组合式多壳程螺旋折流板管壳式换热器数值模拟研究

本文采用数值模拟方法对内壳程为非连续螺旋折流板的组合式螺旋折流板和单壳程弓形折流板管壳式换热器壳侧流动换热特性进行对比研究,结果表明:相同壳程质量流量和相同换热量条件下,组合式两壳程螺旋折流板换热器的压损比弓形折流板换热器降低14.6%;相同壳程质量流量条件下,组合式两壳程螺旋折流板换热器单位压降下换热量比弓形折流板换热器提高10.8%.     

螺旋折流板换热器流动与换热特性的试验分析

对螺旋折流板换热器的流动及换热特性进行了试验研究与分析.结果表明,当保持螺旋周期为定值时,在相同流量下和相同壳径下,螺旋折流板换热器的壳侧压降随螺旋角增大而减小,且远低于弓形折流板的管壳式换热器;壳径减 小时,压降增加明显.相同Re下,螺旋折流板换热器的壳侧换热系数低于弓形折流板,在螺旋角为40°时达到最大值.相同流量下,螺旋折流板管壳式换热器单位压降和单位泵功下的换热系数均高于弓形折流板管壳式换热器.     

双螺旋与中间搭接螺旋折流板换热器性能研究

采用数值模拟方法研究了40°螺旋角时螺旋折流板换热器双螺旋和中间搭接两种折流板布置形式对壳程性能与螺旋流动的影响,并与30°和40°螺旋角时单螺旋连续搭接结构的进行了对比.结果表明,40°螺旋角时双螺旋和中间搭接结构会强化壳程流体的螺旋流动,使同流量下壳程换热系数与压降增加,但同压降下的换热系数显著下降且均低于30°螺...     

周向重叠三分螺旋折流板换热器壳侧性能试验研究

对倾斜角为20°、24°、28°和32°的单头以及32°的双头周向重叠三分螺旋折流板换热器和弓形折流板换热器的传热和压降性能进行了测试,换热器采用公共壳体和可更换管芯结构。采用壳侧轴向雷诺数和轴向欧拉数分别作为反映壳侧流量和阻力系数的无因次参数。试验结果显示在试验范围内周向重叠三分螺旋折流板换热器壳侧换热系数、壳侧压降和综合性能指标都随着倾斜角增大而减小;倾斜角20°方案的性能指标最佳,其平均壳侧努塞尔数和轴向欧拉数与弓形折流板方案的数值之比分别为1.123和0.45;双头螺旋折流板方案的换热系数和压降都大于同样倾斜角的单头螺旋折流板方案,但两者的综合性能较接近。     

斜向流换热器壳程流场均匀化研究

传统弓形折流板换热器壳程流体横向流动时存在流动阻力和传热死区大等缺点。为克服上述不足,研究开发了一种新型高效节能的斜向流管壳式换热器,采用导向型折流栅替代传统弓形折流板,倾斜流道内流体斜向冲刷换热管束。考察和对比了斜向流换热器和弓形折流板换热器壳程主流区的流体流速分布和变化规律,证实了导向型折流栅具有显著的控涡均化壳程流场和提高壳程流体整体流速的作用,有助于减小壳程压降,增大有效换热面积,为管壳式换热器结构改良提供了参考依据。     

三分螺旋折流板换热器壳侧传热特性研究

本文给出了三分螺旋折流板换热器几何参数的关系式,并分析了倾斜角为10°、15°、20°扇形、15°椭圆、20°扇形搭接的三分螺旋折流板换热器和弓形折流板换热器的传热和压降性能测试实验结果。结果显示20°扇形折流板方案的壳侧换热系数较高且压降较低,其性能指标h_o/△p_o~(1/3)平均值比弓形折流板换热器的值高26%;20°扇形搭接方案与螺距相仿的15°扇形方案的性能大致相当;15°扇形方案比螺距较小的15°椭圆方案的性能更高。结果表明对换热器的性能起决定作用的不是折流板的倾斜角而是当量螺旋角。     

弓形折流板换热器中折流板对换热器性能的影响

本文采用Bell-Delaware换热器设计方法研究了传统弓形折流板换热器加热轻油时在不同管束排列角度下,改变换热器壳侧折流板间距以及改变折流板的窗口高度对管壳式换热器的壳体内径、换热管数目、壳侧换热系数及壳侧压降的影响.     

