Application of thermal analysis for evaluating the digestion of microwave pre-treated sewage sludge

The effect of microwave pre-treatment (MwP) on anaerobic digestion of sewage sludge was studied by means of thermal analysis and evolved gas analysis. The effect of the pre-treatment at low energy input (<1000 kJ L^?1) on sludge solubilisation was studied with the aid of response surface methodology. The pre-treatment process was subsequently studied at energies of 488–2700 kJ L^?1 to evaluate the improvement in biogas production under mesophilic conditions. Organic matter modifications were studied using a Setaram TGA92 analyser at atmospheric pressure coupled to an MSC200 quadrupole mass spectrometer from Balzers. Particle size analysis was carried out using a Laser Diffraction Particle Size Analyser LS 13 320 Beckmann Coulter for evaluating the effect of MwP on sludge particles. Results showed an increase in organic matter solubilisation with the increase in the energy applied. Modifications in the specific surface area of the organic matter due to the MwP resulted in increments in methane yields. However, an accumulation of complex compounds was observed in thermal profiles at the maximum energy input (2700 kJ L^?1). Semi-continuous digestion experiments were evaluated using as substrate pre-treated sludge at the optimum energy value (975 kJ L^?1). Results showed a significant increase in methane yield (43 %) when evaluating the process at hydraulic retention times (HRTs) of 25–10 days.     

Anaerobic Digestion of Yard Waste with Hydrothermal Pretreatment

The digestibility of lignocellulosic biomass is limited by its high content of refractory components. The objective of this study is to investigate hydrothermal pretreatment and its effects on anaerobic digestion of sorted organic waste with submerged fermentation. Hydrothermal pretreatment (HT) was performed prior to anaerobic digestion, and three agents were examined for the HT: hot compressed water, alkaline solution, and acidic solution. The concentrations of glucose and xylose were the highest in the sample pretreated in acidic solution. Compared with that of the untreated sample, the biogas yields from digesting the samples pretreated in alkaline solution, acidic solution, and hot water increased by 364, 107, and 79 %, respectively. The decrease of chemical oxygen demand (COD) in liquid phase followed the same order as for the biogas yield. The initial ammonia content of the treated samples followed the order sample treated in acidic solution > sample treated in alkaline solution > sample treated in hot water. The concentrations of volatile fatty acids (VFAs) were low, indicating that the anaerobic digestion process was running at continuously stable conditions.     

Thermal Pretreatment of Harvest Residues and Their Use in Anaerobic Co-digestion with Dairy Cow Manure

Several batch experiments were conducted on the anaerobic co-digestion of dairy cow manure (DCM) with three harvest residues (HR) (soybean straw, sunflower stalks, and corn stover). The influence of thermal pretreatment of HR on biogas production was investigated, where the HR were thermally pretreated at two different temperatures: T = 121 °C and T = 175 °C, during t = 30 and t = 90 min, respectively. All anaerobic co-digestion batch experiments were performed simultaneously under thermophilic regime, at T = 55 °C. Biogas and methane yields were significantly improved in experiments performed with corn stover thermally pretreated at 175 °C for 30 min (491.37 cm³/g VS and 306.96 cm³/g VS, respectively), if compared to experiments performed with untreated corn stover. The highest VS and COD removal rates were also observed in the same group of experiments and were 34.5 and 50.1%, respectively. The highest biogas and methane yields with soybean straw (418.93 cm³/g VS and 261.44 cm³/g VS, respectively) were obtained when soybean straw pretreated at 121 °C during 90 min. The highest biogas and methane yields with sunflower stalk (393.28 cm³/g VS and 245.02 cm³/g VS, respectively) were obtained when sunflower stalk was pretreated at 121 °C during 90 min.     

Pretreatment of Chicken Feather Waste for Improved Biogas Production

This study deals with the utilization of chicken feather waste as a substrate for anaerobic digestion and improving biogas production by degradation of the compact structure of the feather keratin. In order to increase the digestibility of the feather, different pretreatments were investigated, including thermal pretreatment at 120 °C for 10 min, enzymatic hydrolysis with an alkaline endopeptidase [0.53–2.66 mL/g volatile solids (VS) feathers] for 0, 2, or 24 h at 55 °C, as well as a combination of these pretreatments. The effects of the treatments were then evaluated by anaerobic batch digestion assays at 55 °C. The enzymatic pretreatment increased the methane yield to 0.40 Nm³/kg VS_added, which is 122 % improvement compared to the yield of the untreated feathers. The other treatment conditions were less effective, increasing the methane yield by 11–50 %. The long-term effects of anaerobic digestion of feathers were examined by co-digestion of the feather with organic fraction of municipal solid waste performed with and without the addition of enzyme. When enzyme was added together with the feed, CH₄ yield of 0.485 Nm³/kg VS^?1 d^?1 was achieved together with a stable reactor performance, while in the control reactor, a decrease in methane production, together with accumulation of undegraded feather, was observed.     

