Cross-axis synchronous flow-through coil planet centrifuge for large-scale preparative counter-current chromatography. I. Apparatus and studies on stationary phase retention in short coils

Using a new cross-axis synchronous flow-through coil planet centrifuge with a 20-cm revolutional radius, the retention of the stationary phase for nine solvent systems was studied with short coils mounted at two different locations on three holders with 5-, 15- and 25-cm hub diameters. Coils mounted 10 cm to the left of the center of a holder produced a much improved retention of most of the solvent systems compared with the same coils mounted at the center of the holder. In the lateral coil position the retention was found to be affected by the direction of the planetary motion and the head-tail elution mode. This phenomenon may be attributed to the effect of the lateral force field acting asymmetrically between the upper and lower halves of the coil.     

Water-organic solvent systems in countercurrent chromatography: Liquid stationary phase retention and solvent polarity

Countercurrent chromatography (CCC) is a separation technique in which the stationary phase is a liquid. The liquid stationary phase retention is a critical problem in CCC. The retention of 18 organic solvents in a hydrodynamic CCC apparatus was measured with an aqueous mobile phase, the centrifuge spin rate and the mobile phase flow rate being constant, 800 rpm and 2 ml/min, respectively. Conversely, water retention was measured when the 18 solvents were the mobile phases. A direct relationship between the liquid stationary phase retention and the phase density difference was found. The liquid phase density difference is the most important parameter for stationary phase retention in a hydrodynamic CCC apparatus with coiled tubes. The chromatographic retention of formanilide was measured in biphasic systems and expressed as the formanilide partition coefficient. It is shown that the partition coefficient correlates with the Reichardt polarity index of the organic solvent when the liquid stationary phase retention volume does not.     

Multilayer coil planet centrifuge for analytical high-speed counter-current chromatography

A compact portable model of a high-speed counter-current chromatograph enables efficient analytical separations of microgram sample quantities within 10 min. A series of preliminary experiments was conducted to study retention of the stationary phase of various two-phase solvent systems in short coils with different helical diameters. Under the optimal experimental conditions, analytical capability of the apparatus was successfully demonstrated in separation of flavonoids from a crude sea buckthorn ethanol extract in a multilayer coil with a total capacity of 8 ml.     

Cross-axis synchronous flow-through coil planet centrifuge (type XLL). I. Design of the apparatus and studies on retention of stationary phase

The fourth prototype holds a pair of column holders in the lateral position at 15 cm from the center of the rotary shaft horizontally mounted on the rotary frame at 7.6 cm from the central axis of the apparatus. Using short coils of 2.6 mm I.D. PTFE (polytetrafluoroethylene) tubing with 7.6 cm and 24 cm helical diameters, retention of the stationary phase was measured in ten pairs of two-phase solvent systems under various experimental conditions. Satisfactory retention was obtained by choosing proper combinations of three factors, i.e., the direction of planetary motion, head-tail elution mode, and inward-outward elution mode. The polar butanol solvent systems showed excellent retention from 65 to 80% in the 7.6 cm helical diameter left-handed coil.     

Spiral coils for counter-current chromatography using aqueous polymer two-phase systems

Retention properties of polyethylene glycol-phosphate aqueous two-phase systems in a spiral coil (5 mm I.D.) on Type-J synchronous counter-current chromatographic devices have been compared for the elution mode where the lower phase is the mobile phase and flows from the inside head terminal. This was achieved with the aid of digital imaging under stroboscopic illumination, an image analysis and measurement of the displaced volume of the stationary phase. For the spiral coil, high and stable stationary phase retention at mobile phase flow rates up to 64 ml/min has been obtained. Wave-like disturbance of the interface near the proximal point was observed and analyses have been made for possible use in protein separation.     