阶梯式螺旋折流板换热器流动与传热特性研究

针对现有的螺旋折流板换热器加工较为复杂,并且非连续型螺旋折流板的相邻折流板间存在漏流的问题,提出了一种新型阶梯式螺旋折流板换热器。通过数值模拟的方法对阶梯式螺旋折流板换热器和弓形折流板换热器进行对比,研究其壳程流动与传热特性。结果表明,阶梯式螺旋折流板换热器能够使壳侧流体呈近似螺旋状流动,综合性能优于弓形折流板换热器,速度分布更加均匀。     

连续螺旋折流板蒸发器壳侧流动换热数值模拟研究

本文对相同几何尺寸的连续螺旋折流板蒸发器与传统弓形折流板蒸发器进行对比性的数值模拟研究,结果表明:在相同壳侧体积流量和折流板数条件下,连续螺旋折流板蒸发器的传热因子和摩擦因子约是弓形折流板的1/3和1/4;当以换热因子和摩擦因子比值评价蒸发器综合性能时,连续螺旋折流板蒸发器比弓形折流板蒸发器提高57%;当最小流通截面流...     

新型螺旋梅花形孔板换热器热力性能仿真计算

依据涡旋流动强化传热技术,变传统直流道的梅花形支撑孔板为螺旋流道的梅花形支撑孔板,进而设计出一种新型螺旋梅花形孔板换热器,建立了相应的数学模型,并对其传热与流动特性进行了仿真计算。通过与梅花形孔板换热器的对比分析,展示了新型换热器壳程强化换热机理,并进一步探索了螺旋流道的螺旋角对新型换热器的影响。计算结果表明:在研究范围内,新型换热器壳程平均对流换热系数高于传统换热器,但同时壳程压降也相对应增加,在一定雷诺数范围内新型换热器综合性能参数优于传统换热器。当螺旋角为27°、雷诺数小于19672时,其综合性能比传统换热器较佳;探究了不同螺旋角的影响,发现螺旋角越大,新型换热器压降越大,同时换热能力也越强。     

Guided-Wave Two-Dimensional Acousto-Optic Scanner Using Proton-Exchanged Lithium Niobate Waveguide

Two-dimensional scanning of a 0.6328 mum guided-light beam has been realized using noncolinear acousto-optic (AO) coplanar Bragg diffraction together with colinear AO guided-mode to substrate radiation-mode conversion in a Z-cut Xpropagation LiNbO3 proton-exchanged (PE) waveguide. The two surface acoustic (SAW) waves utilized are at the center frequencies of 500 and 200 MHz, propagating in the Y and X axes, respectively. Two-dimensional scanning of approximately 720 resolvable light beam spots, namely, 18 40 (horizontal vertical) scanning, has been demonstrated using a light beam of 1.0 mm aperture. The total number of resolvable beam spots can be greatly increased from 720 by simply utilizing SAW transducers of larger bandwidth and a light beam of greater aperture. It should also be possible to significantly increase the diffraction efficiency from 3 % by optimizing the parameters of the PE waveguide and the SAWs.     

Hybrid Wavelength and Code Division Multiple Access in Optical Networks

A review of schemes for multiple access in fiber optic networks shows that a hybrid of wavelength and code division multiple access (WCDMA) combines the best features of both. In particular, the hybrid scheme retains the large information carrying capacity of wavelength division multiple access (WDMA) and flexibility of code division multiple access (CDMA). In this paper WDMA, optical CDMA (OCDMA), and WCDMA networks are discussed. In OCDMA networks, concept of incoherent and coherent coding including inverse decoding and matched filter is introduced. The delay performance of both WDMA and WCDMA networks, under the simple suboptimum access protocols based on cyclic search, is computed. It has been shown quantitatively that tuning delay significantly affects the delay performance of both WDMA and WCDMA networks. Futhermore, delay performance of WCDMA networks is always better than the WDMA networks for the same tuning delay, load, and number of users.     