Biogas Production Potential and Kinetics of Microwave and Conventional Thermal Pretreatment of Grass

Pretreatment methods play an important role in the improvement of biogas production from the anaerobic digestion of energy grass. In this study, conventional thermal and microwave methods were performed on raw material, namely, Pennisetum hybrid, to analyze the effect of pretreatment on anaerobic digestion by the calculation of performance parameters using Logistic function, modified Gompertz equation, and transference function. Results indicated that thermal pretreatment improved the biogas production of Pennisetum hybrid, whereas microwave method had an adverse effect on the performance. All the models fit the experimental data with R ² > 0.980, and the Reaction Curve presented the best agreement in the fitting process. Conventional thermal pretreatment showed an increasing effect on maximum production rate and total methane produced, with an improvement of around 7% and 8%, respectively. With regard to microwave pretreatment, maximum production rate and total methane produced decreased by 18% and 12%, respectively.     

Hydrothermal pretreatment of rice straw at relatively lower temperature to improve biogas production via anaerobic digestion

The performances of rice straw (RS) degradation and biogas production were examined at different pretreatment temperatures from 90℃ to 130℃ to improve biogas fermentation efficiency and net energy production in whole slurry. Test at 100℃ pretreatment, which achieved 12.8% higher net energy production from RS than that observed in the control, could be considered as the optimal choice.     

Fungal Pretreatment by Phanerochaete chrysosporium for Enhancement of Biogas Production from Corn Stover Silage

Corn stover silage (CSS) was pretreated by Phanerochaete chrysosporium in solid-state fermentation (SSF), to enhance methane production via subsequent anaerobic digestion (AD). Effects of washing of corn stover silage (WCSS) on the lignocellulosic biodegradability in the fungal pretreatment step and on methane production in the AD step were investigated with comparison to the CSS. It was found that P. chrysosporium had the degradation of cellulose, hemicellulose, and lignin of CSS up to 19.9, 32.4, and 22.6 %, respectively. Consequently, CSS pretreated by 25 days achieved the highest methane yield of 265.1 mL/g volatile solid (VS), which was 23.0 % higher than the untreated CSS. However, the degradation of cellulose, hemicellulose, and lignin in WCSS after 30 days of SSF increased to 45.9, 48.4, and 39.0 %, respectively. Surface morphology and Fourier-transform infrared spectroscopy analyses also demonstrated that the WCSS improved degradation of cell wall components during SSF. Correspondingly, the pretreatment of WCSS improved methane production by 19.6 to 32.6 %, as compared with untreated CSS. Hence, washing and reducing organic acids (such as lactic acid, acetic acid, propionic acid, and butyric acid) present in CSS has been proven to further improve biodegradability in SSF and methane production in the AD step.     

Biogas Production from N-Methylmorpholine-N-oxide (NMMO) Pretreated Forest Residues

Lignocellulosic biomass represents a great potential for biogas production. However, a suitable pretreatment is needed to improve their digestibility. This study investigates the effects of an organic solvent, N-Methylmorpholine-N-oxide (NMMO) at temperatures of 120 and 90 °C, NMMO concentrations of 75 and 85 % and treatment times of 3 and 15 h on the methane yield. The long-term effects of the treatment were determined by a semicontinuous experiment. The best results were obtained using 75 % NMMO at 120 °C for 15 h, resulting in 141 % increase in the methane production. These conditions led to a decrease by 9 % and an increase by 8 % in the lignin and in the carbohydrate content, respectively. During the continuous digestion experiments, a specific biogas production rate of 92 NmL/gVS/day was achieved while the corresponding rate from the untreated sample was 53 NmL/gVS/day. The operation conditions were set at 4.4 gVS/L/day organic loading rate (OLR) and hydraulic retention time (HRT) of 20 days in both cases. NMMO pretreatment has substantially improved the digestibility of forest residues. The present study shows the possibilities of this pretreatment method; however, an economic and technical assessment of its industrial use needs to be performed in the future.     

