3.5 +/- 0.3 micrograms/ml) after administration of the suppository made from MO mixed with H-15. The enhancing effect of MO on the rectal absorption of GM could not be further increased by incorporating an amount of MO larger than approximately 300 mg into the suppository. This study demonstrates that MO can be used in the two types of hollow suppositories as an effective enhancing agent of rectal absorption of poorly absorbed drugs such as GM.     

Effect of glycyrrhizinate on dissolution behavior and rectal absorption of amphotericin B in rabbits.

The effects of dipotassium glycyrrhizinate (GLYK) on the dissolution behavior and bioavailability of amphotericin B (AMB) were investigated. The mixtures of AMB and GLYK were prepared at different molar ratios by lyophilization. Lyophilization resulted in amorphous AMB either alone or in the mixture. Dissolution rates of AMB of the mixtures were markedly faster than that of lyophilized AMB alone, which was followed by a decrease of dissolution. The initially-enhanced dissolution rate was likely to be due to the improvement of surface wettability of drug particles with GLYK rather than the amorphous state of AMB. A phase solubility study of AMB with GLYK indicated that the increasing solubility was caused by micellar solubilization. The in vitro release rate of AMB from suppositories containing the lyophilized mixtures was significantly accelerated by increasing the amount of GLYK. The rectal absorption of AMB from suppositories containing either the drug alone, a physical mixture or a lyophilized mixture was studied using rabbits. The absorption of the mixture (AMB/GLYK = 1/9) was about 35 times greater in the area under the serum concentration-time curve (0-24 h) than that of lyophilized AMB alone. These results suggest that GLYK is useful for improving the dissolution property of AMB and the bioavailability of the drug incorporated in suppositories.     

Gastric acidity-dependent bioavailability of commercial sustained release preparations of indomethacin, evaluated by gastric acidity-controlled beagle dogs

The relationship between gastric acidity and the bioavailability of two kinds of sustained-release indomethacin (IM) formulations was investigated in gastric acidity-controlled beagle dogs, and compared with that of rapid-release IM formulations. All test dosage forms were more rapidly dissolved in simulated intestinal fluid than in simulated gastric fluid. Gastric acidity did not affect the bioavailability of IM from the rapid-release formulation. However, the bioavailability of IM from the two kinds of sustained-release formulations were markedly influenced by gastric acidity. The rates of IM bioavailability from both of the sustained-release formulations were faster under low acidity conditions than under high acidity conditions (p less than 0.01). In addition, Tmax and mean residence time (MRT) were approximately the same for the rapid-release and sustained-release formulations under low acidity conditions. These results suggest that the IM sustained-release formulations showed a rapid-release profile under low acidity conditions.     

Preparation and physicochemical properties of konjac glucomannan ibuprofen ester as a polysaccharide-drug conjugate

Abstract

A novel drug-polysaccharide conjugate with konjac glucomannan (KGM) as a drug carrier was fabricated through the esterification of ibuprofen (IBU), an anti-inflammatory drug, with KGM. The influences of the reaction conditions, such as the amount of ibuprofen acryl chloride, reaction time, reaction temperature, and the amount of catalyst, on the degree of substitution were investigated. KGM ibuprofen ester (KGM-IBU) was characterized by Fourier transform infrared spectrometry (FTIR), X-ray diffraction (XRD), solid-state ¹³C NMR, scanning electron microscopy (SEM), transmission electron microscopy (TEM), thermogravimetric analysis (TGA), differential scanning calorimetry (DSC), and dynamic mechanical analysis (DMA). The hydrophobic structure of IBU in KGM-IBU was proven by the fluorescence emission spectra of pyrene. In addition, by using commercially available ibuprofen sustained-release capsules (IBU-SRC) as a control, the in vitro controlled release performance of KGM-IBU was evaluated. The cumulative release of IBU-SRC within 36?h was 94%, while that of KGM-IBU within 36?h was 77%. The results showed that KGM-IBU had better sustained-release performance without a burst release effect. The obtained products could be used as a potential biocompatible sustained-release drug delivery system.     

