Acidity adjustment of HZSM-5 zeolites by dealumination and realumination with steaming and citric acid treatments

This article describes a novel method for acidity adjustment of HZSM-5 zeolites with steaming and citric acid treatments and demonstrates the realumination effect of citric acid on HZSM-5 zeolites dealuminated by steaming. A series of modified HZSM-5 zeolites were prepared by streaming and/or acid treatments and characterized by means of X-ray diffraction (XRD), X-ray fluorescence spectroscopy (XRF), (27)Al MAS NMR spectroscopy, hydroxyl infrared spectroscopy (OH-IR), pyridine-adsorbed infrared spectroscopy, and N(2) adsorption in the present investigation. The results showed that compared with single HCl or citric acid treatment, steaming treatment, and steaming/HCl treatments, citric acid treatment after steaming exclusively increased the amount of framework Al due to reinsertion of extraframework Al into the defective sites of the steamed HZSM-5 framework. This realumination effect of the citric acid treatment on the steamed HZSM-5 zeolite, which is reported here for the first time to the best of our knowledge, could nearly recover the pore structure of the steamed zeolite to that of the parent HZSM-5 zeolite and appropriately tailor the amount and strength of different acid sites, which sheds light on optimizing the physicochemical properties of HZSM-5 zeolites. It was also found that the steaming treatment prior to the citric acid treatment was the precondition of the realumination of HZSM-5 zeolites, suggesting that the lattice defect sites generated during steaming were necessary for citric acid to work.     

TPAOH处理制备的微介孔催化剂物化性质与噻吩烷基化性能研究

采用不同浓度的TPAOH溶液处理不同SiO_2/Al_2O_3物质的量比的HZSM-5分子筛,制备了微孔-介孔多级孔HZSM-5催化剂。结果表明,采用不同浓度的TPAOH溶液处理不同SiO_2/Al_2O_3物质的量比的HZSM-5分子筛能够脱出HZSM-5分子筛的骨架硅而产生介孔,介孔孔径随TPAOH溶液浓度和SiO_2/Al_2O_3物质的量比的增大而增大;TPAOH溶液处理能够调变HZSM-5催化剂的酸性。采用不同浓度的TPAOH溶液处理SiO_2/Al_2O_3物质的量比分别为50、80和150的HZSM-5分子筛,其中,SiO_2/Al_2O_3物质的量比为50的HZSM-5弱中酸酸强度、相对酸量、B酸和L酸含量明显高于SiO_2/Al_2O_3物质的量比为80和150的HZSM-5分子筛。经不同浓度的TPAOH溶液处理后SiO_2/Al_2O_3物质的量比为50的HZSM-5催化剂具有最佳的噻吩烷基化反应性能。     

CF-2沸石的表面酸性及催化性能

CF-2是一种新型的高硅沸石。1981年我们实验室首先在二乙醇胺-甘油-Na₂O-SiO₂-Al₂O₃-H₂O体系中制备成功^[1],以后才见到关于Theta-1^[2],ISI-1^[3],KZ-2^[4],NO-10^[5]和ZSM-22^[6]沸石的报道。     

不同分子筛上1-己烯骨架异构化反应性能的研究

以HZSM-35、HZSM-5、HM和Hβ四种分子筛为1-己烯骨架异构化催化剂,比较研究了四种催化剂的异构化性能,对其构效关系进行了关联。结果表明,相比于HZSM-5和Hβ分子筛,HZSM-35和HM具有适宜的酸量,有效孔径为0.4-0.6 nm,而且无晶穴、无交叉孔道,具有良好的择形催化效应,在转化率高达95%的同时,C_5-和C₇₊等副产物的收率在20%左右,异己烯收率可达40%-50%。进一步对四种分子筛进行酸碱改性处理,结果显示,虽然酸性质略有改变,但是一维孔结构的HZSM-35和HM分子筛的异构化性能仍明显优于多维孔结构的HZSM-5和Hβ分子筛,说明在酸性质一定的前提下,孔结构对异构化反应起关键作用。     

Electrochemical study of the thionine dye incorporated into ZSM-5 and HZSM-5 zeolites