Degradation of furfural (2- furaldehyde) to methane and carbon dioxide by an anaerobic consortium

Furfural, a byproduct formed during the thermal/chemical pre-treatment of hemicellulosic biomass, was degraded to methane and carbon dioxide under anaerobic conditions. The consortium of anaerobic microbes responsible for the degradation was enriched using small continuously stirred tank reactor (CSTR) systems with daily batch feeding of biomass pretreatment liquor and continuous addition of furfural. Although the continuous infusion of furfural was initially inhibitory to the anaerobic CSTR system, adaptation of the consortium occurred rapidly with high rates of furfural addition. Addition rates of 7.35 mg furfural/700-mL reactor/d resulted in biogas productions of 375%, of that produced in control CSTR systems, fed the biomass pretreatment liquor only. The anaerobic CSTR system fed high levels of furfural was stable, with a sludge pH of 7.1 and methane gas composition of 69%, compared to the control CSTR, which had a pH of 7.2 and 77% methane. CSTR systems in which furfural was continuously added resulted in 80% of the theoretically expected biogas. Intermediates in the anaerobic biodegradation of furfural were determined by spike additions in serum-bottle assays using the enriched consortium from the CSTR systems. Furfural was converted to several intermediates, including furfuryl alcohol, furoic acid, and acetic acid, before final conversion to methane and carbon dioxide.     

Effect of Double-Step Steam Explosion Pretreatment in Bioethanol Production from Softwood

The study investigated the production of bioethanol from softwood, in particular pine wood chip. The steam explosion pretreatment was largely investigated, evaluating also the potential use of a double-step process to increase ethanol production through the use of both solid and liquid fraction after the pretreatment. The pretreatment tests were carried out at different conditions, determining the composition of solid and liquid fraction and steam explosion efficiency. The enzymatic hydrolysis was carried out with Ctec2 enzyme while the fermentation was carried out using Saccharomyces Cerevisiae yeast “red ethanol”. It was found that the best experimental result was obtained for a single-step pretreated sample (10.6 g of ethanol/100 g of initial biomass dry basis) for a 4.53 severity. The best double-step overall performance was equal to 8.89 g ethanol/100 g of initial biomass dry basis for a 4.27 severity. The enzymatic hydrolysis strongly depended on the severity of the pretreatment while the fermentation efficiency was mainly influenced by the concentration of the inhibitors. The ethanol enhancing potential of a double-step steam explosion could slightly increase the ethanol production compared to single-step potential.     

Biological Pretreatment of Chicken Feather and Biogas Production from Total Broth

Chicken feathers are available in large quantities around the world causing environmental challenges. The feathers are composed of keratin that is a recalcitrant protein and is hard to degrade. In this work, chicken feathers were aerobically pretreated for 2–8 days at total solid concentrations of 5, 10, and 20 % by Bacillus sp. C₄, a bacterium that produces both α- and β-keratinases. Then, the liquid fraction (feather hydrolysate) as well as the total broth (liquid and solid fraction of pretreated feathers) was used as substrates for biogas production using anaerobic sludge or bacteria granules as inoculum. The biological pretreatment of feather waste was productive; about 75 % of feather was converted to soluble crude protein after 8 days of degradation at initial feather concentration of 5 %. Bacteria granules performed better during anaerobic digestion of untreated feathers, resulting in approximately two times more methane yield (i.e., 199 mlCH₄/gVS compared to 105 mlCH₄/gVS when sludge was used). Pretreatment improved methane yield by 292 and 105 % when sludge and granules were used on the hydrolysate. Bacteria granules worked effectively on the total broth, yielded 445 mlCH₄/gVS methane, which is 124 % more than that obtained with the same type of inoculum from untreated feather.     

Evaluation of Methanogenic Activity of Biogas Plant Slurry for Monitoring Codigestion of Ossein Factory Wastes and Cyanobacterial Biomass

Overall measurement of methanogenic activity of sludge and or slurry is thought as a key for understanding the basic physiology of anaerobic consortia involved in anaerobic digestion process of an alternative biomass. In this study, the methanogenic activity of biogas plant slurry was used to evaluate the anaerobic digestion of ossein factory wastes such as sinews and primary clarified bone waste (PCBW) and cyanobacterial biomass in standard assay conditions. A maximum methanogenic activity was reported here when ossein factory wastes mixed with cyanobacterial biomass in specific proportions in which sinews and PCBW alone also favored to a significant methane yield. Cyanobacterial biomass alone did not give a desirable methanogenic activity. Approximately 48% of total solids were destroyed from these wastes after 30 days. This study gives information on the use of these wastes with suitable proportions for taking an effort in a large-scale anaerobic digestion in an effective way of ossein factory.     