聚乙二醇相对分子质量及用量对温敏型PCL-PEG-PCL水凝胶的制备及释药性研究

采用开环聚合法制备PCL-PEG-PCL共聚物,并将其制成温敏性水凝胶,探究了PEG(聚乙二醇)相对分子质量及质量浓度对水凝胶温敏性的影响.水凝胶的相变温度由翻转小瓶法测定.通过FTIR、热分析仪和SEM等技术对其组成及结构进行表征.以疏水性姜黄素(Cur)为模型药物,制备出载Cur PCL-PEG-PCL水凝胶,并研究其体外释药行为.FTIR结果表明:实验制备的共聚物中含有PCL和PEG的链段.热分析结果表明:在25℃~65℃内水凝胶存在相变过程.SEM结果表明:水凝胶剖面具有疏松多孔.体外释药结果表明:PCL-PEG-PCL水凝胶对Cur具有缓释作用,释药机理符合Higuchi骨架溶蚀模型.     

Design of polyvinyl alcohol hydrogel as a controlled-release vehicle for rectal administration of dl-propranolol-HCl and atenolol

Preparations of beta-blockers, propranolol-HCl and atenolol, in poly(vinyl alcohol) (PVA) hydrogel were designed for the therapeutic treatment of hypertension by transrectal delivery. In vitro release characteristics and plasma drug concentration profiles after rectal administration in rats and dogs were examined. The PVA hydrogels containing beta-blockers were prepared by a low-temperature crystallization method. The release of beta-blockers from hydrogel preparations was consistent with Fickian diffusion (Higuchi model); the drug release versus the square root of release time profile gave a straight line over 60% of the total release process. The release of beta-blockers from hydrogel preparations increased at higher concentrations of PVA in the hydrogel preparations and was not affected by the pH of hydrogel preparations. Plasma concentrations of beta-blockers after rectal administration of hydrogels were higher than those after administration of suppositories (Witepsol H-15) in rats and dogs. The drug plasma concentrations increased at higher concentrations of PVA in hydrogel preparations. In the case of propranolol, which is a hepatic high-clearance drug, area under the blood concentration curve, 0-8 h after rectal administration of a hydrogel preparation (20% w/w PVA, pH 7.0) was 2.16 times and 5.26 times higher than those obtained with Witepsol H-15 suppository and oral administration, respectively. Rectal administration with PVA hydrogels is a favorable route for a hepatic high-clearance drug such as propranolol.     

Simultaneous Determination of Acetaminophen and Phenobarbital in Suppositories by Partial Least-Squares Spectrophotometric Calibration

Abstract

The use of partial least-squares spectrophotometric calibration for the simultaneous determination of suppositories in a multicomponent formulation is presented. This method is applied to the deternination of acetaminophen and phenobarbital in suppository preparations. The results show that these components in a molar ratio of about 61:1 in suppositories have been determined simultaneously with high precision.     

Synthesis,characterization, and thermal properties of biodegradable polyetheresteramide copolymers based on 11-aminoundecanoic acid

In this work, new aliphatic polyetheresteramide copolymers based on e-caprolactone, 11-aminoundecanoic acid, and poly(ethylene glycol) (PEG) were synthesized by the melt polycondensation method. The copolymers obtained were characterized by ¹H NMR, differential scanning calorimetry, thermogravimetric analysis/differential thermogravimetry, and wide-angle X-ray diffraction. Water absorption and hydrolytic degradation behavior was also studied. With the increase in PEG content, water absorption and the hydrolytic degradation rate increased accordingly.     

Effect of particle size of drug on conversion of crystals to an amorphous state in a solid dispersion with crospovidone

The effect of particle size on amorphization of drugs in a solid dispersion (SD) was investigated for two drugs, indomethacin (IM) and nifedipine (NP). The SD of drugs were prepared in a mixture with crospovidone by a variety of mechanical methods, and their properties investigated by particle sizing, thermal analysis, and powder X-ray diffraction. IM, which had an initial particle size of 1 μm and tends to aggregate, was forced through a sieve to break up the particles. NP, which had a large initial particle size, was jet-milled. In both cases, reduction of the particle size of the drugs enabled transition to an amorphous state below the melting point of the drug. The reduction in particle size is considered to enable increased contact between the crospovidone and drug particles, increasing interactions between the two compounds.