ZnO nanoparticles dispersed PVA–PVP blend matrix based high performance flexible nanodielectrics for multifunctional microelectronic devices

Polymer nanocomposite (PNC) films based on the blend matrix of poly(vinyl alcohol) (PVA) and poly(vinyl pyrrolidone) (PVP) (50/50 wt%) incorporated with zinc oxide (ZnO) nanoparticles (i.e., (PVA–PVP)–x wt% ZnO; x = 0, 1, 3 and 5) were prepared by solution-cast method. The behaviour of polymer-polymer and polymer-nanoparticle interactions in the PNC films was ascertained by employing X-ray diffraction, energy dispersive X-ray, and Fourier transform infra-red spectroscopies. Scanning electron microscopy and atomic force microscopy were performed for the morphological characterization, whereas the thermal and optical properties of the PNC films were investigated by using differential scanning calorimetry and ultraviolet–visible spectroscopy, respectively. The dielectric and electrical behaviour of these PNC materials were determined by employing the dielectric relaxation spectroscopy over the frequency range from 20 Hz to 1 MHz. The influence of ZnO concentration on the degree of PVA crystalline phase and the crystallite size, surface morphology and roughness of the films, the glass phase transition and melting phase transition temperatures, direct and indirect optical energy band gap, refractive index, complex permittivity, electrical conductivity, activation energy and the structural dynamics of these PNC materials were explored. The investigated properties of the PNC films were credited to an innovation and engineering of novel high performance flexible nanodielectrics in the area of advanced functional materials for their promising applications especially in the next generation optoelectronic, gas sensor and microelectronic devices.     

Relaxation dynamics and fragility during liquid–glass transitions of poly(propylene glycol)s

The acoustic and thermal properties of the liquid–glass transitions of propylene glycol and its oligomers, poly (propylene glycol)s, were studied by temperature modulated DSC and Brillouin scattering. The fragility indices were determined from Angell plots using the observed modulation frequency dependence of the complex heat capacity. The variation in the glass transition temperatures is discussed on the basis of the free volume theory. The relaxation time of the structural relaxation obeys the Vogel–Fulcher law, and its high frequency end is in good agreement with the result of the dielectric measurement in the literature. The correlation between the observed thermal expansion coefficients and the glass transition temperature is discussed based on the free volume theory. The sound velocity and attenuation were accurately determined as a function of the temperature by Brillouin scattering by combination with the refractive index measurement. The relaxation dynamics were discussed by considering the relaxation from segmental motions. All of these physical properties were discussed based on the third-order anharmonicity and the Grüneisen parameter.     

Glass transitions and dynamics in thin polymer films: dielectric relaxation of thin films of polystyrene

The glass transition temperature T(g) and the temperature T(alpha) corresponding to the peak in the dielectric loss due to the alpha process have been simultaneously determined as functions of film thickness d through dielectric measurements for polystyrene thin films supported on glass substrate. The dielectric loss peaks have also been investigated as functions of frequency for a given temperature. A decrease in T(g) was observed with decreasing film thickness, while T(alpha) was found to remain almost constant for d>d(c) and to decrease drastically with decreasing d for d相似文献   

Thermally stimulated currents in poly(vinyl chloride): Tacticity and molecular weight influence

Thermally stimulated currents (TSC) have been measured in several samples of poly(vinyl chloride) differing in tacticity and molecular weight as a result of polymerizing them at different temperatures. This has allowed us to characterize the relaxation behavior of PVC. No dielectric relaxation can be observed by this experimental technique at temperatures between liquid helium and liquid nitrogen. The β relaxation is observed around 173°K, with similar parameters in all samples studied. Around the glass transition the relaxation times isolated in the α peak follow a compensation law. Molecular weight and tacticity have a strong influence on the temperature of the maximum and the intensity of this relaxation, respectively.     

The Effect of Supercritical CO2 on the Macromolecules Parallel Conformation and Its Relation to the Electrical Conductivity and Dielectric Behavior of Epichlorohydrin Terpolymer

The effect of supercritical CO₂ on the electrical conductivity of poly(epichlorohydrin–Ethylene oxide–Allyl glycidal ether) terpolymer is investigated using dielectric spectroscopy. Impedance measurements were carried out in the frequency range from 100–10 MHz and the temperature range of ?35–70°C with intervals of 5°C. The experimental results of the dielectric constant and the dielectric loss were fitted with the Cole–Cole equation to obtain the maximum relaxation frequencies of the different relaxation processes. As a result of the CO₂ treatment process, enhancement in the polymer chain mobility without noteworthy change in the glass transition temperature was determined. In addition, the level of the DC conductivity and the dielectric strength were increased. These effects were attributed to improvement in the chain dynamics, which arises from enhancement in the parallel conformation of macromolecules.     