Dry Anaerobic Co-digestion of Cow Dung with Pig Manure for Methane Production

The performance of dry anaerobic digestions of cow dung, pig manure, and their mixtures into different ratios were evaluated at 35?±?1 °C in single-stage batch reactors for 63 days. The specific methane yields were 0.33, 0.37, 0.40, 0.38, 0.36, and 0.35 LCH₄/gVS_r for cow dung to pig manure ratios of 1:0, 4:1, 3:2, 2:3, 1:4, and 0:1, respectively, while volatile solid (VS) and chemical oxygen demand (COD) removal efficiencies were 48.59, 50.79, 53.20, 47.73, 46.10, and 44.88 % and 55.44, 57.96, 60.32, 56.96, 53.32, and 50.86 %, respectively. The experimental results demonstrated that the co-digestions resulted in 5.10–18.01 % higher methane yields, 2.03–12.95 % greater VS removals, 2.98–12.52 % greater COD degradation and so had positive synergism. The various mixtures of pig manure with cow dung might persuade a better nutrient balance and dilution of high ammonia concentration in pig manure and therefore enhanced digester performance efficiency and higher biogas yields. The dry co-digestion of 60 % cow dung and 40 % pig manure achieved the highest methane yield and the greatest organic materials removal efficiency than other mixtures and controls.     

Growth of Chlorella vulgaris on Sugarcane Vinasse: The Effect of Anaerobic Digestion Pretreatment

Microalgae farming has been identified as the most eco-sustainable solution for producing biodiesel. However, the operation of full-scale plants is still limited by costs and the utilization of industrial and/or domestic wastes can significantly improve economic profits. Several waste effluents are valuable sources of nutrients for the cultivation of microalgae. Ethanol production from sugarcane, for instance, generates significant amounts of organically rich effluent, the vinasse. After anaerobic digestion treatment, nutrient remaining in such an effluent can be used to grow microalgae. This research aimed to testing the potential of the anaerobic treated vinasse as an alternative source of nutrients for culturing microalgae with the goal of supplying the biodiesel industrial chain with algal biomass and oil. The anaerobic process treating vinasse reached a steady state at about 17 batch cycles of 24 h producing about 0.116 m³CH₄ kgCOD_vinasse ^?1. The highest productivity of Chlorella vulgaris biomass (70 mg l^?1 day^?1) was observed when using medium prepared with the anaerobic digester effluent. Lipid productivity varied from 0.5 to 17 mg l^?1 day^?1. Thus, the results show that it is possible to integrate the culturing of microalgae with the sugarcane industry by means of anaerobic digestion of the vinasse. There is also the advantageous possibility of using by-products of the anaerobic digestion such as methane and CO₂ for sustaining the system with energy and carbon source, respectively.     

Influence of Hydraulic Retention Time and Reactor Configuration During Fermentation of Diluted Chicken Manure

In this study, single-stage and two-phase semi-continuous thermophilic anaerobic reactors fed with diluted (3 % total solids (TS) and 1.8 % volatile solids (VS)) chicken manure at three different hydraulic retention times (HRTs) were compared interms of biogas production rate, methane content of the produced biogas, and VS and TS removal. Along the study, HRTs of 16, 12, and 8 days were implemented to the single-stage and the two-phase systems. It was observed that the single-stage anaerobic system was superior to the two-phase anaerobic system according to their biogas production rates (517 vs. 356, 551 vs. 359, 459 vs. 386 (mL/g VS_feed)) at all HRTs. On the other hand, methane content of the biogas produced was higher in the two-phase system compared to the single-stage system.     