Cross-axis synchronous flow-through coil planet centrifuge (type XLL). II. Speculation on the hydrodynamic mechanism in stationary phase retention

The hydrodynamic mechanism involved in the retention of stationary phase in the present x-axis coil planet centrifuge system is discussed. A statistical treatment of the retention data disclosed important clues such as the effect of the inward-outward elution mode, the close correlation between the planetary motion and the head-tail elution mode, and the superior retention capacity of the left-handed coils. The combined effects of the radial and lateral centrifugal force field derived from the mathematical analysis of acceleration acting on the coil provide an explanation for the phenomena.     

New angle rotor coil planet centrifuge for counter-current chromatography. II. Design of the apparatus and studies on phase retention and partition capability

A new angle rotor coil planet centrifuge (psi = 25 degrees), which produces a Type J-L synchronous planetary motion, has been constructed to examine its capability in terms of stationary phase retention and solute partitioning. Studies on phase distribution diagrams obtained from various two-phase solvent systems indicated that the present system can be adapted to a wide variety of solvent systems by adjusting the centrifugal conditions. Excellent partition capability of the apparatus was successfully demonstrated in separations of dinitrophenyl amino acid samples with chloroform-acetic acid-0.1 N hydrochloric acid (2:2:1).     

Improved cross-axis synchronous flow-through coil planet centrifuge for performing counter-current chromatography. I. Design of the apparatus and analysis of acceleration

A novel design of the cross-axis synchronous flow-through coil planet centrifuge is introduced. The apparatus holds a pair of large coil holders symmetrically, one on each side of the rotary frame, at a lateral position 12.5 cm from the center of the holder shaft held 10 cm from the centrifuge axis. Mathematical analysis of acceleration generated by the planetary motion of the apparatus revealed a unique centrifugal force field which promises high retention of the stationary phase in the multilayer coil to perform efficient preparative-scale counter-current chromatography.     

pH-gradient counter-current chromatography isolation of natural antioxidant chlorogenic acid from Lonicera japonica Thumb. using an upright coil planet centrifuge with three multi-layer coils connected in series

A new pH-gradient counter-current chromatography method for the isolation of chlorogenic acid from flowers and buds of Lonicera japonica Thumb. has been successfully established using a novel upright coil planet centrifuge with three multi-layer coils connected in series with 600 mL capacity. The crude extracts were first prepared by direct extraction with hot water and following concentration to remove the solution. Then the two-phase solvent system composed of ethyl acetate-n-butanol-water (2:1:3, v/v) was applied to the separation. Its neutral upper phase was used as stationary phase, whereas both its neutral lower phase and base lower phase with 10mM NH(3) were employed as mobile phase with gradient elution in the head to tail mode. As a result, 330 mg quantity of crude extract was purified in one-step separation for 180 min, yielding 20.5mg chlorogenic acid with over 98% purity. Structure of the compound is further identified by electrospray ionization tandem mass spectrometry (ESI-MS/MS) and nuclear magnetic resonance (NMR).     

Retention characteristics of chlorinated polycyclic aromatic hydrocarbons in normal phase HPLC. II. Chloro-substituted PAHs

Summary The retention behaviour of chloro-substituted PAHs on several commercial normal bonded phase HPLC columns has been investigated. Chloro-substitution was shown to generally decrease the retention on stationary phases like amino-, diol- and nitrophenylpropyl-modified silica. Dimethylaminosilica exhibited more complex retention characteristics towards chloro-substituted PAHs. On this stationary phase, the position of the chlorine substituents on the aromatic solute seemed to be of greater importance for retention than on the amino-, nitro- and diolsilica. For some chloro-PAHs, the retention was shown to increase with the number of chloro-substitutions, probably due to the large affinity of the electron-rich nitrogen in the stationary phase for the electron deficient -system of the chloro-PAHs. Chloro-substituted PAHs were strongly retarded on the electron donating 2-(1-pyrenyl)-ethylsilica (PYE) stationary phase. However, the molecular shape of the chloro-derivatives had a large influence on retention, which was considerably decreased for some nonplanar chloro-derivatives of chrysene and benz(a)anthracene. A two-dimensional back-flush HPLC method, consisting of a combination of a nitrophenylsilica column and a PYE column of matched lengths, was shown to be useful for clean-up of chloro-substituted PAHs in environmental samples.     