Poly(acrylamide‐co‐acrylic acid)/Poly(vinyl pyrrolidone) Polymer Blends Prepared by Dispersion Polymerization

The structure and properties of a three‐component system, a poly(acrylamide‐co‐acrylic acid)/poly(vinyl pyrrolidone) [P(AM‐co‐AA)/PVP] polymer blend prepared by dispersion polymerization, were studied. Scanning electron microscopy (SEM) and transmission electron microscopy (TEM) images showed that the resulting P(AM‐co‐AA) microspheres with diameters between 200–300 nm were well‐dispersed in the PVP matrix. Fourier transform infrared spectra (FTIR) showed that intermolecular hydrogen bonding interaction occurred between the dispersed phase and the continuous phase. The mechanical properties of P(AM‐co‐AA)/PVP polymer blends were also determined. With different mass ratios of acrylamide to acrylic acid, it was found that the blends had better mechanical properties with increased AA content.     

Preparation and characterization of Ag nanoparticle-embedded polymer electrospun nanofibers

Poly (vinyl alcohol) (PVA) and poly (vinyl pyrrolidone) (PVP) nanofibers embedding Ag nanoparticles (5–18 nm) have been prepared successfully by electrospinning at room temperature. Scanning electron microscope (SEM), X-ray diffraction (XRD), high-resolution transmission electron microscopy (HRTEM), Fourier transform IR spectra (FTIR), and Raman scattering were used to characterize the structure and properties of Ag nanoparticle-embedded PVA and PVP nanofibers before and after heat treatment at different temperature. The antibacterial activity of Ag nanoparticle-embedded PVP nanofibers after heat treatment was also tested, which indicated that the biological activity of yeast cells was effectively inhibited by these Ag nanoparticle-embedded PVP nanofibers.     

Revisiting the Dielectric Relaxation of Ethylene-Vinylacetate Copolymers: Influence of Microstructure

The dielectric relaxation behavior of a series of ethylene-vinylacetate (EVA) copolymers was investigated by measuring the complex dielectric permittivity in a broad frequency and temperature range. Crystallinity of EVA copolymers was estimated by differential scanning calorimetry (DSC) and wide-angle X-ray scattering (WAXS). The shape of the higher temperature relaxation, appearing above the glass transition temperature T _g depends on the VA content. It was found that this relaxation was asymmetric for VA concentrations higher than 40 wt% and changed to a symmetric shape at lower VA values. Concurrently, as the VA content decreased, a major broadening of the relaxation over a wide frequency range was observed. It is found that the dielectric relaxation was preserved on going through the melting range of the semicrystalline samples, although it exhibited changes of its characteristic parameters that are typical for segmental relaxation appearing at T _g. This finding allows one to associate this relaxation to the segmental motions at T _g in the amorphous phase and not to the existence of interfacial regions.     

Dielectric Dispersion Study of Poly(vinyl Pyrrolidone)–Polar Solvent Solutions in the Frequency Range 20 Hz–1 MHz

Influence of polar solvents environment and polymer concentrations on the electrical properties (complex dielectric constant, ac electrical conductivity, complex electric modulus and complex impedance) of the solutions of poly(vinyl pyrrolidone) (PVP) in polar solvents, namely water, ethyl alcohol, ethylene glycol, diethylene glycol, poly(ethylene glycol), glycerol, dimethyl sulfoxide and dimethyl formamide, have been investigated in the frequency range 20 Hz–1 MHz at 25°C. Comparative analysis of the dielectric dispersion curves confirms that the solvent molecular size and number of its hydroxyl groups, and the solutions viscosity, are the major factors which governs the PVP chain segmental motion. The ionic conduction and electrode polarization phenomena has a dominant influence on the large increase of complex dielectric constant values of the solutions of PVP‐polar solvent in the lower frequency region. The values of relaxation times corresponding to these phenomena are also reported.     

Specific features of the temperature dependence of the conformational dynamics of polymers

Physics of the Solid State - The dielectric and mechanical losses in the amorphous polar polymer poly(vinyl acetate) (PVA) are measured over wide ranges of frequencies and temperatures. It is...     