The electrochemical properties of thionine dye adsorbed into ZSM-5 and HZSM-5 zeolites (TH/ZSM-5, TH/HZSM-5) are studied in 0.5 M KCl solution. The dye is strongly retained and not easily leached from the zeolites matrix. The samples are incorporated into the carbon paste electrode (TH/ZSM-5/P, TH/HZSM-5/P) for cyclic voltammetric measurements. The redox reactions of thionine incorporated into ZSM-5 zeolite contain a quasi-reversible, two-electron one proton in the pH range 1 to 10, but thionine-loaded HZSM-5 zeolite undergoes a quasi-reversible two-electron two-protons redox reaction under acidic conditions and a one proton two-electron redox reaction takes place under basic conditions. The separation of the anodic and cathodic potentials (E _p) is high in thionine-loaded zeolites (>100) with respect to the solution of thionine (E _p = 34 for ZSM-5/P and 36 mV for HZSM-5/P), indicating that there are strong interaction between thionine molecules and the zeolites. The midpoint potentials (E _m) for TH/ZSM-5/P and TH/HZSM-5/P are −0.203 and −0.381 V, respectively. However, the midpoint potentials for the solution of thionine for the electrode system of ZSM-5/P and HZSM-5/P are −0.335 and −0.407 V, respectively. Thus, thionine dye molecules incorporated into the zeolites can be reduced more easily with respect to solution of thionine. In various electrolyte solutions, the midpoint potentials remains constant, but the midpoint potential of the thionine-zeolite electrodes depends on the solution pH. Influence of the pH of the solution on the midpoint potential of an immobilized dye reveals that thionine molecules are accessible to protons. This property is ascribed to the formation of mesopores in the structure of our zeolites suffering from a calcination step. Published in Russian in Elektrokhimiya, 2007, Vol. 43, No. 7, pp. 794–800. The text was submitted by the authors in English     

碳四烃在改性HZSM-5分子筛上芳构化研究

研究了炼厂混合C_4烃在Zn、Ga、Cr、La改性的HZSM-5分子筛催化剂上的芳构化反应,采用TPD和IR测定了催化剂的表面酸性质。结果表明,用Zn(3%)和Zn(2%)Ga(1%)改性的HZSM-5分子筛具有较好的芳构化性能;各改性HZSM-5分子筛催化剂芳构化性能变化与表面酸性有关,总酸量下降,芳构化活性下降,强B酸中心减少,深度裂解反应减少;Zn的单组分和双组分改性的HZSM-5分子筛催化剂芳构化活性的增高与表面强L酸浓度增加和吡啶吸附IR谱中的1615cm~(-1)吸收峰出现有关。     

以稀土离子交换的HZSM-5为载体的甲烷非氧化芳构化催化剂

The declining crude oil reserves has led to natural gas being considered as an alternative supply to produce important organic raw materials such as ethene and aromatics. Mo/HZSM-5 is found to be able to act effectively for the title reaction[1]. In order to clarify how the cation in the channel of HZSM-5 effects the behavior of the catalyst, different rare earth ion exchanged HZSM-5 ([ RE3+] HZSM-5 ) zeolites were investigated as supports of the Mo/[ RE3 + ] HZSM-5 catalyst.     

不同碱处理制备多级孔HZSM-5催化剂及噻吩烷基化性能研究

用Na₂CO₃、TPAOH和TPA⁺/CO₃^2-混合碱分别处理HZSM-5分子筛,采用FT-IR、XRD、XRF、N₂吸附脱附、SEM、NH₃-TPD及Py-FTIR表征手段对各类碱处理前后的HZSM-5分子筛进行表征。结果表明,3种类型的碱处理HZSM-5分子筛后,均能形成微孔-介孔多级孔道的HZSM-5(A)催化剂,并能调变催化剂的酸性,其中,TPA⁺/CO₃^2-混合碱处理得到的HZSM-5(TPA⁺/CO₃^2-)催化剂,比表面积最大,介孔数量最多。在小型固定床反应器上,考察了HZSM-5和HZSM-5(A)催化剂的噻吩烷基化性能,结果表明,HZSM-5(TPA⁺/CO₃^2-)催化剂因为具有适当的多级孔孔道和较多的B酸中心而表现出较高的噻吩转化率和1-己烯对噻吩的选择性。     

水蒸气处理对HZSM-5分子筛催化剂的酸性及孔结构的影响

通过XRD，NH3-TPD，IR，比表面与孔结构测定等方法，研究了HZSM-5分子筛（硅铝比为38）在不同温度下进行水热处理时的酸性与孔结构。结果表明，随着水热处理温度的提高，HZSM-5分子筛的结晶度稍有增大；酸性明显减弱，弱酸位增多，强酸位相对减少；IR谱图上有一定的蓝移；比表面与微孔体积减小，介孔体积增大。     

Effect of Phosphoric Acid on HZSM-5 Catalysts for Prins Condensation to Isoprene from Isobutylene and Formaldehyde