Photo-responsive retention behavior of azobenzene-modified cyclodextrin stationary phase in micro-HPLC.

An azobenzene-modified gamma-cyclodextrin stationary phase (Az gamma-CDSP) was prepared and its photo- and temperature-responses for the retention of perylene and pentacene were investigated using a mixture of methanol and water as the mobile phase in micro-HPLC. The retention of perylene slightly increased, whereas that of pentacene significantly decreased by UV light irradiation to Az gamma-CDSP. These retentions recovered upon irradiation with visible light. Both retentions decreased upon an increase in the column temperature. It was presumed that the trans-azobenzene moiety acts as a preventive cap for perylene and a spacing for pentacene in filling the CD cavity. An azobenzene-modified stationary phase changed its retention behavior with the column temperature and the light irradiation. An improvement in the micro-HPLC system and the optimization of the molecular structure of the photo-responsive stationary phase would provide selective retention control by the irradiation of light in micro-separation systems.     

正交设计试验优化高速逆流色谱分离制备玛咖中芥子油苷的条件

基于高速逆流色谱（HSCCC）技术从玛咖中分离制备出两种芥子油苷,苄基芥子油苷（glucotropaeolin, GTL）和甲氧基苄基芥子油苷（glucolimnanthin, GLI）。使用正交设计试验对分离条件进行优化,采用高分辨质谱对制备的组分进行鉴定,采用高效液相色谱法（HPLC）对组分进行定量分析。确定了两个组分GTL与GLI的HSCCC最佳分离条件：溶剂系统为正丁醇-乙腈-200 g/L硫酸铵溶液（1:0.5:2.4, v/v/v）,上相为固定相,下相为流动相,流动相流速2 mL/min,主机转速900 r/min,从玛咖根粗提物中一次性分离得到157.72 mg/kg纯度为97.9%的苄基芥子油苷和31.93 mg/kg的甲氧基苄基芥子油苷,固定相保留率达57.6%。该方法成本低,简便易行,样品损失量小,可大量循环进样制备。     

Optimization of a high speed countercurrent chromatograph for analytical separations

The analytical capability of the high speed countercurrent chromatograph model 4000 (HSCCC-4000) has been improved by optimizing the dimensions of the multilayer coiled column. Using a two-phase solvent system of n-hexane – ethyl acetate – methanol – water (1:1:1:1) and a set of indole auxins as test samples, a series of studies was conducted to evaluate performance of coiled columns with i.d.s ranging from 0.1 to 0.55 mm. The studies on the stationary phase retention indicated that multilayer coils of 0.55 mm and 0.30 mm i.d. provide satisfactory retention of the stationary phase while the 0.10 mm i.d. column fails to yield reproducible retention. The best partition efficiencies were obtained from the 0.30 mm i.d. multilayer coil with a 6 ml capacity which produced theoretical plate numbers ranging from 5500 to 10500 with a resolution factor of 2.30. The feasibility of interfacing the HSCCC-4000 with a mass spectrometer is briefly discussed.     