Dielectric fluctuations and the origins of noncontact friction

Dielectric fluctuations underlie a wide variety of physical phenomena, from ion mobility in electrolyte solutions and decoherence in quantum systems to dynamics in glass-forming materials and conformational changes in proteins. Here we show that dielectric fluctuations also lead to noncontact friction. Using high sensitivity, custom fabricated, single crystal silicon cantilevers we measure energy losses over poly(methyl methacrylate), poly(vinyl acetate), and polystyrene thin films. A new theoretical analysis, relating noncontact friction to the dielectric response of the film, is consistent with our experimental observations. This work constitutes the first direct, mechanical detection of noncontact friction due to dielectric fluctuations.     

Glass Transition Behavior and Dynamic Fragility of PMMA-SAN Miscible Blend-Clay Nanocomposites

An investigation of the segmental dynamics and glass transition behavior of a miscible polymer blend composed of poly(methyl methacrylate) (PMMA) and poly(styrene-ran-acrylonitrile) (SAN) and its melt intercalated nanocomposite by dynamic mechanical analysis is presented. The principle goal was to address the effect of intercalation on local molecular structure and dynamics. The results showed that the intercalation of polymer chains in the galleries of organoclay (Cloisite 30B) led to a lower temperature dependence of the relaxation time (fragility) and activation energy of α-relaxation. Moreover, calculation of the distribution of the segmental dispersion showed a narrower dispersion in the glass transition region so that the Kohlrausch-Williams-Watts (KWW) distribution parameter (β_KWW) increased from 0.21 for neat PMMA to 0.34 for the 50/50 PMMA/SAN blend nanocomposite containing 3 wt% organoclay. Furthermore, the relaxation behavior of the blends showed a negative deviation from mixture law predictions based on the responses of the neat PMMA and SAN. These behaviors were attributed to the lack of specific interactions between the blend components (PMMA, SAN, and nanoclay layers) and the less cooperative behavior, i.e., less constraint for segmental relaxation, of the intercalated chains.     

Thermal,vibrational, and dielectric studies on PVP/LiBF4+ionic liquid [EMIM][BF4]-based polymer electrolyte films

Free-standing polymer electrolyte membranes based on poly(vinyl) pyrrolidone (PVP)/salt(LiBF₄) having different amounts of ionic liquid (IL) [EMIM][BF₄] were prepared and characterized by thermogravimetric analysis (TGA), differential scanning calorimetry (DSC), Fourier transform infrared (FT-IR) spectroscopy, and alternating current (AC) impedance spectroscopic techniques. The DSC results show a shift in T_m of PVP with salt/or IL content. TGA and DTGA (first derivative of TGA) results give evidence of the presence of uncomplexed PVP, PVP/salt, and PVP/IL complexes. Signatures of these entities are also present in the dielectric spectra. Complexation of PVP with salt and IL has been confirmed by FT-IR analysis. Electrical conductivity as a function of temperature has been studied for PVP/LiBF₄/IL [EMIM][BF₄]. Role of IL in changing phase transition, conductivity, and dielectric relaxation frequency has been discussed.     

Glass transition and enthalpy relaxation of polyphosphate compounds

The glass transition behaviour of polyphosphate compounds such as di- and tri- polyphosphates used as food additives and ATP, ADP existing in biosystems, were investigated by using DSC. From the DSC heating curves of the frozen solutions, the glass transition temperatures of the maximum freeze concentrated solutions, Tg', were determined. It was found that Tg's for polyphosphates are relatively high. The lyophilized tripolyphosphates, ATP and ADP also showed the glass transition at a relatively high temperature, depending on the moisture content. In addition, the enthalpy relaxation behaviour of glassy ATP and ADP was examined and analyzed by using the Kohlrausch-Williams-Watts (KWW) and the Vogel-Fulcher-Tammann (VFT) equations. Judging from the parameters of the KWW and VFT equations, the amorphous states of ATP and ADP were suggested to be more fragile than trehalose and sucrose.     

On the probability distributions of relaxation times in glasses

The scale of relaxation times in glasses has led to generalizations of the Drude model of the dielectric function in terms of an integral, containing a Drude kernel and a probability distribution. This integral equation is solved by a Mellin or a Stieltjes transform. Beyond known results, we obtain the probability distribution of the Havriliak-Negami dielectric function. Even more general classes of dielectric models can be dealt with, using Mellin's transform. They may serve as checks for numerical procedures applied to the underlying ill-posed problem, if experimental data for the dielectric function are used. Received: 2 February 1998 / Accepted: 17 March 1998