Influence of selected biowaste materials pre-treatment on their anaerobic digestion

The topic of this study is the pre-treatment of substrates for anaerobic digestion. Two different substrates of algae Scenedesmus subspicatus (SAG 86.81), Chlorella kessleri (LARG/1) and foliage of Prunus serrulata were subjected to anaerobic digestion. A mixture of commercially available cellulolytic enzymes (Analytical science s.r.o., Modra, Slovakia) was used for anaerobic treatment of algae while the foliage of Prunus serrulata was pre-treated by lignolytic fungi. The highest production of methane per mass of volatile solids was reached with untreated Chlorella kessleri at (0.59 ± 0.04) L g⁻¹. The addition of cellulolytic enzymes did not increase the production of methane from the algal substrate; however, a faster substrate degradation and thus also higher speed of methane production at the beginning of cultivation was achieved. After foliage pre-treatment by fungal isolate Pleurotus pulmonarius, isolated from natural habitats, the methane production increased five times. In this way we were able to speed up the processes of biological degradation of ligno-cellulose materials and thereby to increase the production of methane. Our results show the possibility of using algae as a suitable substrate for biogas production. On the other hand, also aerobic pre-treatment of foliage (Pleurotus pulmonarius) presents a successful way for speeding up the degradation of ligno-cellulose waste leading to increased methane yields.     

Direct and selective methanation of biomass via oxygenvacancy‐mediated catalysis

正Producing biofuels from renewable biomass resources is considered to be an effective way to reduce carbon emissions and is helpful for establishing sustainable society [1]. Bio‐methane (CH4) is a promising and available clean energy in the future owing to its properties such as high calorific values, low carbon emissions and full miscibility and interchangeability with natural gas or shale gas. Therefore, the production of me‐thane directly from waste biomass resources like straw is highly attractive. However, because of the robustness and vari‐ety of C–C bonds and C–O bonds existing in biomass molecules,it is very difficult to achieve high‐selective methanation of bio‐     

Microbial Pretreatment of Corn Stovers by Solid-State Cultivation of Phanerochaete chrysosporium for Biogas Production

The microbial pretreatment of corn stover and corn stover silage was achieved via the solid-state cultivation of Phanerochaete chrysosporium; pretreatment effects on the biodegradability and subsequent anaerobic production of biogas were investigated. The peak levels of daily biogas production and CH₄ yield from corn stover silage were approximately twice that of corn stover. Results suggested that ensiling was a potential pretreatment method to stimulate biogas production from corn stover. Surface morphology and Fourier-transform infrared spectroscopy analyses demonstrated that the microbial pretreatment of corn stover silage improved biogas production by 10.5 to 19.7 % and CH₄ yield by 11.7 to 21.2 % because pretreatment could decrease dry mass loss (14.2 %) and increase substrate biodegradability (19.9 % cellulose, 32.4 % hemicellulose, and 22.6 % lignin). By contrast, the higher dry mass loss in corn stover (55.3 %) after microbial pretreatment was accompanied by 54.7 % cellulose, 64.0 % hemicellulose, and 61.1 % lignin degradation but did not significantly influence biogas production.     

In situ Removal of Hydrogen Sulfide During Biogas Fermentation at Microaerobic Condition

In this paper, rice straw was used as a raw material to produce biogas by anaerobic batch fermentation at 35 °C (mesophilic) or 55 °C (thermophilic). The hydrogen sulfide in biogas can be converted to S⁰ or sulfate and removed in-situ under micro-oxygen environment. Trace oxygen was conducted to the anaerobic fermentation tank in amount of 0.5, 1.0, 2.0, 3.0, 4.0, 5.0, or 10.0 times stoichiometric equivalence, respectively, and the control experiment without oxygen addition was carried out. The results showed that the initial H₂S concentrations of biogas are about 3235?±?185 mg/m³ (mesophilic) or 3394?±?126 mg/m³ (thermophilic), respectively. The desulfurization efficiency is 72.3 % (mesophilic) or 65.6 % (thermophilic), respectively, with oxygen addition by stoichiometric relation. When the oxygen feeded in amount of 2～4 times, theoretical quantity demanded the removal efficiency of hydrogen sulfide could be over 92 %, and the oxygen residue in biogas could be maintained less than 0.5 %, which fit the requirement of biogas used as vehicle fuel or combined to the grid. Though further more oxygen addition could promote the removal efficiency of hydrogen sulfide (about 93.6 %), the oxygen residue in biogas would be higher than the application limit concentration (0.5 %). Whether mesophilic or thermophilic fermentation with the extra addition of oxygen, there were no obvious changes in the gas production and methane concentration. In conclusion, in-situ desulfurization can be achieved in the anaerobic methane fermentation system under micro-oxygen environment. In addition, air could be used as a substitute oxygen resource on the situation without strict demand for the methane content of biogas.