高速逆流色谱双水相体系分离蛋白质

利用多分离柱高速逆流色谱仪,研究了聚乙二醇1000(PEG1000)-磷酸盐双水相体系的固定相保留率及该体系对蛋白质混合物和鸡蛋清样品的分离。以14.0%PEG1000-16.0%磷酸盐体系的上相为固定相,在流速0.6 mL/min和转速900 r/min的条件下,固定相的保留率达到33.3%。在pH 9.2的PEG1000-磷酸盐双水相体系中,细胞色素C、溶菌酶和血红蛋白的分配系数差异最大,采用该pH值的14.0%PEG1000-16.0%磷酸钾盐双水相体系,在流速1.0 mL/min和转速850 r/min的条件下,成功地分离了这3种蛋白质的混合物。鸡蛋清中的主要蛋白质成分卵转铁蛋白、卵白蛋白和溶菌酶在pH 9.2的15.0%PEG1000-17.0%磷酸钾盐体系中也具有最大的分配系数差异。采用该体系,在流速1.0 mL/min和转速850 r/min的条件下,成功地分离了鸡蛋清样品,得到的卵白蛋白、溶菌酶和卵转铁蛋白的电泳纯度分别为100％,100％和60％,收率均大于90％。     

High-performance liquid chromatography of substituted p-benzoquinones and p-hydroquinones. II. Retention behavior, quantitative structure-retention relationships and octanol-water partition coefficients

The retention behavior of methoxy-substituted p-benzoquinones and the corresponding hydroquinones in reversed-phase chromatography was examined on octylsilica and two octadecylsilica stationary phases and with five hydroorganic mobile phases containing acetonitrile, methanol or tetrahydrofuran and additionally in most cases (NH3OH)3PO4 used as a reducing and buffering agent. The retention order of benzoquinones and hydroquinones was the same on each stationary phase with either methanol or acetonitrile as the organic modifier. On the other hand, minor differences in the retention order were observed with the various stationary phases. In all cases, satisfactory quantitative structure-retention relationships (QSRRs) were found and the data suggest that the differences in the retention behaviour of octadecylsilicas used in this study are silanophilic interactions which, together with solvophobic interaction contribute to the retention of these eluites. Further analysis showed that QSRRs of sterically crowded molecules must take into account reduced surface area available for binding. The retention data obtained with use of aqueous tetrahydrofuran as mobile phase failed to give rise to satisfactory QSRRs. This was attributed to selective solvation of eluite by tetrahydrofuran and/or nearly equipotent binding of eluite and tetrahydrofuran to stationary phase.     

Characterisation of stationary phases in subcritical fluid chromatography with the solvation parameter model. III. Polar stationary phases

In this third paper, varied types of polar stationary phases, namely silica gel (SI), cyano (CN)- and amino-propyl (NH2)-bonded silica, propanediol-bonded silica (DIOL), poly(ethylene glycol) (PEG) and poly(vinyl alcohol) (PVA), were investigated in subcritical fluid mobile phase. This study was performed to provide a greater knowledge of the properties of these phases in SFC, and to allow a more rapid and efficient choice of polar stationary phase in regard of the chemical nature of the solutes to be separated. The effect of the nature of the stationary phase on interactions between solute and stationary phases and between solute and carbon dioxide-modifier mobile phases was studied by the use of a linear solvation energy relationship (LSER), the solvation parameter model. The retention behaviour observed with sub/supercritical fluid with carbon dioxide-methanol is close to the one reported in normal-phase liquid chromatography with hexane. The hydrogen bond acidity and basicity, and the polarity/polarizability favour the solute retention when the molar volume of the solute reduces it. As with non-polar phases, the absence of water in the subcritical fluid allows the solute/stationary phase interactions to play a greater part in the retention behaviour. As expected, the DIOL phase and the bare silica display a similar behaviour towards acidic and basic solutes, when interactions with basic compounds are lower with the NH2 phase. On the CN phase, all interactions (hydrogen bonding, dipole-dipole and charge transfer) have a nearly equivalent weight on the retention. The polymeric phases, PEG and PVA, provide the most accurate models, possibly due to their better surface homogeneity.     

Photo-response assisted enantiomer separations on an azobenzene-modified gamma-cyclodextrin stationary phase in micro-HPLC.