Femtosecond Transform-Limited Pulse Generation by Compensating for the Linear Chirp of SPM Spectra in Dispersion Shifted Fibers

A simple technique of pulse compression, based on the linear chirp compensation of self-phase modulation (SPM) spectra in dispersion shifted fibers, is demonstrated. The optimization procedure is carried out, for a short span of a single-mode fiber, using a parabolic law, which describes the behavior of the squared output pulse width versus the pump peak power in the case of Gaussian pulses. The experimental results give a minimum pulse duration of 233 fs, which is in good agreement with the model. Shorter and coherent pulses, down to 90 fs, have been obtained by inserting an interference filter at the optical output.     

Effect ofγ-radiation on the spectral luminescence characteristics of impure cadmium tungstate crystals

Results of a study of the effect of γ-radiation on the spectral luminescence properties of cadmium tungstate crystals doped with silver, bismuth, and molybdenum cations are presented. Spectral characteristics of the nondnnnoped crystals are briefly described. Absorption and photo and X-ray luminescence spectra of the crystals taken before and after exposure to γ-radiation (5.5·10⁴ Gy) are compared. It is found that the spectral characteristics of the crystals doped with silver, bismuth, and molybdenum cations do not change markedly after the exposure. The relation between the type of impurity-induced defects, individual characteristics of the impurity cations, and the character of the effect of γ-radiation on the spectral luminescence properties of impure crystals is analyzed (preliminarily). Translated from Zhurnal Prikladnoi Spektroskopii, Vol. 64, No. 1, pp. 55–60, January–February, 1997.     

Theoretical analysis and simulation of conjugate heights for dual-conjugate AO system in lidar

A multi-conjugate adaptive optics （MCAO） can offer a possibility of widening field of view （FOV） characterized by the isoplanatic angle, and the choose of conjugate height becomes a basic problem for MCAO, which influences the size of iosplanatic angle. Considering the application of lidar, the isoplanatic angle＇s expressions of two deformable mirrors （DMs） MCAO for uplink and downlink are deduced. The effects of conjugate heights for dual-conjugate AO are thoughtfully discussed, and the isoplanatic angles are further analyzed. The results show that the isopanatic angle varies with the conjugate height and reaches the maximum as the conjugate height is at the optimal altitude. Moreover, the optimal conjugate height changes with the propagation distance.     

Quick single-photon detector with many avalanche photo diodes working on the time division

Due to the limit of response speed of the present single-photon detector, the code rate is still too low to come into practical use for the present quantum key distribution (QKD) system.A new idea is put up to design a quick single-photon detector.This quick single-photon detector is composed of a multi-port optic-fiber splitter and many avalanche photo diodes (APDs).Au of the ports with APDs work on the time division and cooperate with a logic discriminating and deciding unit driven by the clock signal.The operation frequency lies on the number N of ports, and can reach N times of the conventional single-photon detector.The single-photon prompt detection can come true for high repetition-rate pulses.The applying of this detector will largely raise the code rate of the QKD, and boost the commercial use.     

Research on beamforming method for dual-line array with space mismatch between the two line arrays

The performance of port/starboard discrimination of dual-line array will be seriously degraded when the space between the two line arrays of the dual-line array is mismatched. The directivity function of the delay-sum and delay-subtract beamforming is deduced and the port/starboard discrimination of the delay-sum and delay-subtract beamforming is also studied both under the ideal status and the status under which the space between the two line arrays of the dual-line array is mismatched. Analysis results show the delay-subtract beamforming has better performance of port/starboard discrimination. At last, the sea trial results demonstrate the theoretical results.     

Sorting of bending magnets for the SSRF booster

The Shanghai Synchrotron Radiation Facility(SSRF)booster ring,a full energy injector for the storage ring,is deigned to accelerate the electron beam energy from 150MeV to 3.5GeV that demands high extraction efficiency at the extraction energy with low beam loss rate when electrons are ramping.Closed orbit distortion(COD)caused by bending magnet field uniformity errors which affects the machine performance harmfully could be effectively reduced by bending magnet location sorting.Considering the affections of random errors in measurement,both ideal sorting and realistic sorting are studied based on measured bending magnet field uniformity errors and one reasonable combination of bending magnets which can reduce the horizontal COD by a factor of 5is given as the final installation sequence of the booster bending magnets in this paper.