A series of HZSM-5 zeolites modified with different amounts of phosphoric acid(P/HZSM-5) was prepared. The physicochemical features of the P/HZSM-5 catalysts were characterized via X-ray diffraction(XRD), N₂ adsorption-desorption, NH₃-temperature programmed desorption(NH₃-TPD) and Fourier tranform infrared(FTIR) spectra of the adsorbed pyridine, and the performances of the catalysts for Prins condensation to isoprene from isobutylene and formaldehyde were investigated. The maximum isobutene conversion and isoprene selectivity were 10.3% and 94.6% on the HZSM-5 catalyst with a Si/Al molar ratio of 600 using 5%(mass fraction) phosphoric acid. The phosphoric acid modification not only modulated the amount of acidic sites but also regulated the acid type. An appropriate amount of weak Lewis and Brönsted acid sites served as the active sites for the condensation of isobutene with formaldehyde, and the strong acid sites could cause side reactions and coke deposition.     

FTIR研究不同硅铝比HZSM-5沸石的酸性质

用IR和NH₃-TPD测定了硅铝比为31.4～137.1的HZSM-5沸石样品的酸中心数;由Lang-muir吸附模型推导出B、L酸的吸附热公式,并由此计算了B酸的吸附热。发现在Al/u.c.为3.64附近,酸中心数与Al/u.c的关系发生了转折,并发现B酸吸附符合Langmuir模型,L酸强度不均匀而不符合该模型,测定了HZSM-5分子筛的B、L酸消光系数8_B=7.52×10⁵cm·mol^-1、8_L=1.09×10⁶cm·mol^-1。     

Influence of various aluminum distributions on modification of ZSM-5 zeolite framework with cobalt ions in alkane catalytic cracking

Research on Chemical Intermediates - HZSM-5 (HZ(1) and HZ(2)) zeolites synthesized with various framework aluminum distributions and also cobalt-modified H-form zeolites (Co/HZ(1) and Co/HZ(2))...     

17O magic angle spinning NMR studies of Brønsted acid sites in zeolites HY and HZSM-5

High-resolution 17O/1H double resonance NMR spectra were obtained for two zeolites, one with a low Si/Al ratio (zeolite HY) and one with a high Si/Al ratio (HZSM-5), to investigate their local structure and Br?nsted acidity. Two different oxygen signals, corresponding to Br?nsted acid sites in supercages and sodalite cages of zeolite HY were readily resolved in the two-dimensional (2-D) 1H-17O heteronuclear correlation (HETCOR) NMR spectra allowing the 17O isotropic chemical shift (deltaCS) and quadrupolar coupling parameters (quadrupolar coupling constant, QCC, and asymmetry parameter, eta) for the two oxygen atoms to be extracted. Similar experiments for HZSM-5 showed that the sites in this system are associated with a much larger distribution in NMR parameters than found in HY. 17O-1H rotational echo double resonance (REDOR) NMR was applied to probe the O-H distances in zeolites HY and HZSM-5. Weaker 17O-1H dephasing was observed for zeolite HZSM-5 in comparison to that of HY, consistent with longer O-H bonds and/or increased proton mobility.     

热处理对HZSM-5结构、酸性及催化乙醇脱水反应性能的影响

对商用HZSM-5分子筛进行高温热处理,利用X射线衍射(XRD)、核磁共振波谱法(²⁷Al-MAS NMR)低温氮吸附、电感耦和等离子体放射光谱(ICP-AES)、氨-程序升温脱附(NH₃-TPD)和吡啶吸附傅里叶变换红外(FT-IR)光谱等技术对高温热处理改性前后样品进行了表征,并考察了高温热处理对分子筛的结构、酸性及催化乙醇脱水制乙烯反应性能的影响。结果表明,热处理改性后的HZSM-5分子筛发生骨架脱铝,B酸减少,L酸增多,孔容增大,出现新的介孔;适中的酸性位和复合型的介-微双孔道结构使其减少了反应中的副反应,乙烯的选择性得到提高,催化剂寿命显著提高。     

含锆ZSM-5分子筛上丙烯齐聚反应的研究

以正丁胺(NBA)为模板剂，通过水热法直接合成了Zr/ZSM-5分子筛。XRD分析表明Zr/ZSM-5分子筛结晶度良好，但衍射峰的强度稍有差别。SEM显示样品分子筛表面规整，为3 μm～5 μm的棒状晶体。采用NH3-TPD法对分子筛进行了酸性测试，结果表明，在锆质量分数0.2%～1.2%，分子筛的中强酸和强酸量随锆质量分数的增加而增大，并向高温方向偏移。丙烯齐聚催化反应的活性评价结果显示，中强酸和强酸的量对Zr/HZSM-5催化性能有显著影响，在反应过程中对链的增长起促进作用。     