The photo-responses of the retention and enantioseparation of several optical isomers were evaluated using an azobenzene-modified gamma-cyclodextrin stationary phase (Az gamma-CDSP) in micro-HPLC. UV light irradiation induced a decrease in the retention and the chiral selectivity for N-(3,5-dinitrobenzoyl)-1-phenylethylamine (DNBPEA) and N-(3,5-dinitrobenzoyl)-1-(1-naphtylethyl)amine (DNBNEA), while an increase was induced for dansylphenylalanine (DnsPhe) using a mixture of methanol and aqueous phosphate buffer as the mobile phase. No changes in the retention and the enantiomer separation of benzoin were observed with UV light irradiation. The retention behaviors were recovered by visible-light irradiation. It was speculated that the main factor of the change in the retention behavior was a change in the pi-pi interaction due to the azobenzene moiety of the stationary phase with photo-irradiation. Comparing the retention behavior before and after UV light irradiation, a suitable condition for obtaining a better resolution and enantiomer separation would be chosen using Az gamma-CDSP.     

Support-free pulsed liquid–liquid chromatography

A simple technique of support-free liquid–liquid chromatography is suggested that operates without incorporation of a centrifuge. The pulsed chromatography apparatus consists of a stationary coiled tube and a pulsation device to produce reciprocating motion of liquid phases within each individual coil segment. This reciprocating motion generates a centrifugal force field varying in intensity and direction that leads to an improved mixing of the two liquid phases and retains the stationary phase in the coiled tubing. The intensity of the back and forth motion of liquid phases within each coil unit can be varied by varying the frequency and/or the amplitude of the pulsations generated by the pulsation device. As the magnitude of the stationary phase retention is of paramount importance for success of the technique, the retention of the stationary phase in the pulsed coil column was experimentally studied. A few experiments were conducted to test the chromatographic behavior of valeric (n-pentanoic) and caproic (n-hexanoic) acids. The results obtained demonstrate the potential of the new separation method for preparative purposes.     

量子化学计算预测高效液相色谱键合相的保留机理

本文用Gaussian98计算软件中的Hartree—Fock方法对高效液相色谱中溶质与固定相发生作用后产生的能量进行计算,并对溶质与C18键合相和苯胺甲基键合相相互作用的计算结果与实验结论进行了比较。结果表明,量化计算结果与色谱保留行为之间具有相关性,即分子间相互作用能量的高低,决定了保留值的大小,表现为能量越负,保留值越大,而且双倍键合量的能量低于单倍键合量。量化计算的方法将为色谱保留性能的研究和键合相的研制提供参考。     

Gas chromatographic analysis of high-molecular-mass polycyclic aromatic hydrocarbons II. Polycyclic aromatic hydrocarbons with relative molecular masses exceeding 328

Three columns were used for the gas chromatographic analysis of polycyclic aromatic hydrocarbons (PAHs) with relative molecular masses (M_r) up to 450. Two of the columns were commercially available, coated with a 50% methyltrifluoropropyl-substituted polysiloxane a 5% diphenyl-substituted methylpolysiloxane. The third column was laboratory made, coated with a biphenyl-substituted silarylene-siloxane copolymer. All three columns were utilized for the analysis of high-M_r PAHs as regards both thermal stability of the stationary phases, i.e., low bleeding rate, and chromatographic efficiency. The column coated with a trifluoropropyl-substituted stationary phase showed, however, a low separation efficiency, possibly owing to low solute stationary phase compatibility. The biphenyl-substituted stationary phase, on the other hand, showed a very high separation efficiency, but the retention of the PAHs was significantly higher on this column compared with the other two, leading to the demand for higher oven temperatures. Different retention mechanisms were observed on these columns, as shown by differences in the retention indices of the PAHs measured in a system using PAHs as retention index markers. A comparatively faster elution of non-planar PAHs was observed on the columns coated with the trifluoropropyl-substituted stationary phase and the biphenyl-substituted stationary phase compared with the column coated with the 5% diphenyl-substituted polymer. The usefulness of the columns for separations of high-M_r PAHs is demonstrated by gas chromatograms of carbon black extracts and a coal tar extract standard reference material.