二甲苯在ZSM-5分子筛中的吸附与扩散

本文在298K-493K温度范围内,测定了二甲苯在ZSM-5分子筛中的吸附等温线和扩散系数。间二甲苯在HZSM-5分子筛中的吸附是需要较高活化能而为扩散控制的物理吸附,只有在较高温度下(>393K),才能进入分子筛的敛孔,其扩散系数比对二甲苯小三个数量级。对、间二甲苯在HZSM-5分子筛中的吸附量随温度升高而渐趋接近。但HZSM-5经镁改性后,间二甲苯吸附量大幅度下降,而对二甲苯吸附量变化不大,说明孔道结构因素对提高烷基苯转化的对位选择性起着相当重要的作用。增大分子筛的晶粒尺寸,二甲苯的扩散系数变化不大,表明大晶粒ZSM-5之所以能提高对位选择性,原因在于扩散路线的增长导致扩散较慢的间二甲苯异构化为扩散较快的对二甲苯。     

纳米薄层HZSM-5分子筛催化甲醇制丙烯

在合成系列硅铝比纳米薄层HZSM-5分子筛的基础上,研究了纳米薄层HZSM-5分子筛催化甲醇制丙烯(MTP)的反应性能.在固定床微反装置上详细考察了工艺条件对纳米薄层HZSM-5分子筛催化性能的影响,同时与纳米HZSM-5分子筛对MTP反应的催化性能进行了比较.结果表明,纳米薄层HZSM-5分子筛具有较高的目的产物选择性和较长的催化寿命.在适宜硅铝比(n(SiO2)/n(Al2O3)=213)和反应条件下(温度470°C,甲醇质量空速为3 h-1),丙烯的选择性达到46.7%,三烯(乙烯、丙烯和C4烯烃)选择性达到78.7%.其中,丙烯/乙烯的质量比可达到6.5,是纳米HZSM-5分子筛的2倍,而芳烃的选择性比纳米分子筛明显降低.这是因为纳米薄层HZSM-5分子筛比纳米HZSM-5分子筛具有较宽的(010)晶面、较大的外比表面积和介孔孔容.     

Persistent carbocations from 4,4′-dimethylaminodiphenylethylenes within CaY zeolite: intrazeolite-water controls the structure of the carbocation

Inclusion of 4,4′-dimethylaminodiphenylethylene and related olefins within activated CaY results in the formation of persistent monomer carbocations. The structure of the cation, consequently the color of the zeolite, is controlled by water molecules present within zeolites. Under ‘dry’ conditions the zeolite is light yellow and under ‘wet’ conditions it is blue colored. Blue color results from the quininoidal structure adopted by 1,1-bis-(4-dimethylaminophenyl)ethyl cation through participation of the lone pair electrons present on the amino substituent at the para position.     

Na_2CO_3溶液处理对Ni-Mo/HZSM-5分子筛硫醚化催化性能的影响

采用Na2CO3溶液对ZSM-5分子筛进行碱处理,考察了处理温度和处理时间对ZSM-5分子筛结构特征和物化性能的影响。利用XRD、N2吸附-脱附、XRF、SEM及NH3-TPD表征对处理前后样品进行分析。以正丁硫醇和异戊二烯组成的模型化合物为原料,对碱处理后含微-介孔HZSM-5分子筛制得的Ni-Mo/HZSM-5催化剂进行硫醚化活性评价。结果表明,Na2CO3溶液处理没有破坏原分子筛晶体形貌,保持微孔结构的同时,适当的提高处理温度和延长处理时间有利于ZSM-5分子筛比表面积、外比表面积、介孔孔容和平均孔径的增大,并调节了酸性质。但过长的处理时间并不利于介孔的生成和酸性的调变。经90℃的Na2CO3溶液处理5 h得到催化剂表现较高硫醚化活性,正丁硫醇和异戊二烯转化率分别可达92.36%和97.33%。由此,Na2CO3溶液处理可提高催化剂硫醚化活性,且改性过程温和可控。     

EFFECT OF SULFURIZATION ON THE PIIYSICAL ANDCATALYTIC PROPERTIES OF HZSM-5 ZEOLITES

IntroductionZSM-5zeoliteshavebeenwidelyemployedinthefieldofhydrocarbonconversion.UtiliZationofMo-containingandKorBamodifiedZSM-5zeolitestOactivatemethaneandtOpreparelightolefinsfromparaffinshavebeenreportedinourpreviouspapersll'2].However,littleattentionh…